2014 Chevrolet Malibu Technical Service Bulletins

1,727 technical service bulletins (TSBs) are on record for the 2014 Chevrolet Malibu. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10126062Jul 11, 2016Brakes. This informational bulletin provides information on installing the correct tires for vehicles with the condition of under hard acceleration at higher speeds, the traction control light will flash. Or, they may come in for ABS or general handling/braking concerns.
• 10100822Jul 11, 2016Engine. This informational bulletin provides the technician with what may happen to an engine due to lack of maintenance.
• 10089121Jun 29, 2016Tires, Equipment. This informational bulletin provides guidance to gm dealers when using gm approved tire force variation measurement equipment.
• 10113951Jun 21, 2016Equipment. This Preliminary Information communication provides information to the technician with a diagnostic tip for navigation radios that have inaccurate entries at times when using the voice recognition to input the address. When using the Navigation command "Address" or "Destination" this Allows an address to be stated as a one-shot method. When using the Navigation command "Directed Address" this Allows an address to…
• 10080901Jun 21, 2016Other or unknown, Brakes. This preliminary information communication provides information to the technician on how to diagnose and repair vehicles that may have the antilock braking system, service traction control system, and/or service stabilitrak lights are on. The electronic brake control module may have one or more of the following diagnostic trouble codes c0035-c0050 with specifically symptom 18, 5a, or 0f. Technician will gain access…
• 10081363Jun 20, 2016Steering. This technical bulletin provides a procedure to reprogram the power steering control module to correct the condition of a notchy or sticky feeling in the steering wheel near the center position.
• 10094782Jun 17, 2016Steering. This preliminary informational bulletin provides a procedure to replace the power steering fuse for a condition of loss of power steering assist and/or service power steering message displayed.
• 10089228Jun 17, 2016Equipment. This technical bulletin provides a procedure to remove the transport mode on message displayed in the dic due to vehicles shipped over long distances outside the u.s. And canada.
• 10081022Jun 14, 2016Electrical system. This preliminary information communication advises the technician that ,when testing any circuit for open or resistance, it is imperative that all related terminal pin fit and tension be checked when the test steps require disconnection of the connector or component, prior to any component replacement. Always use the recommended terminal test tool during these tests.
• 10089254Jun 10, 2016Seats. This technical bulletin provides a procedure to install a clip on the seat frame to eliminate a noise originating from the seat pan and seat frame coming in contact.
• 10089247Jun 10, 2016Equipment. This informational bulletin provides information on the proper use of floor mats.
• 10080687Jun 10, 2016Electrical system. This preliminary information communication advises the technician eassist drive motor generator battery module parts restriction has ended. To order the eassist drive motor generator battery section dealer will need to call the battery service center.
• 10089201Jun 8, 2016Equipment. This warranty administration bulletin provides policy information on using gm service policies and procedure manual that represent key gm requirements for service operations.
• 10114105May 31, 2016Engine, Electrical system. This informational bulletin provides information on identifying non-GM (aftermarket) engine calibrations for gasoline engines using Tech 2 or GDS 2.
• 10078925May 31, 2016Engine. This preliminary information communication provides information to the technician regarding vehicles equipped with engine regular production option code lea, lcv, and lkw may have a service engine soon lamp with diagnostic trouble code p015a set. If the service information for diagnostic instruction for diagnostic trouble code p015a was completed inspect the engine oil level for being overfilled.
• 10114102May 25, 2016Electrical system. This technical bulletin provides a procedure to reprogram the radio to correct a customer several concerns caused by to an internal software calibration.
• 10114101May 25, 2016Wheels. This informational bulletin updates General Motor's position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening or re-machining. Only cosmetic refinishing of the wheel's coatings, using recommended procedures, is allowed.
• 10078920May 24, 2016Engine, Electrical system. This preliminary information communication provides information to the technician regarding vehicles equipped with engine regular production option code lea, lcv, and lkw may have a service engine soon lamp with diagnostic trouble code p015a set. If the service information for diagnostic instruction for diagnostic trouble code p015a was completed inspect the engine oil level for being overfilled.
• 10118547May 20, 2016Tires. This informational bulletin provides information on the temporary tire flat spotting condition.
• 10114107May 20, 2016Electrical system. This informational bulletin provides information on service programming system (SPS) errors.
• 10078916May 20, 2016Equipment. This preliminary information communication advises the technician to replace the radio if the phone icon is pressed and it will highlight, or highlight and spin, but the radio will not change from that screen.
• 10078885May 17, 2016Engine. This preliminary information communication provides the technician with the diagnosis and repair steps for a vehicle with a check engine light on with diagnostic trouble code p015b or a reduced engine power message with diagnostic trouble code p1101. Technician should look for a missing or damaged o-ring seal in the charge air cooler coupler.
