2014 Chevrolet Spark Technical Service Bulletins

1,479 technical service bulletins (TSBs) are on record for the 2014 Chevrolet Spark. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10137903May 12, 2014Equipment. This preliminary bulletin states to add the DTC symptom byte to the documentation to help aid engineering pinpoint concerns when trying to locate a root cause.
• 10092905May 12, 2014Equipment. 13434b - customer satisfaction (revised service procedures). Certain vehicles may have a condition where the air conditioning (a/c) system does not work or cools intermittently due to inaccurate control of the evaporator temperature sensor. Dealers are to inspect and, if necessary, replace the a/c compressor. Dealers are to also, if necessary, replace the evaporative air temperature (eat) sensor, install a low…
• 10061202May 12, 2014Equipment. Summary to be provided on a future date.
• 10137901May 9, 2014Fuel system. This informational bulletin provides the technician with information on what E85 fuel may due to a non E85 vehicle.
• 10092904May 9, 2014Engine. 14076a - service update (revised engine oil spec). This bulletin provides a service procedure to perform a test procedure on certain vehicles, equipped with a 1.2l engine (ll0). If the vehicle does not pass the test procedure, dealers are to replace the four piston assemblies. Some customers have commented about engine knock/tick/rattle, sluggish performance, and poor shifts; however, the vehicle remains operable.
• 10092901May 9, 2014Engine. 14076 - service update. This bulletin provides a service procedure to perform a test procedure on certain vehicles, equipped with a 1.2l engine (ll0). If the vehicle does not pass the test procedure, dealers are to replace the four piston assemblies. Some customers have commented about engine knock/tick/rattle, sluggish performance, and poor shifts; however, the vehicle remains operable
• 10061201May 9, 2014Engine. Summary to be provided on a future date.
• 10061190May 9, 2014Engine. Summary to be provided on a future date.
• 10061183May 9, 2014Engine. Summary to be provided on a future date.
• 10137900May 8, 2014Equipment, Engine cooling. This prelimenary bulletin provides a procedure to replace the pistons if found creating the customers concern of spark knock noise and MIL on.
• 10112056May 6, 2014Engine cooling. This Preliminary Information communication provides information to the technician on the steps to diagnose and repair vehicles that have excessive oil consumption, blue smoke from the exhaust, or a Malfunction Indicator Lamp. Technician should inspect the PVC orifice for leaking oil or drawing a vacuum at idle. If the PCV orifice external port is leaking oil or vacuum, replace the camshaft cover assembly.
• 10137890May 2, 2014Equipment, Transmission and drivetrain, Engine cooling. This informational bulletin provides information to the technician on what parts of an engine or transmission will require the PQC to be notified.
• 10247283May 1, 2014Engine, Back-over prevention (rear camera). Engine Noise ? DTC P0324
• 10247282May 1, 2014Engine cooling. Engine Noise ? DTC P0324
• 10246813May 1, 2014Engine cooling. CSP-Air Conditioning System Inoperative or Cools Intermittently
• 10245758May 1, 2014Equipment. Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
• 10137889May 1, 2014Equipment, Electrical system. This technical bulletin provides a procedure on how to turn the transport mode message off and reset the battery light flashing.
• 10070980May 1, 2014Transmission and drivetrain. Summary to be provided on a future date.
• 10070963May 1, 2014Electrical system. Summary to be provided on a future date.
• 10070929May 1, 2014Engine. Summary to be provided on a future date.
• 10067242May 1, 2014Engine. Summary to be provided on a future date.
• 10067241May 1, 2014Engine. Summary to be provided on a future date.
• 10067202May 1, 2014Equipment. Summary to be provided on a future date.
• 10056237May 1, 2014Electrical system. General motors: due to loose ground terminal connections, in some vehicles and trucks experience, accessories malfunctions, dic messages, ipc warning indicators, ses light on.
• 10055837May 1, 2014Equipment. Chevrolet: see document search button for owner letter. Due to inaccurate control of evaporator temperature sensor, in some vehicles, the air conditioning (a/c) system, immediately, fails to work or cools. Model 2013-2014 spark. *pe updated 7/30/14. *pe updated 10/6/14.
• 10135227Apr 28, 2014Equipment. This informational bulletin provides information to the dealers on properly maintaining vehicles in inventory.
