2022 Chevrolet Silverado 2500 Technical Service Bulletins

1,047 technical service bulletins (TSBs) are on record for the 2022 Chevrolet Silverado 2500. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10240793Jul 18, 2023Equipment. This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.
• 10240792Jul 18, 2023Forward collision avoidance. This Preliminary information communicates a "Forward Collision System Reduced" message displayed on the DIC when the Forward Automatic Braking has been set to the "Alert" setting. This is normal when the FAB has been set to "Alert".
• 10239674Jul 18, 2023Fuel system, Electrical system, Engine cooling. This technical bulletin provides a procedure to test and replace the high-pressure fuel injector electrical connectors if found the cause of the MIL.
• 10239755Jul 17, 2023Seat belts. This service bulletin provides information on availability for a seat belt extender.
• 10239658Jul 17, 2023Equipment. This service bulletin provides information for dealers/technicians on accessory all-weather floor liners and flat mats warped or misshapen.
• 10239633Jul 14, 2023Engine cooling. This technical bulletin provides a procedure to replace the camshaft actuator magnet to correct customer concerns of engine related shudder.
• 10240786Jul 13, 2023Equipment. This Preliminary Information communication provides information to the technician that General Motors Technical Assistance Center may ask for Global Diagnostic System 2 Session Log. Technician will need use Global Diagnostic System 2 to send the session logs to General Motors Technical Assistance Center for further assistance on the vehicle in question.
• 10239629Jul 13, 2023Exterior lighting, Electrical system. This service bulletin provides technicians with information on available BCM calibrations to restore bulb outage detection on vehicles produced by a second stage manufacturer (Upfitter), and/or turn signals flash fast after factory box removed.
• 10240782Jul 12, 2023Back-over prevention (rear camera), Body and structure. This Preliminary information communicates an issue with a wind noise while driving at highway speeds and dealers are to inspect the body harness pass through for being full seated into the cowl.
• 10239645Jul 12, 2023Electrical system, Equipment. This service bulletin provides information for dealers/technicians on Over the Air (OTA) and In Market Enhancement (IME) FAQs.
• 10239638Jul 12, 2023Equipment, Electrical system. This service bulletin provides information on the EL-52800 Diagnostic & Charge Battery Station (DCBS) – FAQs.
• 10239188Jun 30, 2023Engine, Other or unknown. This Preliminary information communicates the possibility of dtc U060F or U1345 being set as current or history and clearing the codes then evaluating to confirm they do not return Engineering investigating root cause of condition
• 10239124Jun 30, 2023Body and structure. This service bulletin provides information on Paintless Dent Repair Process.
• 10239116Jun 30, 2023Equipment, Electrical system. This service bulletin provides information on the Transport Mode Feature, also known as Logistics mode, which is used to increase the 12V Battery stand time of the vehicle during transit and or long period of stand time at the dealerships.
• 10239113Jun 30, 2023Equipment, Exterior lighting, Electrical system, Engine cooling. This service bulletin provides information for dealers/technicians on New Labor Operations for Limited Production Option (LPO) Calibrated Accessories.
• 10239101Jun 30, 2023Engine cooling. This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.
• 10239121Jun 29, 2023Body and structure, Electrical system. This technical bulletin provides a procedure to correct the condition of Inadvertent/Unwanted Tail Gate Opening.
• 10239112Jun 29, 2023Air bags, Electrical system. This technical bulletin provides a procedure to replace the air bag and air bag harness to correct a condition of Airbag Malfunction Warning and Airbag Malfunction Indicator Illuminated with DTC B0001-1B due to corrosion.
• 10239103Jun 29, 2023Transmission and drivetrain. This service bulletin provides information for automatic transmission Oil Cooler Flush and flow test.
• 10239102Jun 29, 2023Electrical system. The intent of this service bulletin is to identify aftermarket ALDL or DLC interface devices as potential sources for causing multiple customer concerns that do not have other diagnostic methods to identify them.
• 10239115Jun 28, 2023Electrical system, Equipment, Back-over prevention (rear camera). This service bulletin provides repair information to update radio software to correct customer concerns of Software related issues.
• 10239179Jun 26, 2023Transmission and drivetrain. This Preliminary information communicates that the t-case input seal, and/or the o-ring most likely is the source of the leak between the transmission and the t-case.
• 10239084Jun 22, 2023Transmission and drivetrain. This technical bulletin provides a procedure to locate and repair a transmission leak that may be coming from port plugs near the rear of the transmission.
• 10239171Jun 20, 2023Back-over prevention (rear camera). This Preliminary information communication provides information to the technician on installing Regular Production Option Code UVC Rearview Camera. Technician will need to reference the latest version of General Motors Up-fitter Integration Bulletin 152. The information can be found at http://www.gmupfitter.com/ under the "Technical Bulletin" Tab and then "Show all bulletins."
• 10239090Jun 20, 2023Electrical system, Fuel system, Equipment. This technical bulletin provides repair information to correct a customer concern of Fuel Range Blank on Instrument Panel.
• 10239167Jun 19, 2023Equipment. This Preliminary information communicates to dealers that there is a known issue with a loss of audio and the concern is being investigated by GM Engineering.
• 10239087Jun 19, 2023Engine cooling. This technical bulletin provides repair information to correct a customer concern of Evaporative DTCs P0442, P0446, P0455 or P0449, Caused by Dust Intrusion into the Evaporative Canister.