• 10118546May 16, 2016Equipment. This informational bulletin provides information on a new U.S. dealer special tool loan program.
• 10118545May 16, 2016Electrical system, Equipment. This informational bulletin provides warranty policy information on revised wiring repair labor operations and required additional information.
• 10134545May 13, 2016Electrical system. This informational bulletin provides warranty information on accessory power outlet and trailer lighting fuse replacement.
• 10078874May 10, 2016Equipment. This preliminary information communication advises the technician that a noise or a vibration in the vehicle that seems to be abnormal may not have been there when the vehicle was purchased. Technician should look for non - general motors aftermarket accessories installed on the vehicle that can cause these issues.
• 10134536May 6, 2016Equipment. This warranty administration bulletin provides information on GM?s policy on performing GM covered vehicle services and maintenance on vehicles originating/sold in Canada.
• 10081365May 6, 2016Electrical system. This informational bulletin provides information on the identification of vehicles that are shipped with the transport mode on and how to turn it off.
• 10114113May 5, 2016Engine cooling. This informational bulletin provides information on black smoke and rough idle on cold start.
• 10078872May 4, 2016Body and structure. This preliminary information communication provides the technician with the steps to diagnose and repair the concern of mildew odor or water on front floor on either side of the vehicle. Technician will gain access to the front wheelhouse of the affected side. The front wheel house flange may have a void in the sealer causing water to leak through and accumulate on the floor or wet carpet will be found.
• 10078571May 1, 2016Equipment. This informational bulletin provide information on the product quality center (pqc) assembly replacement process.
• 10078569May 1, 2016Fuel system, Other or unknown. This informational bulletin provides information on vehicles designed to operate on gaseous fuels.
• 10083782Apr 27, 2016Engine, Electrical system. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of black smoke when starting the vehicle after sitting.
• 10083513Apr 27, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. The technician is provided instructions for resetting the vehicle communication interface module for this concern.
• 10078745Apr 27, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. The technician is provided instructions for resetting the vehicle communication interface module for this concern.
• 10083073Apr 26, 2016Electrical system, Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of a dead battery after leaving the vehicle during a bluetooth call.
• 10078743Apr 26, 2016Electrical system. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of a dead battery after leaving the vehicle during a bluetooth call.
• 10078560Apr 25, 2016Steering. This preliminary information bulletin provides a procedure to inspect and replace the steering column seal to correct a customer concern on a rubber squeak type noise when turning the steering wheel due to the seal for the intermediate shaft, located at the front of dash, rubbing on the rotating intermediate steering shaft.
• 10083781Apr 22, 2016Electrical system. This preliminary information communication advises the technician on the steps to diagnose the concern, and the steps to repair the concern of the vehicle cranks but does not start. The technician is to inspect for a sheared cam pin in the engine.
• 10083587Apr 22, 2016Equipment. This preliminary information communication advises the technician to contact the gm technical assistance center for further instructions. The concern is the radio may be unable to save xm favorite stations.
• 10083509Apr 21, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern. The vehicle's xm radio only has xm preveiw channels.
• 10083482Apr 21, 2016Equipment. This preliminary information communication advises the technician to diagnose the concern and the steps to repair the concern. The vehicle's xm travel link may be inopertive.
• 10078522Apr 20, 2016Equipment. "this technical bulletin provides a procedure to contact onstar for hard mute request to correct a customer concern when the radio is on, it does not mute enough when the onstar® turn-by-turn navigation directions are announced due to customer improperly setting the radio volume high enough when the turn-by-turn navigation messages are played. "
• 10078520Apr 20, 2016Electrical system. This informational bulletin provides information that may be useful on diagnosing batteries that have set for a long period of time and/or set in cold weather climates and testing those batteries.
• 10083884Apr 19, 2016Equipment. This preliminary information communication advises the technician on the steps for diagnosing the concern. The vehicle may be unable to connect to onstar using the white, blue or red onstar buttons.
• 10083484Apr 19, 2016Electrical system. This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. When performing battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the onstar system.
• 10078735Apr 19, 2016Electrical system. This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. When performing battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the onstar system.
• 10078507Apr 18, 2016Electrical system, Equipment. This warranty administration bulletin provide policy information on using the el-50313 midtronics gr8 battery tester/charger for diagnosing battery replacements and maintaining batteries on new vehicles in dealer inventory.
• 10078506Apr 18, 2016Electrical system. This informational bulletin provides warranty information on using the service programming system (sps) for programming control modules
• 10078504Apr 18, 2016Engine. This informational bulletin provides information internal engine noise or damage after oil filter replacement

← All problems reported for the 2014 Chevrolet Malibu