• 10135222Apr 22, 2014Equipment. This informational bulletin explains how to cut a new key or how to get a precut key from GM.
• 10135219Apr 22, 2014Exterior lighting. This informational bulletin explains condensation in exterior lights and replacment guidelines for warranty replacement.
• 10135218Apr 22, 2014Equipment. This informational bulletin is to assist with the identification of issues that are not considered warrantable.
• 10111811Apr 18, 2014Electrical system, Equipment. This Preliminary Information communication provides information to the technician about vehicles that have an OnStar system that will not power up. Technician should turn off the ignition and cancel retained accessory power. After the vehicle has powered down remove power to the OnStar module for five minutes. After the power has been removed for five minutes, if the OnStar system is working release the vehicle.
• 10111810Apr 17, 2014Equipment. This Preliminary Information communication provides information to the technician about installing General Motors Accessory pats. Technician can check Service Information for some accessories. Technician can also contact Partect for assistance. Technician can also contact Techline Customer Support Center for programming issues.
• 10093951Apr 15, 2014Equipment. 13434a - customer satisfaction (revised service procedure). Certain vehicles may have a condition where the air conditioning (a/c) system does not work or cools intermittently due to inaccurate control of the evaporator temperature sensor. Dealers are to inspect and, if necessary, replace the a/c compressor. Dealers are to also, if necessary, replace the evaporative air temperature (eat) sensor, install a low…
• 10061069Apr 15, 2014Equipment. Summary to be provided on a future date.
• 10135201Apr 14, 2014Equipment. This information bulletin provides the technician with additional information on fixing the vehicle right the first time by listing possible concerns to specific vehicles.
• 10093946Apr 9, 2014Equipment. 13434 - customer satisfaction. Certain vehicles may have a condition where the air conditioning (a/c) system does not work or cools intermittently due to inaccurate control of the evaporator temperature sensor. Dealers are to inspect and, if necessary, replace the a/c compressor. Dealers are to also, if necessary, replace the evaporative air temperature (eat) sensor, install a low pressure switch adaptor kit, and…
• 10061119Apr 9, 2014Equipment. Summary to be provided on a future date.
• 10111792Apr 8, 2014Equipment. This Preliminary Information communication advises the technician that the Human Machine Interface, Radio or Tuner, radio controls, Integrated Center Stack, display, and Media Disc Players are placed on restriction through the General Motors Technical Assistance Center. Dealer will need to contact General Motors Technical Assistance Center for further assistance.
• 10250013Apr 1, 2014Electrical system. High Voltage Safety ? High Voltage Disabling
• 10247684Apr 1, 2014Equipment. Navigation Radio, Radio, Amplifier, Human Machine Interface.
• 10246812Apr 1, 2014Visibility (wipers, defrost, mirrors). CSP-Air Conditioning System Inoperative or Cools Intermittently
• 10246811Apr 1, 2014Engine cooling. CSP-Air Conditioning System Inoperative or Cools Intermittently
• 10245323Apr 1, 2014Equipment. Navigation Radio, Radio, Amplifier, Human Machine Interface.
• 10074043Apr 1, 2014Equipment. Summary to be provided on a future date.
• 10067201Apr 1, 2014Equipment. Summary to be provided on a future date.
• 10067200Apr 1, 2014Equipment. Summary to be provided on a future date.
• 10137887Mar 28, 2014Electrical system. This warranty bulletin explains how to use the EL-50313 Midtronic GR8 Battery tester to test a battery and determin if it is warranty or not
• 10137880Mar 25, 2014Engine cooling. This prelimenary bulletin explains that engineering is looking for a repair at this time.
• 10137866Mar 17, 2014Equipment. This informational bulletin helps the technician quick reference repairs to bulletins as opposed to replacing parts that may be un necessary.
• 10111850Mar 5, 2014Equipment. This Preliminary Information communication provides information to the technician about vehicles that when a Canadian customer may comment that when they travel to the United States, they are unable to connect to OnStar or use hands free calling. Dealer can advise the customer that the existing cell phone provider not having roaming agreements in areas outside of Canada.
• 10111849Mar 5, 2014Electrical system, Equipment. This Preliminary Information communication provides information to the technician about vehicles that have a frequent "off route" messages while following Turn by Turn route. Technicians will need to remove power from the Vehicle Communication Interface Module for one hour and retest for the concern.

← All problems reported for the 2014 Chevrolet Spark