2004 Cadillac XLR Technical Service Bulletins

462 technical service bulletins (TSBs) are on record for the 2004 Cadillac XLR. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10246951Oct 1, 2012Equipment. Programming And Activation Of Replacement OnStar Modules.
• 10038294Jan 1, 2012Seat belts. Gm: there are seat belt problems: difficulty latching and unlatching buckle. Buckle release button is sticking. Seat belt warning light illuminated. Likely caused by sticky beverages that are spilled into the buckle assembly. *rm updated 4/3/12.
• 10038295Feb 1, 2011Other or unknown. Gm: information on fixing multiple situations right the first time.
• 10037131Oct 1, 2010Fuel system. Gm: the fuel gauge may show empty when there is still gas in the tank. Vehicles may also run out of gas with the fuel gauge at half-full.
• 10036404Sep 1, 2010Electrical system, Engine cooling. Cadillac: intermittent ses light due to dtcs p0068, p0101, and/or p1101. This may not have been a concern until recent repairs were performed that may have affected air flow or ecm programming.
• 10034684Aug 1, 2010Fuel system. Cadillac chevrolet service campaign: see document search button for owner letter. A fuel tank leak at quick connectors that are used to link the left and right fuel tanks. If leak becomes large enough, a small amount of fuel may be observed dripping on the ground. Csc letter was received.
• 10027804Nov 1, 2008Equipment, Electrical system. General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09.
• 10016945Sep 30, 2008Transmission and drivetrain. Rear axle chatter shudder on turns. *sc updated. *kb updated 9/30/08.
• 10026586Jun 1, 2008Equipment. Buick cadillac chevrolet gmc hummer oldsmobile pontiac saab saturn service campaign: see document search button for owner letter. Special coverage adjustment-analog onstar deactivation. Fcc ruled in 2002 wireless carriers would no longer re required to support analog wireless network starting in 2008. *pe csc letter was received. Updated 12/1/08.
• 10022263Jan 1, 2008Transmission and drivetrain. Rear axle clunk and/or chatter type noise on turns (drain/refill rear differential fluid). *kb updated 4/11/08.
• 10023737Dec 1, 2007Other or unknown. Pop or creak noise from rear of vehicle behind the seats.
• 10019477Oct 1, 2007Steering. Diagnostic trouble code (dtc) c0710 steering wheel position sensor (swps) signal, service stability system message on driver information center (dic). *tt updated 2/15/08.
• 10020690Nov 1, 2006Fuel system. Special coverage adjustment-fuel tank cap.
• 10020421Sep 28, 2006Fuel system, Other or unknown. Revised fuel sender values for the chevrolet corvette and cadillac xlr.
• 10020420Sep 28, 2006Body and structure. Deck lid may not stay open to the full open position.
• 10020052Jul 14, 2006Electrical system. Electrical concerns - water leak on the passenger floor or bcm area.
• 10019933Mar 1, 2006Engine cooling. Obd system diagnostics disabled by canister purge solenoid curcuit malfunction - reprogram ecm.
• 10019246Feb 22, 2006Steering. Service vme-power steering leak at high pressure hose connection to pump.
• 10019204Feb 17, 2006Steering. Service vme-power steering leak a thigh pressure hose connection to pump.
• 10018555Jan 6, 2006Visibility (wipers, defrost, mirrors). Wipers will not park.
• 10017696Nov 21, 2005Electrical system. Various electrical problems with a cell phone charger plugged in.
• 10018743Nov 1, 2005Transmission and drivetrain. Rear wheel drive shaft nut torque specification requirements and information on replacement shafts for service.
• 10017276Nov 1, 2005Fuel system. Service vme - fuel gauge erratic or defaults to empty.
• 10017185Oct 27, 2005Transmission and drivetrain. 5l40e/5l50e fluid leak from bell housing area.
• 10017181Oct 27, 2005Visibility (wipers, defrost, mirrors). Indexing door glass that appears to be stuck or inoperative.
• 10017159Oct 27, 2005Visibility (wipers, defrost, mirrors). Quarter glass window separates from attaching bracket.
• 10017146Oct 26, 2005Vehicle speed control. Tcc surge, shudder or chuggle on light load just after torque converter clutch engagement with transmission at operating temperature.
• 10017126Oct 25, 2005Transmission and drivetrain. Unable to move gear shift lever out of park at times.
• 10017118Oct 25, 2005Transmission and drivetrain. No crank, transmission range indicator inoperative.
• 10016708Sep 28, 2005Transmission and drivetrain. The 5l40e and 5l50e automatic transmission may experience a condition of high tcc slip speed and or dtc p0741. *tt updated 09-26-07.
• 10016561Sep 22, 2005Tires. Unable to program tire pressure sensors.
• 10016537Sep 21, 2005Body and structure. Trunk inoperative at times.
• 10018137Sep 1, 2005Body and structure. Interior of the vehicle is turning pink. Gm. Tech link.
• 10018126Sep 1, 2005Engine cooling. Oil life system reset procedures - cars. Gm tech link.
• 10017379Aug 1, 2005Electrical system. Remote keyless entry (rke) system does not function properly, poor rke performance.
• 10017536Jun 1, 2005Fuel system, Other or unknown. Erratic fuel gauge readings, fuel gauge reads empty when there is fuel in tank, diagnostic trouble code p0463 set, service fuel system message displayed.
• 10014950May 12, 2005Equipment. Floor mat rear compartment divider retainers.
• 10014918May 12, 2005Fuel system, Other or unknown. Erratic fuel gauge - service vme.
• 10014887May 11, 2005Steering. Telescoping steering wheel inoperative.
• 10014862May 11, 2005Electrical system. Sir lamp on with a diagnostic trouble code (dtc) b1001 set in the sdm.
• 10014858May 11, 2005Brakes. Anti-lock braking system (abs) lamp on with a diagnostic trouble code (dtc) c0820 set in the electronic brake control module (ebcm).
• 10017408May 1, 2005Engine cooling. Engine oil leak from front of vehicle.
• 10013549Apr 21, 2005Suspension. Lower rear shock attaching bolt may break after torqued.
• 10017344Apr 1, 2005Suspension. Revised front and rear ball joint stud nut tightening specifications.
• 10017340Apr 1, 2005Tires. Tire pressure monitoring (tpm) system - tire mounting and dismounting.
• 10015040Mar 1, 2005Body and structure. Availability of floor mat/rear compartment divider retainers.
• 10015013Mar 1, 2005Exterior lighting. High intensity discharge (hid) headlamps - disposal instructions.
• 10011694Jan 28, 2005Transmission and drivetrain. No forth and fifth gear possible codes p0700 p0741 p0762.
• 10011599Jan 27, 2005Electrical system. Charge system fault message.
• 10015762Jan 1, 2005Fuel system, Other or unknown. Fuel filter replacement. Gm tech link.

← All problems reported for the 2004 Cadillac XLR