2007 Chevrolet Silverado Technical Service Bulletins

280 technical service bulletins (TSBs) are on record for the 2007 Chevrolet Silverado. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10022963May 1, 2013Electrical system. Information on body control module (bcm) grounds. *nj updated 7/19/13.
• 10112973Apr 16, 2013Equipment. This Preliminary Information communication provides information to the technician about vehicles that for no reason the alarm will go active. Technician will need to use a scan tool to verify that the alarm was activated by the inclination sensor. If the trigger is the inclination sensor, inspect the sensor's mounting location. Technician will need to relocate the sensor if it is attached to the driver's side lower…
• 10112958Apr 5, 2013Engine cooling. This Preliminary Information communication provides information to the technician about vehicles that have low oil pressure, no oil pressure, and/or engine noise. Technician will need to replace the oil pump, flush the oil cooler lines.
• 10043850Feb 1, 2013Steering. Gmc: hydraulic power steering leak at hose connection to steering rack. All potential leaks should be completely cleaned and indentified before attempting to repair or replace any power steering components. *js updated 4/22/13.
• 10023751Feb 1, 2013Transmission and drivetrain. Engine surge or stall at stop and/or dtc p0742 possible tcc applied. Equipped with allison lct1000 transmission rpo m74 or mw7. *nj updated 4/22/13.
• 10112763Jan 31, 2013Equipment. This Preliminary Information communication provides information to the technician about vehicles that have a cold air leak on the front passenger side while driving. Technician will need to use black RTV silicone and apply over the seam between the upper and lower Heater-Vent-Air Conditioning case halves.
• 10112740Jan 25, 2013Transmission and drivetrain. This Preliminary Information communication provides information to the technician about vehicles that may have a service 4WD message displayed in the Driver Information Center. Technician may find Diagnostic Trouble Code C0379. Technician will need to inspect the front axle actuator connector for signs of moisture intrusion. If there is corrosion on the terminals at either location replace the actuator and harness.
• 10112737Jan 23, 2013Electrical system. This Preliminary Information communication provides information to the technician about vehicles that the speedometer needle appears to be inaccurate. Dealer should advise the customer the specification for speedometer needle accuracy is +/- 2 miles per hour at any given speed when looking straight at the needle.
• 10112725Jan 16, 2013Engine. This Preliminary Information communication provides information to the technician about vehicles that have misfires on cylinders 1, 4, 6 and 7. Technician should inspect the camshaft part numbers. Technician should ensure to use part number for the application by using the numbers stamped on the cam.
• 10112697Dec 27, 2012Equipment, Transmission and drivetrain. This Preliminary Information communication provides information to the technician about vehicles that have a Service Engine Soon Malfunction Indicator Lamp on, engine misfire, and/or engine noise. Technician may find Diagnostic Trouble Codes P0300-P0308.
• 10113849Dec 20, 2012Engine cooling. This informational bulletin provides information on the proper oils to use on GM vehicles including information regarding the differences of the Dexos oils.
• 10113843Dec 17, 2012Equipment. This warranty administration bulletin provides information on the Clarification of Use for Dealer Empowerment Labor Operations and Customer Enthusiasm
• 10112668Dec 13, 2012Exterior lighting. This Preliminary Information communication provides information to the technician about the puddle light operation. Technician should be advised that the puddle lamps to operate, "Approach Lighting" must be turned on using the Drivers Information Center buttons.
• 10112655Dec 12, 2012Wheels, Tires. This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
• 10112648Dec 12, 2012Electrical system, Engine cooling. This Preliminary Information communication provides information to the technician about vehicles with a "Service Charging System" message displayed on the Driver Information Center and/or a low voltage reading on the volt gauge during the first several minutes after a cold start. Technician may find a Diagnostic Trouble Code B1517 sym 03. If this concern only occurs during the first several minutes of a cold start…
• 10113837Dec 7, 2012Equipment. This informational bulletin provides a list off all the issues revolving around new vehicles for a one stop place to find growing concerns around them.
• 10043510Dec 1, 2012Equipment. Cadillac/chevrolet/gmc: original style blower motor assembly is no longer available. A revised hvac blower motor assembly for full size trucks is required, with modifications, to function properly. *pe updated 2/25/13.
• 10112615Nov 29, 2012Visibility (wipers, defrost, mirrors). This Preliminary Information communication provides information to the technician the steps to diagnose and repair vehicles that have windows inoperative while the engine is running but work when the engine is off. Technician should look for aftermarket parts and remove them and retest the windows before any in depth diagnostics are performed.
• 10112614Nov 29, 2012Equipment. This Preliminary Information communication provides information to the technician about customers may inquire about the availability of the passenger compartment air filter. Dealer should advise the customer starting in 2003 the passenger compartment air filter is no longer available as a factory option.
• 10112613Nov 29, 2012Tires. This Preliminary Information communication provides information to the technician about vehicles with tire sidewall irregularities. This is a visual condition that will not affect durability, reliability or performance of the tires. Dealer should communicate to the customer that slight sidewall indentations are a common characteristic of radial tire construction.
