2018 Chevrolet Equinox Technical Service Bulletins

1,338 technical service bulletins (TSBs) are on record for the 2018 Chevrolet Equinox. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10134578Oct 11, 2017Engine cooling. This informational bulletin explains a normal small exhaust leak and residual build up on the EGR housing.
• 10134608Oct 10, 2017Equipment. This technical bulletin provides a procedure to reprogram the radio to correct a condition of DTC B1265 Entertainment System Remote Enable Circuit due to a calibration concern.
• 10123227Oct 5, 2017Electrical system. This Preliminary Information communication provides information to the technician about vehicles that have a Diagnostic Trouble Code B101D-37 history in the Vehicle Communication Interface Module or telematics communication interface control module. Engineering has determined that this code will only display in history on the scan tool and will not cause issues with OnStar system operation.
• 10134574Oct 4, 2017Transmission and drivetrain. This informational bulletin advised the technician not to do anything about the DTC set.
• 10134595Oct 3, 2017Electrical system, Equipment. This informational bulletin provides information on approved warranty part numbers for original equipment batteries
• 10123222Oct 3, 2017Equipment, Electrical system. This Preliminary Information communication provides information to the technician about what XM offerings are available for vehicles. A dealer or customer can access the website listed below for vehicle specific XM offerings and availability.
• 10190339Oct 1, 2017Equipment, Electrical system. Original Equipment Batteries Part Number and ACDelco Replacement Battery Approved Warranty Part Numbers Correct battery cold cranking amperage (CCA) ratings and type are critical for proper test results when using the EL-50313. Access to the battery specification label, which contains the OEM part number and CCA rating and type, may be difficult without component removal. Refer to the table below for the original…
• 10190338Oct 1, 2017Equipment. Essential Tools that Include Consumable Parts (U.S. Only)
• 10190337Oct 1, 2017Suspension. Information Regarding the Differences Between Fluid Leakage and Seepage This bulletin is intended to help identify the differences between what is considered a fluid leak and what is considered seepage. Improper diagnosis may lead to unnecessary component replacement. Use the following information to determine if the condition is normal acceptable seepage or a defective component
• 10190329Oct 1, 2017Equipment, Back-over prevention (rear camera). Rear View Camera Guidelines Not Present at Times Condition Some customers may report that the Rear View Camera (RVC) guidelines are temporarily not available at times but the RVC will remain on during the concern. Additionally, no related DTCs will be found if this bulletin applies. One example of when this concern may be observed is if a customer quickly starts the car and immediately places the shifter in Reverse…
• 10190328Oct 1, 2017Engine cooling, Visibility (wipers, defrost, mirrors). Engineering Information – Interior Coolant Leak at Heater Core Inlet/Outlet Tubes
• 10190320Oct 1, 2017Electrical system, Equipment. IPC Odometer Programming Method Quick Reference Guide
• 10190318Oct 1, 2017Electrical system. All or Some Options May Be Missing from Driver Information Center (DIC) “Info Pages” Menu Due to Them Not Being Selected Condition Some customers may comment that with the “Info” option selected from the main menu (1), the “Info Pages” are blank (2) when scrolling up and down.
• 10190317Oct 1, 2017Engine cooling. Information on Diesel Engine Soot Deposits at the Variable Turbine Geometry (VGT) Pin Condition Some customers may comment that combustion deposits or soot (1) can be seen coming from the Turbo Actuator Pin/Arm (2). Information This is normal operation and will not affect the function of the Turbocharger. There is a small gap between the seal and the shaft to allow for proper rotation. Do Not replace the…
• 10190312Oct 1, 2017Brakes. Rear Brake Squeak Type Noise Condition Some customers may comment on a squeak type noise heard from the rear brakes when cold. This noise will typically occur on first brake apply when the brakes are cold. Note: This condition may not be duplicated if the brakes are warm. Correction Replace the rear brake pads
• 10190305Oct 1, 2017Equipment, Electrical system. DTC B1265 Entertainment System Remote Enable Circuit Condition Some customers may comment on a malfunction indicator lamp illuminated. During diagnosis a technician may find DTC B1265 present or stored in history. Cause This may be due to an incorrect calibration loaded into the vehicle at assembly. Correction Reprogram the radio with the latest calibrations.
