2004 Cadillac Escalade ESV Technical Service Bulletins

461 technical service bulletins (TSBs) are on record for the 2004 Cadillac Escalade ESV. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10112641Dec 12, 2012Engine cooling. This Preliminary Information communication provides information to the technician that fluid contamination may be directed to one of the following testing centers according to the type of fluid needing testing. Dealer should send the correct fluid to the proper testing center.
• 10113837Dec 7, 2012Equipment. This informational bulletin provides a list off all the issues revolving around new vehicles for a one stop place to find growing concerns around them.
• 10126163Nov 30, 2012Electrical system. This informational bulletin provides information regarding the aftermarket device interference with onstar diagnostic service.
• 10138218Nov 29, 2012Electrical system, Equipment. This informational bulletin provides information regarding the inappropriate warranty claims submitted for damaged radios and instrument panel clusters, provides exampls on whats an acceptable for warranty and whats not
• 10137476Nov 29, 2012Electrical system, Equipment. This informational bulletin provides information regarding the inappropriate warranty claims submitted for damaged radios and instrument panel clusters, provides exampls on whats an acceptable for warranty and whats not
• 10112614Nov 29, 2012Equipment. This Preliminary Information communication provides information to the technician about customers may inquire about the availability of the passenger compartment air filter. Dealer should advise the customer starting in 2003 the passenger compartment air filter is no longer available as a factory option.
• 10126171Nov 28, 2012Equipment. This informational bulletin provides a step by step procedure on how to properly use the GM chemicals to eliminate unwanted odors in vehicles and which products to use for each application.
• 10112607Nov 28, 2012Equipment. This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Technical Assistance Center with the scan tool data from the OnStar system.
• 10112600Nov 26, 2012Transmission and drivetrain. This Preliminary Information communication provides information to the technician with the axel setup information from American Axle Manufacturing. Technician should be advised that the maximum pinion shim to be used or stacked behind the pinion is 0.050?, and the minimum pinion shim is 0.020? for an 8.6 axle. The range for available pinion depth shims for the 10.5? axle is 0.006? to 0.024?. When setting the…
• 10138211Nov 20, 2012Equipment. This warranty administration bulletin provides information regarding customer concerns not duplicated and which labor operations to claim when the concern cannot be duplicated. Also provides information on how to submit claims within the global warranty managment.
• 10137469Nov 20, 2012Equipment. This warranty administration bulletin provides information regarding customer concerns not duplicated and which labor operations to claim when the concern cannot be duplicated. Also provides information on how to submit claims within the global warranty managment.
• 10138201Nov 13, 2012Equipment. This informational bulletin provides information and rules for GM keycode look up applicationa dn the key code security rules and regulations for Canada only.
• 10137459Nov 13, 2012Equipment. This informational bulletin provides information and rules for GM keycode look up applicationa dn the key code security rules and regulations for Canada only.
• 10137458Nov 13, 2012Equipment. This informational bulletin provides information for requesting a new key code for customers with lost or stolen keys
• 10126196Nov 13, 2012Equipment. This informational bulletin provides information and rules for GM keycode look up applicationa dn the key code security rules and regulations for Canada only.
• 10126200Nov 12, 2012Equipment. This informational bulletin provides a single point reference and strategy document to aid in reducing customer comebacks, and the possibility of buyback situations by outlining specific guidelines, strategy and forms that will assist with this goal, by identifying, clarifying and documenting customer concerns accurately at each service visit.
• 10126198Nov 12, 2012Equipment. This informational bulletin provides a list of newly released PI and Bulletins in regards to recent released vehicles so that vehicles can be fixed right the first time in for service.
• 10112560Nov 9, 2012Brakes. This Preliminary Information communication provides information to the technician about brake rotors on new vehicles and replacement parts from General Motors Service Parts Operations. Technician should be advised the costing should not be removed from the brake rotor it will wear off with normal brake usage. Dealer should communicate to the customer this condition is a normal operating characteristic of their…
• 10112546Nov 6, 2012Brakes. This Preliminary Information communication advises the technician that the Hydro-Boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.
• 10112544Nov 6, 2012Steering, Brakes. This Preliminary Information communication provides information to the technician about vehicles that may have a power steering pump whine noise. Technician will need to flush and refill the power steering system with Lucas Power Steering Fluid with Conditioners. Technician will replace the power steering pump with the latest design if the fluid is not available.
• 10138187Nov 5, 2012Equipment. This preliminary informational bulletin provides a revision for PI0688C to add the 2013 model year and update the Parts Information.
• 10137444Nov 5, 2012Equipment. This preliminary informational bulletin provides a revision for PI0688C to add the 2013 model year and update the Parts Information.
• 10112528Nov 1, 2012Electrical system. This Preliminary Information communication provides information to the technician about vehicles that during battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the OnStar system. Technician should understand the power cycles of the various OnStar systems. All Generation 6, 7, 8, and 9 systems are powered up continuously for 48 hours from ignition…
• 10112523Oct 30, 2012Transmission and drivetrain, Electrical system. This Preliminary Information communication provides information to the technician about vehicles that have slip in forward ranges immediately after replacing the input housing. Technician will inspect the 3-4 clutches and the forward clutch oil feed passages for leakage between circuits. Technician should apply regulated compressed air to the 3-4 clutch feed hole and the forward clutch feed hole one at a time with…
• 10112519Oct 29, 2012Suspension, Wheels. This Preliminary Information communication provides information to the technician about vehicles that have grease leaking from front hub bearings. Technician should not replace the bearing for grease purge. Technician should be advised to not clean the purged grease from the area immediately on or adjacent to the seals because this grease provides additional protection.