• 10112609Nov 28, 2012Body and structure. This Preliminary Information communication provides information to the technician about vehicles that the customer or up-fitter may have removed the rear bumper, install a different rear bumper, or add a different box/flat bed/cube box/hitch, etc. to the rear of the truck, which affects the rear park assist operation. Technician can disable the rear park assist for this concern.
• 10112603Nov 27, 2012Transmission and drivetrain. This Preliminary Information communication provides information to the technician about vehicles that have a rattle, buzz, tick, or vibration type noise that appears to be coming from the center of the dash. Technician will adjust the transmission dipstick tube away from the front of cowl to provide additional clearance.
• 10112597Nov 21, 2012Fuel system. This Preliminary Information communication provides information to the technician about vehicles that have a buzz or rattle type noise during light acceleration around 1200-2000 Revolutions per minute. Technician will need to reposition the fuel line and bracket down away from the floor pan.
• 10112571Nov 14, 2012Fuel system. This Preliminary Information communication provides information to the technician about vehicles that may have a bump feel or clunk noise at a stop or on launch. Dealer should communicate to the customer this condition is a normal operating characteristic of their vehicle. The bump clunk issue may be due to fuel movement in the fuel tank when not completely full. The condition is eliminated after completely filling…
• 10112561Nov 9, 2012Body and structure. This Preliminary Information communication provides information to the technician about vehicles that have water or dust from the openings under the bed rails near the stake pockets. Dealer should communicate to the customer this condition is a normal operating characteristic of their vehicle.
• 10112558Nov 8, 2012Electrical system. This Preliminary Information communication provides information to the technician with additional vehicle speed sensor diagnostic information. Technician may encounter multiple issues when diagnosing a Vehicle Speed Sensor. Technician will find it difficult to follow the speed signal path between the components. To test connect the Fluke meter leads between circuits 821 and 822 and set the meter to Alternating…
• 10112551Nov 6, 2012Brakes. This Preliminary Information communication provides information to the technician about vehicles that have an Antilock Braking System lamp followed by a Service Stability message in the Drivers Information Center. Technician my find Diagnostic Trouble Code C0710 set in the Electronic Brake Control Module. Technician may or may not find Diagnostic Trouble Code C0455. Technician will need to ensure the steering wheel…
• 10112546Nov 6, 2012Brakes. This Preliminary Information communication advises the technician that the Hydro-Boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.
• 10112539Nov 5, 2012Engine cooling. This Preliminary Information communication provides information to the technician about vehicles with Service Engine Soon Malfunction Indicator Lamp. Technician may find Diagnostic Trouble Code P0101. Technician should follow published Service Information diagnostics for any Diagnostic Trouble Codes that are set.
• 10112537Nov 2, 2012Air bags. This Preliminary Information communication provides information to the technician about vehicles that have a Diagnostic Trouble Code B0081 in the Sensing and Diagnostic Module and Passenger Presence Sensor modules. Technician should inspect the Sensing and Diagnostic Module and Passenger Presence Sensor powers, grounds, and communication circuits at all in line connectors for fully seated, backed out terminals, and…
• 10112535Nov 2, 2012Steering, Equipment, Vehicle speed control, Electrical system. This Preliminary Information communication provides information to the technician with the installation of Cruise Control on a vehicle which did not come equipped with the option. Technician will need to contact the Techline Customer Support Center to determine if a calibration is available for the vehicle. If they are able to provide a calibration for the vehicle then order steering wheel with cruise control…
• 10112531Nov 1, 2012Brakes. This Preliminary Information communication provides information to the technician about hairline cracks may be noticed in the pad friction material, when performing a brake inspection. Technician should be advised that the hairline cracks do not affect the operation of the brake system and the pads should not be replaced if only hairline cracks are found.
• 10043892Nov 1, 2012Visibility (wipers, defrost, mirrors). Gm: diagnose and repair hvac blower function. May not be any air flow from the hvac vents. One possible of this condition may be the contacts in the hvac junction block(s) located at the right side of the instrumental panel. *js updated 1/24/13.
• 10112526Oct 31, 2012Brakes, Equipment. This Preliminary Information communication provides information to the technician about vehicles that have a "Service Stability Message" appears on the Drivers Information Center. Technician will find Diagnostic Trouble Code C0561 set in the Electronic Brake Control Module. Technician will need to address any other Diagnostic Trouble Codes that are set in the vehicle first before working on Diagnostic Trouble Code…
• 10112527Oct 29, 2012Equipment. This Preliminary Information communication provides information to the technician about vehicles that have the content theft alarm is inoperative. Dealer should communicate to the customer this condition is a normal operating characteristic of their vehicle. Technician should be advised that the vehicle must have Keyless Entry Regular Production Option Code (AU0/AU3) and Regular Production Option Code YE9 or Y91 to…
• 10112519Oct 29, 2012Suspension, Wheels. This Preliminary Information communication provides information to the technician about vehicles that have grease leaking from front hub bearings. Technician should not replace the bearing for grease purge. Technician should be advised to not clean the purged grease from the area immediately on or adjacent to the seals because this grease provides additional protection.
