2015 Chevrolet Silverado 2500 Technical Service Bulletins

2,387 technical service bulletins (TSBs) are on record for the 2015 Chevrolet Silverado 2500. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10082860Aug 3, 2016Equipment. This informational bulletin provides information on gm does not approve the use of “clipping” to repair collision damage to vehicles. Gm has not tested or validated a “clipped vehicle” repair; therefore, gm cannot endorse this type of repair or confirm the crash performance during a subsequent collision.
• 10083776Aug 2, 2016Electrical system. This preliminary information communication advises the technician on steps to perform to determine if the customer's battery drain concern is being caused by a known concern with bluetooth call transfer operation when exiting the vehicle. If the concern is duplicated at the dealer with the onstar led is still green after the vehicle is turned off and the bluetooth call was disconnected. Dealer should advises that…
• 10082861Aug 2, 2016Electrical system. This technical bulletin provides a procedure to remove the transport mode on message displayed in the dic due to vehicles shipped over long distances outside the u.s. And canada.
• 10082823Aug 2, 2016Engine cooling. This informational bulletin explains the use of diesel fuel additives in an engine, are not required unless the customer desires additives to prevent fuel concerns depending on fuel or temperature related conditions.
• 10082814Aug 2, 2016Engine. This informational bulletin provides information to gm dealers on the correct cleaning methods when cleaning engine gasket sealing surfaces.
• 10082423Aug 1, 2016Engine cooling. This informational bulletin provides additional information about the def use and treatment of the fluid.
• 10126063Jul 12, 2016Engine. This informational bulletin provides information on intake manifold inspection/replacement after severe internal engine damage.
• 10126062Jul 11, 2016Brakes. This informational bulletin provides information on installing the correct tires for vehicles with the condition of under hard acceleration at higher speeds, the traction control light will flash. Or, they may come in for ABS or general handling/braking concerns.
• 10089121Jun 29, 2016Tires, Equipment. This informational bulletin provides guidance to gm dealers when using gm approved tire force variation measurement equipment.
• 10089001Jun 28, 2016Engine cooling, Equipment. This information bulletin provide information on a new way to look at nox sensor readings and exhaust temperature during a dpf regeneration or a reductant fluid quality test.
• 10074343Jun 28, 2016Transmission and drivetrain. This technical bulletin provides a procedure to replace the stator shaft support to correct customer concern on a delayed engagement when the transmission is shifted from park to reverse or park to drive after the vehicle has been sitting with the engine off due to the torque converter draining the transmission fluid back into the transmission pan.
• 10094768Jun 23, 2016Suspension, Steering, Electrical system. This preliminary informational bulletin provides information on a procedure for diagnosing and repairing vibrations caused by the wheel and tire, axle components and/or propeller shafts.
• 10088863Jun 22, 2016Equipment, Engine cooling. This informational bulletin is a supplement to the duramax diesel coolant system fill and head gasket replacement procedure found in the service information.
• 10081022Jun 14, 2016Electrical system. This preliminary information communication advises the technician that ,when testing any circuit for open or resistance, it is imperative that all related terminal pin fit and tension be checked when the test steps require disconnection of the connector or component, prior to any component replacement. Always use the recommended terminal test tool during these tests.
• 10097195Jun 8, 2016Equipment. This technical bulletin provides a procedure to inspect the air box and air filter seal and replace if necessary to correct a customer concern that the malfunction indicator light (mil) is illuminated due to excessive sand and/or debris entering the air filter box and bypassing the seal of the air filter causing damage to the ho2 sensor and the catalytic converter to become blocked with sand and debris particles.
• 10089201Jun 8, 2016Equipment. This warranty administration bulletin provides policy information on using gm service policies and procedure manual that represent key gm requirements for service operations.
• 10245966Jun 1, 2016Back-over prevention (rear camera). No Audio Except Chime Distorted Or Inoperative Rear Camera -No Audio- Displayed On Audio Page In DIC.
• 10126061May 31, 2016Other or unknown. 15809 - Service Parts Customer Satisfaction Program - Certain Chevrolet Silverado LD and GMC Sierra LD model vehicles equipped with the 12,000 lb. trailering package (RPO Z82) may have been serviced with, or the customer sold over the counter, a trailer hitch platform that could develop cracks at the weld points over time. With heavy towing loads over thousands of miles, these cracks could potentially propagate and…
• 10114105May 31, 2016Engine, Electrical system. This informational bulletin provides information on identifying non-GM (aftermarket) engine calibrations for gasoline engines using Tech 2 or GDS 2.
• 10126060May 27, 2016Electrical system. 15801A - Customer Satisfaction Program. This bulletin is being revised to add a note at the beginning of the Service Information section. The 2016 model year GMC Sierra HD vehicle, and an increase in population has also been added. Vehicles equipped with Duramax Diesel Engine (RPO LGH or LML) and Ambulance Upfitter or Fire Truck Upfitter (RPO YF2 or ANM), may have a condition in which the emission control system as…
• 10114101May 25, 2016Wheels. This informational bulletin updates General Motor's position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening or re-machining. Only cosmetic refinishing of the wheel's coatings, using recommended procedures, is allowed.
• 10118547May 20, 2016Tires. This informational bulletin provides information on the temporary tire flat spotting condition.
• 10114107May 20, 2016Electrical system. This informational bulletin provides information on service programming system (SPS) errors.