• 10190271Oct 1, 2017Equipment. Flutter or Thump Noise from Rear of Vehicle Condition Some customers may comment on hearing a flutter or thump noise from the rear of the vehicle. The noise is most noticeable while driving above 40 km/h (25 mph), with the HVAC off, or in recirculation mode Cause The cause of the condition may be the rear pressure relief valves (PRVs) opening and closing.
• 10190268Oct 1, 2017Engine cooling. Information on Traces of EGR Cooler Housing Actuator Exhaust Residue Seen in Colder Climates Some customers may comment that exhaust residue (2) can be seen condensing onto the aluminum housing of the EGR assembly, making it appear as if the bypass actuator arm seal (1) has failed
• 10190263Oct 1, 2017Equipment, Electrical system. Information on Chassis Control Module (CCM) Receives Invalid Data and Sets DTC U0422 The Technician may find DTCs U0422 set. The Technician may also find the following DTCs set. • U1534 • U1538 Information Based on analysis with the BCM team, during vehicle startup (on occasion) the PEPS module arbitration along with high bus traffic leads to the BCM setting the door open switch virtual device availability (VDA) to…
• 10190232Oct 1, 2017Transmission and drivetrain. Information on Chassis Control Module (CCM) and Hybrid Powertrain Control Module (HPCM) Receives Invalid Data and Sets DTC U0422 The technician may find DTC U0422 set.
• 10190231Oct 1, 2017Equipment, Electrical system. Intermittent Operation of Key Fobs, Door Unlock Inoperative “No Remote Detected” Message with Possible TPM MIL Some customers may comment on intermittent loss of Key Fob and/or Passive Entry, Passive Start functions. This may be accompanied with a “No Remote Detected” message on the DIC.
• 10159627Sep 29, 2017Electrical system. This technical bulletin provides a procedure to repair the shutter harness if corrosion is found in the electrical connection.
• 10157043Sep 28, 2017Engine cooling. This Preliminary Information communication provides the technician with the diagnosis and repair steps for a vehicle with a check engine light on with Diagnostic Trouble Code P015B or a reduced engine power message with Diagnostic Trouble Code P1101. Technician should look for a missing or damaged O-ring seal in the charge air cooler coupler.
• 10157041Sep 28, 2017Electrical system. This Preliminary Information communication provides information to the technician about vehicles that have a Diagnostic Trouble Code B101D stored in Telematics Communication Interface Control Module. Technician will use Global Diagnostic System 2 to review the Firmware Over-the-Air version. If the Firmware Over-the-Air version on the scan tool equals 6708 the technician will need to contact General Motors Technical…
• 10157035Sep 25, 2017Engine cooling. This Preliminary information communicates the need to replace the heater hose clamps anytime the heater hoses are serviced.
• 10159599Sep 22, 2017Suspension. This informational bulletin provides information on RDM Axle Ratios for AWD Vehicles for Vibration Diagnostics When Using the Pico Scope
• 10159633Sep 20, 2017Suspension, Wheels, Tires. This engineering informational bulletin is requesting information from the field on vehicles that have the condition of Engineering Information ? Vehicle Vibration when Driving on Smooth Roads at Speeds Between 64 - 113 kph (40 - 70 mph).
• 10159617Sep 20, 2017Equipment, Engine cooling. This informational bulletin explains to the technician to erase the code P2598 set during PDI.
• 10159616Sep 20, 2017Equipment. This informational bulletin is informing technicians and customers if they experience Low Volume On Back Up Warning that it can be resolved through the settings of the alerts.
• 10159570Sep 20, 2017Electrical system. This warranty administration bulletin provides policy information on the requirements for battery testing and warranty replacements.
• 10157020Sep 20, 2017Equipment, Electrical system. This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking tension or probing the .64 series terminals. The test probe terminal has been released in the terminal repair kit (J-38125-620H) located in Lear Tray 7 part number 963716-2.
• 10159613Sep 19, 2017Electrical system. This informational bulletin provides information for programming the low speed LAN module due to the mirrors memory position reverse tilt position is inoperative.