• 10112512Oct 22, 2012Seats, Equipment. This Preliminary Information communication provides information to the technician about vehicles that are unable to set a personalized easy exit seat and/or power tilt column position and they will only move a predetermined amount. Dealer should communicate to the customer this condition is a normal operating characteristic of their vehicle.
• 10112508Oct 22, 2012Tires. This Preliminary Information communication provides information to the technician that some owners of Heavy Duty Trucks and Utilities may ask if they can lower their tire pressures. Tire pressures being set to the "Tire and Loading Label" will ensure the safe handling and ride characteristics of the truck and should not be lowered.
• 10112491Oct 17, 2012Visibility (wipers, defrost, mirrors), Equipment. This Preliminary Information communication provides information to the technician about vehicles that have passenger window express down feature is inoperative. Technician should be advised that models equipped with either Memory Seats Regular Production Option Code (AN3) and/or Power Folding Mirrors Regular Production Option Code (DL3) will have the passenger window express down feature.
• 10112472Oct 15, 2012Electrical system. This Preliminary Information communication provides information to the technician about vehicles that if the ignition key is turned to the start position, and then released when the engine begins cranking, the engine will continue cranking for a few seconds or until the vehicle starts. Some customers may state that this feature is inoperative.
• 10112470Oct 12, 2012Electrical system, Equipment, Vehicle speed control. This Preliminary Information communication provides information to the technician about vehicles that have an instrument panel backlighting flashes, flickers or inoperative, unwanted horn activation, radio controls inoperative or unwanted activation, OnStar unwanted activation, and cruise control inoperative.
• 10112463Oct 11, 2012Transmission and drivetrain. This Preliminary Information communication provides information to the technician about vehicles that have a groan, growl, or moan coming from the vehicle when operating the vehicle in four wheel drive. Driving on clean, dry pavement in Four-Wheel Drive High or Four-Wheel Drive Low for an extended period of time may cause premature wear on your vehicle's power train.
• 10112452Oct 5, 2012Electrical system. This Preliminary Information communication provides information to the technician about vehicles that the cruise control being inoperative. Technician may find Diagnostic Trouble Code B3894 set in the Trailer Brake Control Module. Technician should follow published Service Information diagnostics first. Technician should check the "Master Cylinder Pressure" sensor parameter listed in the Trailer Brake Control…
• 10112451Oct 5, 2012Visibility (wipers, defrost, mirrors). This Preliminary Information communication provides information to the technician about vehicles that have passenger window express down feature is inoperative. Technician should be advised that models equipped with either Memory Seats Regular Production Option Code (AN3) and/or Power Folding Mirrors Regular Production Option Code (DL3) will have the passenger window express down feature.
• 10047839Oct 1, 2012Steering, Electrical system. Cadillac/chevrolet/gmc: will have inoperative cruise control; inoperative or unwanted activation of radio controls; backlighting flashes, flickers or inoperative due to possible short to ground on steering wheel coil connector x2. Models 2007-2013 escalades models, avalanche, silverado, suburban, tahoe, sierra, yukon models.
• 10023423Oct 1, 2012Vehicle speed control. Cruise control inoperative - keywords abs b3894 brake cylinder ebcm inop master module pressure sensor switch trailer. With rpo jl1. *nj models 2007-2013 avalanche, silverado, suburban, tahoe sierra, yukon, yukon denali, yukon xl, yukon denali xl. Updated 12/10/12.
• 10047479Sep 1, 2012Electronic stability control, Other or unknown. Gmc/chevrolet/cadillac: instrument panel messages regarding stabilitrak message, traction control message, service brake system message, is off and gauges, in various modules low speed settings, are inoperative. Models 2007-13 all escalades; avalanche, silverado, suburban, tahoe; sierra, all yukons and denalis.
• 10047459Sep 1, 2012Vehicle speed control. Cadillac/gmc/chevrolet: information on cruise control being inoperative due to bpp circuit signal and/or tcc/cruise brake pedal parameters, when brake pedal is released but shows applied. Models 2007-2013 all escalades, avalanche, silverado, suburban, tahoe, sierra, all yukons.
• 10055803Jul 1, 2012Transmission and drivetrain. Cadillac/chevrolet/gmc/hummer/pontiac: there is slipping or have no fourth, fifth or sixth gear and malfunction indicator lamp (mil) would be on, with diagnostic trouble code (dtc) p0796 found as active.
• 10042386Jun 1, 2012Brakes, Electrical system. Chevrolet/cadillac/gmc: certain vehicles experiencing erratic or inoperative speedometer or anti-lock brake system message or malfunctioning indicator light displaying in driver's information center. *pe updated 08/5/2013

← All problems reported for the 2007 Chevrolet Silverado