2013 Chevrolet Sonic Technical Service Bulletins

1,726 technical service bulletins (TSBs) are on record for the 2013 Chevrolet Sonic. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10113545Feb 13, 2015Transmission and drivetrain. This preliminary informational bulletin provides repair information to correct a customer concern of on an automatic transmission fluid leak.
• 10113538Feb 11, 2015Tires, Wheels. This informational bulletin communicates comprehensive instructions to GM Dealers and authorized GM Accessory Distributor/Installers as to the proper methods for mounting, balancing, and installing accessory wheels and tires.
• 10113537Feb 11, 2015Engine cooling. This preliminary informational bulletin provides a diagnostic tip for technicians who may find an oil leak after a recent oil change has been performed.
• 10114390Feb 9, 2015Equipment, Engine cooling. This Preliminary Information communication provides information to the technician on the steps to diagnose and repair vehicles that have excessive oil consumption, blue smoke from the exhaust, or a Malfunction Indicator Lamp. Technician should inspect the PVC orifice for leaking oil or drawing a vacuum at idle. If the PCV orifice external port is leaking oil or vacuum, replace the camshaft cover assembly.
• 10113531Feb 9, 2015Equipment. This warranty administration bulletin provides information to clarify proper transaction administration of GM Dealer Empowerment Program and Goodwill Cases.
• 10113527Feb 6, 2015Exterior lighting. This informational bulletin communicates GM's position on exterior lighting components ?tinted or smoked? by an outside vendor.
• 10113519Feb 5, 2015Electrical system, Equipment. This preliminary informational bulletin adds the 2015 model year to repair information on correcting a customer concern of poor, limited, reduced Remote Keyless Entry (RKE) or Remote Vehicle Start (RVS) range.
• 10113514Feb 3, 2015Tires. This informational bulletin communicates GM's position on use of nitrogen gas in tires.
• 10113512Feb 3, 2015Electrical system. This preliminary informational bulletin provides a diagnostic tip for low line pressure or pressure regulator valve stuck after transmission service pump cover replacement.
• 10057275Feb 1, 2015Engine. General motors: 2013-2015 buick encore, cadillac elr, chevrolet cruze, sonic, trax, volt equipped with 1.4l engine(rpo luv or luu). Concern of a chirp noise coming from the engine once vehicle has warmed up.
• 10079524Jan 27, 2015Engine. 14371b - special coverage (labor code revised). Some 2011-2014 model year chevrolet cruze vehicles and some 2012-2014 chevrolet sonic vehicles with the 1.4l engine may have an engine coolant leak from the water pump. The pump may leak from the weep reservoir or from the water pump shaft seal, leading to a drip of coolant onto the engine or onto the ground. Over time, the loss of coolant will reduce cooling…
• 10139439Jan 26, 2015Engine cooling. This preliminary informational bulletin provides diagnostic tips that may be helpful in correcting a customer concern about a whistle noise heard from the engine area after the vehicle has warmed up, or for up to 10 seconds after the engine is shut off.
• 10139438Jan 26, 2015Equipment. This informational bulletin provides information to correct a dealer concern of what they perceive to be paint staining when the protective shipping film is removed from certain vehicles.
• 10139437Jan 23, 2015Electrical system. This informational bulletin updates information on electrical ground repairs using new replacement fasteners with conductive finish.
• 10139436Jan 23, 2015Equipment. This informational bulletin adds 2014 - 2015 model years to information regarding comeback prevention and using Customer Concern Verification Sheets (CCVS).
• 10139433Jan 23, 2015Electrical system. This informational bulletin provides information on control module diagnostics and configuration, programming using the TIS Service Programming System (SPS), set-up and warranty.
• 10139430Jan 22, 2015Wheels. This informational bulletin provides information on chemical staining, pitting, corrosion and/or spotted appearance of chromed aluminum wheels, along with warranty information regarding these conditions.
• 10139426Jan 21, 2015Suspension. This preliminary informational bulletin provides repair information to correct a customer concern of feeling a bump, surge or vibration at idle in drive, at a stop.
• 10139422Jan 16, 2015Engine cooling. This preliminary informational bulletin provides technicians an engine repair tip for installation of pistons.
• 10114352Jan 15, 2015Tires, Wheels. This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
• 10095317Jan 15, 2015Equipment. This preliminary information communication provides information to the technician about changing the tire and wheel size on vehicles. General motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
• 10139415Jan 14, 2015Electrical system. This warranty administration bulletin provides policy information on ACDelco® replacement battery warranty procedures.
• 10139414Jan 14, 2015Equipment. This warranty administration bulletin adds 2012 - 2015 model years to information communicating a change in the product field action customer reimbursement procedure (U.S. Dealers Only).
• 10114343Jan 14, 2015Equipment. This Preliminary Information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. Technician will need to determine what type of call the customer is having that is unwanted. The vehicle may receive an incoming call just like any other phone. Typically the customer will hear the phone ringing in the vehicle. This…
• 10114342Jan 14, 2015Equipment. This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Technical Assistance Center with the scan tool data from the OnStar system.