• 10126051May 16, 2016Engine, Electrical system. 15801 - Customer Satisfaction Program. (2012 model year repair suspended) Vehicles equipped with Duramax Diesel Engine (RPO LGH or LML) and Ambulance Upfitter or Fire Truck Upfitter (RPO YF2 or ANM), may have a condition in which the emission control system as designed will limit speed under certain conditions. The EPA has approved General Motor?s request to remove the emission control system speed limitations on…
• 10118546May 16, 2016Equipment. This informational bulletin provides information on a new U.S. dealer special tool loan program.
• 10118545May 16, 2016Electrical system, Equipment. This informational bulletin provides warranty policy information on revised wiring repair labor operations and required additional information.
• 10134546May 13, 2016Equipment, Back-over prevention (rear camera). This technical bulletin provides a procedure to reprogram the radio to correct a customer concern of radio Inoperative, blue Screen, AM clipping noise, HD on/off status not retained in stations, time lag on transitions, no audio with internal amp, and park assist symbol position wrong in rear view camera.
• 10134545May 13, 2016Electrical system. This informational bulletin provides warranty information on accessory power outlet and trailer lighting fuse replacement.
• 10126047May 11, 2016Tires. 29110 - Customer Satisfaction Program. (Customer Letter Mailing) Certain 2014-2016 model year Chevrolet Silverado and GMC Sierra model vehicles equipped with a full size spare tire and road wheel (SEO 00A) may have been built without a Tire Pressure Monitoring (TPM) sensor installed in the spare tire. If the spare tire was to be used and the TPMS programmed to coordinate with the wheels in use, a tire pressure…
• 10078874May 10, 2016Equipment. This preliminary information communication advises the technician that a noise or a vibration in the vehicle that seems to be abnormal may not have been there when the vehicle was purchased. Technician should look for non - general motors aftermarket accessories installed on the vehicle that can cause these issues.
• 10134536May 6, 2016Equipment. This warranty administration bulletin provides information on GM?s policy on performing GM covered vehicle services and maintenance on vehicles originating/sold in Canada.
• 10114114May 2, 2016Electrical system. This technical bulletin provides a procedure to replace both front overhead console lamps to correct a customer concern that when the dome lamps are off, if the brake pedal is applied or turn signal is operated, the dome lamp may flash on and off in any of the passenger rows caused by sensitivity of the U42 overhead console to normal voltage fluctuations generated with activation of the brake or turn lamps.
• 10078571May 1, 2016Equipment. This informational bulletin provide information on the product quality center (pqc) assembly replacement process.
• 10078569May 1, 2016Fuel system, Other or unknown. This informational bulletin provides information on vehicles designed to operate on gaseous fuels.
• 10083893Apr 27, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of the radio is inopertive. New software has been released to correct this concern.
• 10083782Apr 27, 2016Engine, Electrical system. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of black smoke when starting the vehicle after sitting.
• 10083513Apr 27, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. The technician is provided instructions for resetting the vehicle communication interface module for this concern.
• 10078749Apr 27, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of the radio is inopertive. New software has been released to correct this concern.
• 10078745Apr 27, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of receiving frequent "off route" messages while following turn by turn (tbt) route navigation. The technician is provided instructions for resetting the vehicle communication interface module for this concern.
• 10083073Apr 26, 2016Electrical system, Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of a dead battery after leaving the vehicle during a bluetooth call.
• 10078743Apr 26, 2016Electrical system. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of a dead battery after leaving the vehicle during a bluetooth call.
• 10083781Apr 22, 2016Electrical system. This preliminary information communication advises the technician on the steps to diagnose the concern, and the steps to repair the concern of the vehicle cranks but does not start. The technician is to inspect for a sheared cam pin in the engine.
• 10083587Apr 22, 2016Equipment. This preliminary information communication advises the technician to contact the gm technical assistance center for further instructions. The concern is the radio may be unable to save xm favorite stations.
• 10083561Apr 22, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern of the radio system inoperative. The technician is to call the general motors technical assistance center with the findings from the questions provided.
• 10078545Apr 22, 2016Equipment. This technical bulletin provides a procedure to replace the propeller shaft with a revised part when a broken propeller shaft or u-joint is found.
• 10083891Apr 21, 2016Tires. This preliminary information communication advises the technician this vibration or growl noise can be difficult to diagnose and using the pico scope is recommended for diagnosing this concern. The vehicle may have a vibration or growl noise between 45-65 miles-per-hour.
• 10083509Apr 21, 2016Equipment. This preliminary information communication advises the technician on the steps to diagnose and repair the concern. The vehicle's xm radio only has xm preveiw channels.
• 10083482Apr 21, 2016Equipment. This preliminary information communication advises the technician to diagnose the concern and the steps to repair the concern. The vehicle's xm travel link may be inopertive.
• 10078739Apr 21, 2016Tires. This preliminary information communication advises the technician this vibration or growl noise can be difficult to diagnose and using the pico scope is recommended for diagnosing this concern. The vehicle may have a vibration or growl noise between 45-65 miles-per-hour.
• 10078522Apr 20, 2016Equipment. "this technical bulletin provides a procedure to contact onstar for hard mute request to correct a customer concern when the radio is on, it does not mute enough when the onstar® turn-by-turn navigation directions are announced due to customer improperly setting the radio volume high enough when the turn-by-turn navigation messages are played. "

← All problems reported for the 2015 Chevrolet Silverado 2500