1995 Chevrolet C30 Recalls

NHTSA lists 7 recall campaigns for the 1995 Chevrolet C30. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.

• 97V037000Mar 7, 1997624,433 vehicles potentially affected
  Seats
  Covers: Chevrolet C30 1995–1997, C10 1995–1997, C20 1995–1997 +6 more

  Reported issue: Vehicle description: extended cab and 2-door utility vehicles equipped with reclining seats and the easy-entry feature. These vehicles exhibit a condition in which a pinch point exists in the recliner mechanism that can trap and pinch a person's hand or finger(s) when the easy-entry feature is activated.

  Possible consequence: This pinching can cut the hand or possibly sever the finger(s) without prior warning.

  Remedy: Dealers will install a protector cover over the recliner mechanism.

  Full campaign details →

• 96V117000Jul 1, 19965,773 vehicles potentially affected
  Tires › Bead
  Covers: Chevrolet C30 1995–1996, GMC G35 1995–1996, Chevrolet G30 1995–1996 +3 more

  Reported issue: These tires have bead damage which occured during tire mounting.

  Possible consequence: This damage to the tire reinforcing structure in the bead "toe" area causes a bulge in the sidewall after the tire is inflated. This condition will result in a slow air loss causing the tire to go flat. However, it is possible for the damage to result in a rapid air loss causing injuries to anyone if they were…

  Remedy: Dealers will demount each tire and inspect for bead damage. If bead damage is found, the tire will be replaced.

  Full campaign details →

• 96V057000Apr 4, 1996379,004 vehicles potentially affected
  Vehicle speed control
  Covers: Chevrolet C30 1995–1996, Suburban 1995–1996, GMC Suburban 1995–1996 +11 more

  Reported issue: These vehicles were assembled with the throttle cable contacting the dash mat which could bind the throttle. This does not meet with the maximum return times required by federal motor vehicle safety standard no. 124, "accelerator control systems."

  Possible consequence: Consequence of non-compliance: the engine speed may not return to idle increasing the potential for a vehicle accident.

  Remedy: Dealers will inspect for adequate throttle cable to dash mat clearance, and if there is insufficient clearance, cut out a portion of the dash mat to provide proper clearance.

  Full campaign details →

• 96V004000Jan 2, 19963,047 vehicles potentially affected
  Steering › Steering wheel/handle bar
  Covers: Chevrolet C30 1995, GMC C15 1995, Chevrolet C10 1995 +3 more

  Reported issue: The steering column upper intermediate-shaft nut may not be torqued to proper specifications. The nut could loosen and detach allowing the through-bolt that secures the upper intermediate-shaft to the lower steering column shaft joint to fall out.

  Possible consequence: This loose engagement can provide noticeable noise and abnormal steering feeling to the driver and, if left unattended, the steering shafts can separate resulting in a loss of steering control.

  Remedy: Dealers will torque the suspect fasteners to the proper specifications.

  Full campaign details →

• 95V241000Dec 13, 1995630,099 vehicles potentially affected
  Seat belts › Front
  Covers: Chevrolet C30 1994–1995, GMC C15 1994–1995, Chevrolet C20 1994–1995 +4 more

  Reported issue: If both the lap-belt and shoulder-belt energy management loops on the front seat belt assemblies release at or near the same time, acceleration forces can cause the buckle release mechanism to activate and allow the buckle to separate from the latch.

  Possible consequence: If the buckle released, the system would fail to provide adequate occupant restraint protection.

  Remedy: Dealers will remove the stitching that creates the energy management loop in the shoulder belt(s).

  Full campaign details →

• 95V242000Dec 13, 199540 vehicles potentially affected
  Seat belts › Front
  Covers: Chevrolet C30 1994–1995, GMC C15 1994–1995, Chevrolet C20 1994–1995 +4 more

  Reported issue: These vehicles were built with front seat belt systems with no energy management loops and may not meet the head injury criteria requirements of fmvss no. 208, "occupant crash protection."

  Possible consequence: In the event of a vehicle crash, the occupants of these seats may not be properly restrained.

  Remedy: Dealers will replace the retractor portion of the seat belt assembly(s) with one having the newly designed energy-management twin-loop system.

  Full campaign details →

• 95V026000Feb 16, 199513,853 vehicles potentially affected
  Power train › Automatic transmission › Cooling unit and lines
  Covers: Chevrolet C30 1995, Suburban 1995, GMC Suburban 1995 +13 more

  Reported issue: Due to a thin case casting, an external transmission leak can occur.

  Possible consequence: This condition can cause transmission oil to sprayonto the exhaust system and result in a possible vehicle fire.

  Remedy: Dealers will inspect the transmission case assembly for the involved case casting. If the assembly is involved, the transmission will be replaced.

  Full campaign details →

← All problems reported for the 1995 Chevrolet C30