2007 Chevrolet Aveo Recalls

NHTSA lists 2 recall campaigns for the 2007 Chevrolet Aveo. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.

• 14V261000May 19, 2014218,000 vehicles potentially affected
  Exterior lighting › Headlights
  Covers: Chevrolet Aveo 2004–2008

  Reported issue: General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.

  Possible consequence: If the DRL module melts due to the heat generation, it could cause a vehicle fire.

  Remedy: GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020…

  Full campaign details →

• 06V398000Oct 17, 200617,676 vehicles potentially affected
  Fuel system, gasoline
  Covers: Chevrolet Aveo 2007

  Reported issue: On certain passenger vehicles equipped with a 1.6l engine, during a ncap severe frontal crash test, the fuel line in the engine compartment developed a fracture. In addition, the crash damage caused four short circuits in the fuse block, the combination of which allowed the fuel pump to continue running and fuel leaked onto the ground.

  Possible consequence: If these conditions occurred in an actual crash, a vehicle fire could occur.

  Remedy: Dealers will replace the fuse block and install a new section of fuel line that has been redesigned free of charge. The recall began on november 16, 2006. Owners may contact chevrolet at 1-800-630-2438.

  Full campaign details →

← All problems reported for the 2007 Chevrolet Aveo