• 10094888Jan 14, 2015Equipment, Electrical system. This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. Technician will need to determine what type of call the customer is having that is unwanted. The vehicle may receive an incoming call just like any other phone. Typically the customer will hear the phone ringing in the vehicle. This…
• 10079307Jan 13, 2015Engine. 14371a - special coverage (revised warranty information). Some vehicles with the 1.4l engine may have an engine coolant leak from the water pump. The pump may leak from the weep reservoir or from the water pump shaft seal, leading to a drip of coolant onto the engine or onto the ground. Over time, the loss of coolant will reduce cooling performance and eventually could lead to engine overheating.
• 10139411Jan 12, 2015Equipment. This preliminary informational bulletin provides information that accessory remote start does not work with OnStar RemoteLink? phone application.
• 10139203Jan 7, 2015Engine cooling. This preliminary informational bulletin provides information to reduce the number of no trouble found (NTF) turbochargers (TC) being returned to the warranty parts Center (WPC) by informing Service Department personnel of what inspections and/or diagnosis to perform, prior to returning a TC to the WPC.
• 10139201Jan 6, 2015Engine. This preliminary informational bulletin provides diagnostic tips that may be helpful in correcting a customer concern about a whistle noise heard from the engine area after the vehicle has warmed up, or for up to 10 seconds after the engine is shut off.
• 10139200Jan 6, 2015Engine, Electrical system. This informational bulletin provides information that may be useful in diagnosing/testing batteries that have set for a long period of time and/or set in cold weather climates to correct a customer concern of symptoms that include, but not limited to, a slow or no crank condition that may be caused by a discharged battery.
• 10139199Jan 6, 2015Suspension. This informational bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure, when diagnosing vibration concerns.
• 10139198Jan 6, 2015Tires. This preliminary informational bulletin provides information that the tire pressure monitor (TPM) sensors must always be re-learned when accessory wheels are installed on the vehicle.
• 10057266Jan 1, 2015Engine cooling. General motors: 2011-2014 chevrolet cruze chevrolet sonic/ w 1.4l engine(rpo luj or luv): some model vehicles may experience engine coolant leak from the water pump. This could reduce coolant performance and cause overheating. *lj see document search button for owners letter.
• 10126251Dec 19, 2014Transmission and drivetrain. This informational bulletin was created for the Manual Transmission Operating Characteristics. The different noises caused by driver habit, weather conditions , and normal manual transmission noises.
• 10114801Dec 19, 2014Equipment. This Preliminary Information communication provides information to the technician about vehicle that may OnStar inoperative and Navigation/GPS/Compass issues. Technician may find Diagnostic Trouble Codes B101D sym 3C and or F0. Technician will gather data using a scan tool and contact General Motors Technical Assistance Center for further assistance. After approval technician will replace the OnStar module.
• 10126248Dec 18, 2014Wheels. This preliminary information bulletin provides information on how to remove stainless steel wheel nut caps with the matching depth of socket used on the wheel nut.
• 10126247Dec 18, 2014Equipment. This preliminary information bulletin advises the technician that there is no update for the customers concerns of the GM remote start doesn't work with the Onstar remotelink phone application.
• 10114797Dec 16, 2014Electrical system, Seats. This Preliminary Information communication provides information to the technician about vehicles that have heated seats inoperative. Technician may find Diagnostic Trouble Code U0209 in the Heater-Vent-Air Conditioning. Technician will need to reprogram the seat heater control module using Service Programming System with the latest calibration to address the concern.
• 10114783Dec 12, 2014Electrical system, Seats. This Preliminary Information communication provides information to the technician about vehicles that have heated seats inoperative. Technician may find Diagnostic Trouble Code U0209 in the Heater-Vent-Air Conditioning. Technician will need to reprogram the seat heater control module using Service Programming System with the latest calibration to address the concern.
• 10126237Dec 11, 2014Visibility (wipers, defrost, mirrors). This informational bulletin provide information for the technicians to repair the rear window defroster contact or tabs.
• 10126231Dec 10, 2014Equipment. This information provides the proper way to install the floor mats .
• 10114775Dec 10, 2014Electrical system. This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking tension or probing the .64 series terminals. The test probe terminal has been released in the terminal repair kit (J-38125-620H) located in Lear Tray 7 part number 963716-2.
• 10126221Dec 8, 2014Electrical system. This warranty informational bulletin advised the technician that when performing a wiring repair, more information is required.
• 10114760Dec 3, 2014Electrical system. This Preliminary Information communication provides information to the technician about vehicles that have a Diagnostic Trouble Code B101D stored in Telematics Communication Interface Control Module. Technician will need to call General Motors Technical Assistance Center for further assistance. If the Diagnostic Trouble Code B101D has a sym 37 set please refer to the latest version of PIC5492.
• 10126208Dec 2, 2014Equipment. This preliminary bulletin provides information on inspecting the turbocharger for missing or prematurely worn parts.
• 10253584Dec 1, 2014Wheels. Information on Removal/Cracking of Stainless Steel Wheel Nut Caps.
• 10247716Dec 1, 2014Equipment, Electrical system. J-35616-64B Terminal Test Probe / Replacement Terminal / Terminated Lead.
• 10247061Dec 1, 2014Electrical system. J-35616-64B Terminal Test Probe / Replacement Terminal / Terminated Lead.
• 10245938Dec 1, 2014Electrical system. OnStar Module Does Not Support All B101D Symptom Codes.

← All problems reported for the 2013 Chevrolet Sonic