• 10157016Sep 19, 2017Equipment, Engine cooling. This Preliminary Information communication provides the technician with the diagnosis and repair steps for a vehicle with a check engine light on with Diagnostic Trouble Code P015B or a reduced engine power message with Diagnostic Trouble Code P1101. Technician should look for a missing or damaged O-ring seal in the charge air cooler coupler.
• 10157014Sep 18, 2017Fuel system, Engine. This Preliminary Information communication provides information to the technician about vehicles that may have a hard start, no start, rough running, or low fuel pressure. Technician may find Diagnostic Trouble Codes P0087, P0088, P0191 and P128E during the inspection. If during the inspection of the fuel system contamination is found the complete fuel system will need to be cleaned and flushed. After the fuel…
• 10159575Sep 14, 2017Electrical system. This warranty admin bulletin explains to the technician additional information may be needed when submitting transactions when doing wiring repairs.
• 10159572Sep 14, 2017Equipment. This informational bulletin explains the importance of maintaining the vehicle.
• 10157003Sep 13, 2017Equipment, Engine cooling. This Preliminary information communicates the possibility of the timing chain tensioner gasket being improperly installed or mis-positioned after major engine repairs causing a low engine oil pressure and dtc p06DE.
• 10159605Sep 12, 2017Equipment, Electrical system. This informational bulletin provides information on False Current DTC U15F1 Stored in the HMI (Human Machine Interface) Module and that nothing should be done about this concern.
• 10159569Sep 12, 2017Engine cooling, Equipment. This informational bulletin advises the possible issues that may occur using a scotch brite pad or highly abrasive disk on gasket sealing surfaces or reused parts.
• 10157000Sep 12, 2017Engine, Equipment. This Preliminary information communicates the following to the dealer. If an engine oil leak has been isolated to the front crankshaft seal, check for misfires low engine compression and/or cylinder leakage readings. These issues could cause excessive positive crankcase pressure leading to engine oil leaks.
• 10156999Sep 11, 2017Equipment. This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Technical Assistance Center with the scan tool data from the OnStar system.
• 10159290Sep 8, 2017Engine, Transmission and drivetrain. 17279 - Service Update. Certain vehicles were assembled with engine/transmission mount bolt torques that do not apply sufficient clamp load to securely attach the mounts to the powertrain. In each case, only one of the bolts used to attach the driver side or passenger side mounts are affected. The second and third bolts should reach their intended torque. Dealers are to replace all bolts from the transmission and…
• 10159578Sep 7, 2017Electrical system, Equipment. This informational bulletin provides information on approved warranty part numbers for original equipment batteries
• 10159600Sep 6, 2017Equipment. This technical bulletin provides a procedure to reprogram the radio to correct a condition of a false set DTC due to a software anomaly.
• 10159588Sep 6, 2017Engine cooling. This informational bulletin provides information on a Service Emission System Message and/or a Malfunction Indicator Lamp illuminated. This usually occurs after recently filling the DEF tank with the ignition in the on position due to some DEF fill equipment uses pumps that create a high level of temporary aeration of the DEF fluid being dispensed in the tank.
• 10156992Sep 6, 2017Fuel system, Engine cooling. This Preliminary Information communication provides information to the technician that some vehicle may have an “ Exhaust Fluid Quality Poor ” on the Driver Information Center or a diesel exhaust fluid warning lamp on or other exhaust fluid quality related concerns. Technician will inspect the diesel exhaust fluid for contamination.
• 10156990Sep 6, 2017Equipment. This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts/kits. Technicians should refer to Service Information for information regarding most accessories. Technicians may also contact Partech and/or the Techline Customer Support Center for additional support.
• 10159574Sep 5, 2017Engine. This informational bulletin provides information on Internal Engine Noise or Damage After Oil Filter Replacement.
• 10140304Aug 31, 2017Engine cooling. This Technical bulletin provides a procedure on how to perform a quick test to check if the DPF is the cause of excessive soot from the tailpipe.
• 10140293Aug 31, 2017Engine cooling. This informational bulletin provides information on Intake Manifold Inspection/Replacement After Severe Internal Engine Damage.

← All problems reported for the 2018 Chevrolet Equinox