2009 Chevrolet Silverado 3500 Technical Service Bulletins

488 technical service bulletins (TSBs) are on record for the 2009 Chevrolet Silverado 3500. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10139023May 6, 2013Equipment, Seats, Electrical system. This preliminary informational bulletin provides a revision of PI0718A to add model years and update the Warranty Information.
• 10253616May 1, 2013Equipment. Audio System Speaker Rattle, Buzz Noise, Poor Sound
• 10247060May 1, 2013Electrical system. Terminal Test Probe And Replacement Terminal.
• 10245908May 1, 2013Seats. GM Accessory Heated Seats Inoperative After Installation.
• 10247766Apr 1, 2013Equipment. Unwanted Alarm Sounding (GM Accessory Inclination Sensor Mounting)
• 10247765Apr 1, 2013Electrical system. Fuel Gauge Shows Empty After Refueling And DTC P2636.
• 10247111Apr 1, 2013Electrical system. Unwanted Alarm Sounding (GM Accessory Inclination Sensor Mounting)
• 10063000Apr 1, 2013Air bags, Equipment. Summary to be provided on a future date.
• 10245804Mar 1, 2013Equipment. Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues
• 10245316Mar 1, 2013Electrical system. High Voltage 2-Mode Battery Parts Restriction-TAC.
• 10112857Feb 13, 2013Electrical system. This Preliminary Information communication advises the technician that, when testing any circuit for open or resistance, it is imperative that all related terminal pin fit and tension be checked when the test steps require disconnection of the connector or component, prior to any component replacement. Always use the recommended terminal test tool during these tests.
• 10247756Feb 1, 2013Body and structure, Electrical system. Driver or Passenger Door Module DTC B2555.
• 10247662Feb 1, 2013Visibility (wipers, defrost, mirrors). Cold Air Leak On Passenger Floor.
• 10247101Feb 1, 2013Body and structure, Electrical system. Driver or Passenger Door Module DTC B2555.
• 10245745Feb 1, 2013Body and structure. Reduced Heater Performance with Winter Grille Cover Installed
• 10062898Feb 1, 2013Back-over prevention (rear camera). Summary to be provided on a future date.
• 10062871Feb 1, 2013Body and structure. Summary to be provided on a future date.
• 10133146Jan 28, 2013Visibility (wipers, defrost, mirrors). This technical bulletin provides a procedure for adding double sided tape on the right and left windshield side reveal moldings to remove tapping, clicking or ticking type noise.
• 10253147Jan 1, 2013Engine cooling. Power On Acceleration After Cold Start.
• 10247747Jan 1, 2013Electrical system. Speedometer Needle Accuracy Information
• 10247092Jan 1, 2013Electrical system. Speedometer Needle Accuracy Information
• 10138538Dec 20, 2012Engine cooling. This informational bulletin provides information on the proper oils to use on GM vehicles including information regarding the differences of the Dexos oils.
• 10138554Dec 19, 2012Equipment. This preliminary informational bulletins provides information regarding the release of a new designed HVAC blower motor assembley. The bulletin provides information on how to correctly install the parts to function as intended.
• 10138541Dec 17, 2012Equipment. This warranty administration bulletin provides information on the Clarification of Use for Dealer Empowerment Labor Operations and Customer Enthusiasm
• 10138565Dec 13, 2012Transmission and drivetrain. This preliminary informational bulletin provides information on replacing the transmission fluid level indicator if a customers comments regarding one being broken.
• 10112664Dec 13, 2012Electrical system. This Preliminary Information communication provides information to the technician about vehicles may have a no power or no connect concern. Technician will find that the OnStar led is red and Diagnostic Trouble Code U1500 is set. Technician will need to replace the Vehicle Communication Interface Module if the Station Identification number falls in the ranges 14,000,000 - 16,000,000 or 22,000,000 - 23,200,000.
• 10112641Dec 12, 2012Engine cooling. This Preliminary Information communication provides information to the technician that fluid contamination may be directed to one of the following testing centers according to the type of fluid needing testing. Dealer should send the correct fluid to the proper testing center.
• 10138547Dec 11, 2012Body and structure. This preliminary information bulletin provides information on installing new rivets on the accessory tonneu cover to correct a customers comments on the cover seeming loose
• 10138545Dec 7, 2012Equipment. This informational bulletin provides a list off all the issues revolving around new vehicles for a one stop place to find growing concerns around them.
• 10138544Dec 7, 2012Tires. This informational bulletin provides the proper information used to determine the road force variences within new tires being installed and the proper forms used to send the tires back if the road force is not within spec.
• 10138556Dec 4, 2012Equipment. This preliminary information bulletin provides a descritption of operation of the echo control and noise cancellation settings for concernc regarding noice drop outs during calls and muffled sound.
• 10253582Dec 1, 2012Visibility (wipers, defrost, mirrors). Revised HVAC Blower Motor Installation Instructions.
