2009 Chevrolet Silverado Technical Service Bulletins

276 technical service bulletins (TSBs) are on record for the 2009 Chevrolet Silverado. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10032336Jul 1, 2009Brakes, Air bags. Gmc/cadillac/chevrolet: air bag readiness light on, service air bag message, inflatable restraint sensing and diagnostic module (sdm) corrosion (replace sdm/cut and remove carpet pad).
• 10032889Jun 1, 2009Engine cooling. Gmc/chevrolet: dtc p0101 with non gm air filter. May encounter concern of reduced power and ses light on. Diagnostics may reveal maf (mass air flow) sensor dtc p0101. If diagnostics were inconclusive its possible dtc p0101 is setting due to a non gm air filter. Non gm air filters have shown a slightly higher than normal maf reading.
• 10032869Jun 1, 2009Transmission and drivetrain, Steering. Gmc/chevrolet/saab/hummer: bind/tie-up in fourth gear, no second or fourth gears, overrun clutch distress. During disassembly of the transmission technicians may find that the 2-4 band (item 602 in si document 1553208) and the overrun clutch (645) are both distressed while no other clutches are damaged.
• 10032867Jun 1, 2009Electrical system. Chevrolet/cadillac/gmc: sir mil with dtc b0081. Can be set in the sdm and pps. In most cases, this dtc will set due to a communication fault and does not always require a module replacement. Inspect the pps and sdm powers, grounds, and communication circuits at all: in line connectors, pps connector, sdm connector and splice packs for being fully seated, backed out terminals, and proper terminal tension using the…
• 10032866Jun 1, 2009Electrical system. Gmc/chevrolet/cadillac: sir mil on with dtc b1325 sym 03. During a low battery/voltage condition the passenger presence system may set a b1325 sym 03 along with other faults that are caused by the low batter/voltage condition.
• 10030750May 1, 2009Air bags. Gmc/chevrolet: sir mil on and tech 2 will not communicate with sdm. Some modules may set a communication dtc u0151 against sdm. Diagnostics may lead to replacement of sdm and replacing sdm may fix the concern for a short time or it may fail again on the first or second ignition key cycle. The hd silverado and sierras only.
• 10030652May 1, 2009Brakes. General motors: the brakes are grabby or touchy when applied or an intermittent mil/ses light may be illuminated. Upon further investigation, the technician may find dtc c012e set in the ebcm and c12fe set in the ecm.
• 10030110May 1, 2009Fuel system, Electrical system, Engine cooling. General motors: malfunction indicator lamp (mil) illuminated, intermittent dtc p0191, slow fuel rail pressure (frp) decay, wiring harness connections, voltage fluctuations/interruptions (follow correction information below). *pe updated 11/23/09.
• 10030092May 1, 2009Fuel system. General motors: the low fuel warning light comes on or the gauge shows empty when there is fuel in the tank. *pe updated 11/04/09.
• 10024405May 1, 2009Wheels. Low tire pressure, leaking cast aluminum wheels (repair with adhesive sealant). 2008 and prior gm passenger car and light duty trucks (including saturn) and hummer h2, h3 and saab 9-7x with cast aluminum wheels. *nj updated 10/23/09.
• 10030207Apr 1, 2009Engine cooling. Chevrolet/gmc: diesel engine turbo dtc p2563 or p003a. May encounter a concern of ses light, reduced power, low power.
• 10030122Apr 1, 2009Steering. General motors: the left and/or right steering wheel lower (spoke) cover is warped, loose, discolored or just fits poorly in the steering wheel. The paint finish seems to be peeling.
• 10030111Apr 1, 2009Engine cooling. Diagnostic information on malfunction indicator lamp (mil) illuminated with dtcs p0442,p0446, p0451, p0452, p0453, p0454, p0455 and replacement of fuel tank pressure (ftp) sensor/module.
• 10030211Mar 1, 2009Exterior lighting. Gmc/chevrolet: the left or right rear tail, stop and/or turn signal lamps are intermittently inoperative, or the turn signal flashes fast.
• 10024544Feb 1, 2009Brakes. (hybrid) no brake assist after a battery disconnect. With rpo hp2. *nj updated 12/3/08. *pe updated 8/19/09.
• 10028179Nov 1, 2008Electrical system, Equipment. Buick cadillac chevrolet gmc pontiac saturn service campaign: see document search button for owner letter. Onstar system inoperative; replace onstar module. Some vehicles may have an onstar module with a component that was not manufactured to gm's specification. Can result in an open circuit and an inability to call or receive calls from onstar. Csc letter was received.
• 10026701Sep 1, 2008Exterior lighting, Visibility (wipers, defrost, mirrors), Latches, locks and…. Gmc: bmc failure after windshield wiper operation-keywords: ajar door dome driver dimmer flasher fog haul headlight head high hazard inop inoperative lamp light lock low not on off power park radio rap repeat signal shut speed stay switch turn tow unlock unwanted window. May be due to internal bcm damage.
• 10026693Sep 1, 2008Equipment. Buick cadillac chevrolet gmc pontiac saturn service campaign: see document search button for owner letter. Onstar system inoperative - replace onstar module. This can result in an open circuit and an inability to call or receive calls from onstar. Csc letter was received.
• 10026691Sep 1, 2008Tires. Gmc: tire pressure light stays on (reprogram rcdlr) even though tire pressure values are correct.
• 10022694Sep 1, 2008Brakes. Service brakes soon message dtc c0299. *nj updated 5/13/08. *nj updated 12/5/08. No hybrids vehicles.
• 10026704Aug 1, 2008Fuel system. Gmc: fuel gauge fluctuation in park or neutral, causing the low fuel light to illuminate.
• 10026149Aug 1, 2008Transmission and drivetrain. Gmc: flare and or harsh 2-3 shifts. This condition may be caused by leaking 1-2-3-4 and 3-5-r clutch fluid seal rings (230). Models cadillacs, chevrolets, gmc, hummers, pontiacs. Equipped with 6l80 (rpo myc) or 6l90 (rpo myd) automatic transmission.
• 10023752Aug 1, 2008Electronic stability control. Unwanted stability activation and/or c0710 with lift/lower kits-different tires/wheel. With rpo jl4. *nj updated 12/18/08.
• 10026650Jul 1, 2008Engine cooling. Gmc: oil leak at turbocharger air intake pipe. Initial inspection ma reveal a leak that looks as it is coming from the rear of the engine.
• 10026007Jul 1, 2008Engine cooling. Gmc: no start, no crank, intermittent electrical operations (check for poor connections within engine wiring harness junction block).
• 10020883Jul 1, 2008Brakes, Equipment. Service stability lamp diagnostic trouble code (dtc) c0561. *kb updated 9/30/08.

← All problems reported for the 2009 Chevrolet Silverado