• 10237852Jun 19, 2023Electrical system. Due to the industry-wide semiconductor shortage, the park assist feature is not functional on certain vehicles, built beginning December 2, 2021. The affected vehicle owners should have been made aware of the condition at sale, and notified, that once parts are available, they would be eligible for a no additional cost retrofit to enable the feature. Dealers are to replace the park assist control module to restore…
• 10237851Jun 19, 2023Steering. Customer Satisfaction Program. Due to the industry-wide semiconductor shortage, the heat feature on the steering wheel is not functional on certain 2022 model year vehicles listed above, built beginning November 17, 2021. The affected vehicle owners should have been made aware of the condition at sale, and notified that once parts are available, they would be eligible for a no additional cost retrofit to enable the…
• 10239164Jun 16, 2023Transmission and drivetrain. This Preliminary information communicates that the t-case input seal, and/or the o-ring most likely is the source of the leak between the transmission and the t-case.
• 10239160Jun 14, 2023Equipment. This Preliminary information communicates an issue with an OTA pending message still displayed after an OTA event and how to reset/clear the message.
• 10238190Jun 14, 2023Equipment. This service bulletin describes the U.S. Dealer Special Tool Loan Program process.
• 10239052Jun 12, 2023Electrical system, Equipment. This technical bulletin provides repair information to correct a customer concern of No Alert Tones from Rear Cross Traffic Alert.
• 10239039Jun 12, 2023Equipment, Electrical system. This service bulletin provides information for dealers on Using EL-52545 When Diagnosing PEPs Transmitter Key Fobs.
• 10239154Jun 9, 2023Tires. This Preliminary Information communication provides information to the technician about vehicles with tire sidewall irregularities. This is a visual condition that will not affect durability, reliability or performance of the tires. Dealer should communicate to the customer that slight sidewall indentations are a common characteristic of radial tire construction.
• 10237960Jun 8, 2023Equipment. This service bulletin provides information on submitting quality Photos of Various Vehicle Concerns to the GM Technical Assistance Center (TAC).
• 10239150Jun 7, 2023Transmission and drivetrain. This Preliminary information communicates that the t-case input seal, and/or the o-ring most likely is the source of the leak between the transmission and the t-case.
• 10237935Jun 7, 2023Engine cooling. This informational bulletin advises the technician of how the Soot information has changed from grams to percentage.
• 10237846Jun 7, 2023Engine cooling, Transmission and drivetrain. This service bulletin provides information to dealership personnel on automatic transmission shift and engine driveability concerns and/or MIL ON due to aftermarket oil bath air filter use.
• 10237941Jun 5, 2023Engine cooling. This informational bulletin advises the tech on how to check for possible exhaust leaks.
• 10237321Jun 5, 2023Electrical system. Customer Satisfaction Program - Due to the industry-wide semiconductor shortage, the park assist feature is not functional on certain vehicles, built beginning December 2, 2021. The affected vehicle owners should have been made aware of the condition at sale, and notified, that once parts are available, they would be eligible for a no additional cost retrofit to enable the feature. Dealers are to replace the park…
• 10239146Jun 1, 2023Equipment. This Preliminary information communicates to dealers that there is a known issue with a loss of audio and the concern is being investigated by GM Engineering.
• 10237843Jun 1, 2023Electrical system, Equipment, Back-over prevention (rear camera). This service bulletin provides repair information to correct a customer concern of Rear View Camera Issues - DTCs B395A, B395B, B395C, B101E, B101D.
• 10237841Jun 1, 2023Equipment. This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. Dealers Only).
• 10237387May 30, 2023Transmission and drivetrain. This service bulletin provides information on some vehicles that may rock or move slightly forward or rearward while in Park at start up after cold soak. This condition may be accompanied by a clunk noise. This is a slight movement that is more often seen visually, rather than felt, when viewed from the outside and using the auto-start feature, if equipped.
• 10236607May 24, 2023Steering. Customer Satisfaction Program. Due to the industry-wide semiconductor shortage, the heat feature on the steering wheel is not functional on certain 2022 model year vehicles listed above, built beginning November 17, 2021. The affected vehicle owners should have been made aware of the condition at sale, and notified that once parts are available, they would be eligible for a no additional cost retrofit to enable the…
• 10237682May 23, 2023Air bags. This Preliminary information communicates to the dealer technician that engineering is aware of a concern with the teen driver feature not operating.
• 10236600May 23, 2023Steering. Customer Satisfaction Program. Due to the industry-wide semiconductor shortage, the heat feature on the steering wheel is not functional on certain 2022 model year vehicles listed above, built beginning November 17, 2021. The affected vehicle owners should have been made aware of the condition at sale, and notified that once parts are available, they would be eligible for a no additional cost retrofit to enable the…
• 10237677May 22, 2023Electrical system, Other or unknown, Air bags. This Preliminary Information communication provides information to the technician on how to diagnose and repair vehicle that may have a "Check Trailer Wiring" or "Service Trailer Brake System? message on the Driver Information Center when a trailer is connected to the vehicle. Diagnostic Trouble Code C1114 set in the Chassis Control Module. Chassis Control Module has to determine the type of trailer brake system…
• 10237676May 22, 2023Equipment. This Preliminary information communicates to dealers that there is a known issue with a loss of audio and the concern is being investigated by GM Engineering.

← All problems reported for the 2022 Chevrolet Silverado 2500