• 10112494Oct 18, 2012Equipment. This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts. Technician can check Service Information for some accessories. Technician can also contact Partech for assistance.
• 10112468Oct 12, 2012Visibility (wipers, defrost, mirrors). This Preliminary Information communication provides information to the technician about the percentage of Ultraviolet protection or tint offered by the windshield or side glass. Technician should be advised Windshield reduces Ultraviolet rays down to 4% or less. Front side door glass reduces Ultraviolet rays down to 35% or less. Windshields are SOLAR glass with a light transmittance of >/=70%. Front door glass are…
• 10118626Oct 10, 2012Equipment. This warranty administrational bulletin provides information on Clarification of Use - Dealer Empowerment Labor Operations and Customer Enthusiasm
• 10118619Oct 5, 2012Equipment. This informational bulletin provides information on newly release bulletins used to fi the vehicles in the field the first time.
• 10246951Oct 1, 2012Equipment. Programming And Activation Of Replacement OnStar Modules.
• 10043536Apr 1, 2012Equipment. Buick/cadillac/chevrolet/gmc/oldsmobile: if blower motor is set to any speed position and when key is off, it becomes inoperative and may still be inoperative after key is turned on. *pe updated on 5/1/12.
• 10037570Apr 1, 2012Body and structure. Gm: on some truck models there is some frame corrosion. *rm updated on 5/2/2012.
• 10036545Oct 1, 2010Steering. Buick/cadillac/chevrolet/gmc/oldsmobile and hummer: information on pitman arm shaft seal service kit. Do not replace entire steering gear for pitman seal leak. Technicians have been replacing entire steering gears due to not being able to service just leaking pitman shaft seal. *pe updated 5/9/11.
• 10027804Nov 1, 2008Equipment, Electrical system. General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09.
• 10026804Oct 1, 2008Transmission and drivetrain. Gmc: fluid leak from transmission oil cooler lines due to corrosion. All 2000-2006 light duty trucks equipped with the light duty automatic transmission.
• 10025770Sep 5, 2008Equipment. Some customers may comment on various hvac concerns including temperature doors defaulting to full hot position or unable to obtain defrost position.
• 10026542Sep 1, 2008Electrical system. Cadillac chevrolet gmc service campaign: see document search button for owner letter. Some vehicles could develop a condition where one or more of the instrument panel gauge needles may stick, flutter, or become inoperative. Csc letter received. Updated 11/6/08.
• 10023585Sep 1, 2008Electrical system. Cadillac chevrolet gmc service campaign: see document search button for owner letter. Instrument panel cluster gauge needle function may cause inaccurate readings on some 2003-2004 cadillac, chevrolet, and gmc vehicles. *nj updated 2/5/08. *nj updated 9/5/08. *pe updated 11/4/08.
• 10026704Aug 1, 2008Fuel system. Gmc: fuel gauge fluctuation in park or neutral, causing the low fuel light to illuminate.
• 10026744Jun 1, 2008Seats, Electrical system. Gmc: sir mil dtc b0084 and/or b0085. This concern could be caused by broken seat position sensor circuits under the driver or passenger front seats. Over time, from repeated seat movement, the wiring could break.
• 10026586Jun 1, 2008Equipment. Buick cadillac chevrolet gmc hummer oldsmobile pontiac saab saturn service campaign: see document search button for owner letter. Special coverage adjustment-analog onstar deactivation. Fcc ruled in 2002 wireless carriers would no longer re required to support analog wireless network starting in 2008. *pe csc letter was received. Updated 12/1/08.
• 10024345Feb 1, 2008Transmission and drivetrain, Suspension. Eaton locking differential chatter shudder noise on turns, equipped with a locking rear differential rpo g80. *nj updated 7/17/2008.
• 10024342Feb 1, 2008Tires. Low tire light on and/or dic check tire pressure message when cold, with rpo uj6.
• 10022766Sep 26, 2007Electrical system. Blown mbec 1 or lbec 1 fuse.
• 10022482Aug 15, 2007Electrical system. Additional diagnostic for yaw/lat sensor dtc's.
• 10021673Jun 15, 2007Interior lighting. Ipc backlighting inoperative tbc 2a fuse open.
• 10022470Jun 1, 2007Brakes. Abs light on, dtc's c0265, c0201, u1041 set and/or loss of communication with brake module. (reground ebcm ground).
• 10022260Apr 1, 2007Engine cooling. Front blower motor inoperative or may not shut off in extremely low ambient temperature conditions.
• 10017123Oct 25, 2005Visibility (wipers, defrost, mirrors). Service vme-outside rear view mirror inoperative.
• 10016821Oct 12, 2005Electrical system. Bulletin-sit-bulletin-1656326: pit3569. Low tire light on and or dic check tire pressure message when cold.

← All problems reported for the 2004 Cadillac Escalade ESV