• 10245772Dec 1, 2012Wheels, Tires, Suspension, Other or unknown. Diagnostic Tips for Difficult to Resolve Tire/Wheel Vibration Concerns
• 10138218Nov 29, 2012Equipment, Electrical system. This informational bulletin provides information regarding the inappropriate warranty claims submitted for damaged radios and instrument panel clusters, provides exampls on whats an acceptable for warranty and whats not
• 10112608Nov 28, 2012Equipment. This Preliminary Information communication provides information to the technician on how to diagnose and repair vehicles that may have an OnStar Turn-By-Turn Navigation the system that is inoperative. Technician verifies there are no Diagnostic Trouble Codes are present in the Antilock Braking System and Vehicle Communication Interface Module of the vehicle. If no Diagnostic Trouble Codes found call OnStar using…
• 10112600Nov 26, 2012Transmission and drivetrain. This Preliminary Information communication provides information to the technician with the axel setup information from American Axle Manufacturing. Technician should be advised that the maximum pinion shim to be used or stacked behind the pinion is 0.050?, and the minimum pinion shim is 0.020? for an 8.6 axle. The range for available pinion depth shims for the 10.5? axle is 0.006? to 0.024?. When setting the…
• 10112560Nov 9, 2012Brakes. This Preliminary Information communication provides information to the technician about brake rotors on new vehicles and replacement parts from General Motors Service Parts Operations. Technician should be advised the costing should not be removed from the brake rotor it will wear off with normal brake usage. Dealer should communicate to the customer this condition is a normal operating characteristic of their…
• 10112544Nov 6, 2012Brakes, Steering. This Preliminary Information communication provides information to the technician about vehicles that may have a power steering pump whine noise. Technician will need to flush and refill the power steering system with Lucas Power Steering Fluid with Conditioners. Technician will replace the power steering pump with the latest design if the fluid is not available.
• 10253610Nov 1, 2012Visibility (wipers, defrost, mirrors). Diagnosis and Repair HVAC Blower Function.
• 10112529Nov 1, 2012Equipment. This Preliminary Information communication provides information to the technician about vehicles that have an OnStar system that will not power up. Technician should turn off the ignition and cancel retained accessory power. After the vehicle has powered down, remove power to the OnStar module for five minutes. After the power has been removed for five minutes, if the OnStar system is working release the vehicle.
• 10112528Nov 1, 2012Electrical system. This Preliminary Information communication provides information to the technician about vehicles that during battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the OnStar system. Technician should understand the power cycles of the various OnStar systems. All Generation 6, 7, 8, and 9 systems are powered up continuously for 48 hours from ignition…
• 10118664Oct 29, 2012Brakes. This technical bulletin provides a procedure to either refinish or replace the front rotors for a condition of brake induced pulsation, vibration felt in steering wheel, rumble noise from underbody during downhill descents.
• 10112494Oct 18, 2012Equipment. This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts. Technician can check Service Information for some accessories. Technician can also contact Partech for assistance.
• 10118643Oct 16, 2012Equipment. This preliminary informational bulletin provides a list of corrections for multiple concerns regarding Unexpected Loss of Radio Audio (Radio Goes Silent/No Sound) and Other Blackberry Phone - Bluetooth Issues
• 10118641Oct 16, 2012Exterior lighting, Electrical system. This informational bulletin provides information on Available BCM Calibrations to Restore Bulb Outage Detection on Vehicles Produced by a Second Stage Manufacturer (Upfitter), Turn Signals Flash Fast after Factory Box Removed
• 10084191Oct 16, 2012Equipment, Electrical system. This preliminary informational bulletin provides a list of corrections for multiple concerns regarding unexpected loss of radio audio (radio goes silent/no sound) and other blackberry phone - bluetooth issues
• 10118640Oct 15, 2012Engine cooling, Fuel system. This informational bulletin provides information for Identifying Non-GM ECM Calibration Use and Power-up Hardware Detection in Duramax Diesel Engines - Photograph Tech 2 Calibration IDs, Calibration Verification Numbers (CVNs) and Transmission Data Screen
• 10118639Oct 15, 2012Engine cooling. This informational bulletin provides Information on Identifying Duramax Diesel Overpower Engine Breakdown/Non-Function Due to Aftermarket Power-Up Devices vs Non Overpower Engine Non-Function of Pistons, Cylinders, Valvetrain Components, DTC P003A or P111D Set
• 10118637Oct 15, 2012Equipment. This informational bulletin provides information on dealer responsibility for cargo carrying capacity labeling and the part numbers for the labels.
• 10118635Oct 15, 2012Visibility (wipers, defrost, mirrors). This preliminary informational bulletin provides a procedure for relearning the power folding mirriors and road testin to verify they correct a condtion of the power folding mirriors glass shakes, flutters at normal driving conditions.

← All problems reported for the 2009 Chevrolet Silverado 3500