2004 Chevrolet Tahoe Technical Service Bulletins

612 technical service bulletins (TSBs) are on record for the 2004 Chevrolet Tahoe. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10022914Oct 4, 2007Electrical system. One of the following concerns when programming the mileage or the hours into an exchange instrument panel cluster that is received from an electronic service center (esc).
• 10022766Sep 26, 2007Electrical system. Blown mbec 1 or lbec 1 fuse.
• 10023217Sep 1, 2007Exterior lighting. Turn signal in camper style outside rearview mirror (rpo dpn) does not illuminate turn signal flash (replace upper mirror glass)
• 10022482Aug 15, 2007Electrical system. Additional diagnostic for yaw/lat sensor dtc's.
• 10021676Jun 15, 2007Transmission and drivetrain. New design front axle side bearing adjusters.
• 10021673Jun 15, 2007Interior lighting. Ipc backlighting inoperative tbc 2a fuse open.
• 10022470Jun 1, 2007Brakes. Abs light on, dtc's c0265, c0201, u1041 set and/or loss of communication with brake module. (reground ebcm ground).
• 10022260Apr 1, 2007Engine cooling. Front blower motor inoperative or may not shut off in extremely low ambient temperature conditions.
• 10021133Mar 13, 2007Brakes. Service brake booster message.
• 10021075Mar 1, 2007Tires. Unable to program tire size in ebcm/vses.
• 10021021Feb 22, 2007Engine cooling. Service vme. Supplement to 00-02-35-003l. Update on new I-shaft.
• 10021019Feb 22, 2007Transmission and drivetrain. Slip condition in 2nd, 3rd, or 4th. Damaged 2-4 or 3-4 clutch. *kb updated 10/31/07.
• 10021010Feb 22, 2007Tires. Bridgestone dueler product information update.
• 10012089Feb 1, 2007Steering. Clunking noise under hood and can be felt in steering wheel. *eh updated *eh updated.
• 10017373Nov 1, 2006Equipment. Ei05082 - loss of blower motor speeds except for high speed or inoperative. *tt updated. *kb updated
• 10021017Sep 27, 2006Visibility (wipers, defrost, mirrors). Door glass pops out of run channel.
• 10020874Sep 23, 2006Suspension. Left front axle shaft difficult to remove. Axle differential leak seal shaft.
• 10019825May 3, 2006Tires. Service vme - aftermarket wheels/tire pressure monitor/fmvss 138.
• 10019852Mar 1, 2006Suspension. Revised upper control arm replacement.
• 10019186Feb 16, 2006Interior lighting, Exterior lighting. Ipc, interior lights and/or headlamps flicker. *ak fb2
• 10017462Feb 1, 2006Transmission and drivetrain. 4l60-e/4l65-e automatic transmission/torque converter clutch (tcc) shudder, water in transmission.
• 10014986Feb 1, 2006Brakes. Service stability message on, diagnostic trouble code (dtc) c0131, c0196, c0290 and/or c0292 set.
• 10018926Jan 25, 2006Transmission and drivetrain. 4wd inoperative and possible dtc c0327 stored in the transfer case control module.
• 10018623Jan 9, 2006Visibility (wipers, defrost, mirrors). Front hvac blower inoperative.
• 10018566Jan 6, 2006Visibility (wipers, defrost, mirrors). Front blower inoperative stay running during low ambient temperature.
• 10018544Jan 6, 2006Seats. Heated seat inoperative or shut off in 30 seconds. Diagnostic trouble codes b2435, b2440, b3606 and/or b1825 set in the drivers seat module.
• 10017310Nov 2, 2005Tires. Service tire pressure monitoring system diagnostics codes.
• 10017308Nov 2, 2005Suspension. Service vme - 8.6 inch rear axle which exhibit a gear whine condition (until december 23, 2005).
• 10017299Nov 2, 2005Transmission and drivetrain. Electronic transfer case unable to complete shift.
• 10017277Nov 1, 2005Visibility (wipers, defrost, mirrors). Unwanted operation of rear windows.
• 10011197Nov 1, 2005Suspension. 20 inch wheels and tires available through gmspo. *tt updated.
• 10017196Oct 28, 2005Engine cooling. Incorrect o2 sensors and wiring harness causing ho2 sensor heater circuit codes p0135 p0141 p0155 p0161.
• 10017155Oct 26, 2005Engine cooling. Diagnostic trouble code p0128 or engine will not reach operating temperature.
• 10017132Oct 25, 2005Visibility (wipers, defrost, mirrors). Blower motor inoperative at low ambient temperatures.
• 10017123Oct 25, 2005Visibility (wipers, defrost, mirrors). Service vme-outside rear view mirror inoperative.
• 10017100Oct 24, 2005Transmission and drivetrain. Tcc surge and/or fluid contamination.
• 10017092Oct 24, 2005Brakes. Service brake booster message.
• 10017015Oct 20, 2005Visibility (wipers, defrost, mirrors). Rear blower turns on by itself/defaults to high blower speed and/or defaults to full cold.
• 10016942Oct 18, 2005Engine cooling. Hard start or extended crank time on initial cold start when using alcohol blended fuels.
• 10016866Oct 13, 2005Tires. Bridgestone dueler product information update.
• 10016821Oct 12, 2005Electrical system. Bulletin-sit-bulletin-1656326: pit3569. Low tire light on and or dic check tire pressure message when cold.
• 10017764Oct 1, 2005Seats. Unwanted/loose seat movement.
• 10017760Oct 1, 2005Engine cooling. Lm7, l59 or l33 engines with cold start rough or incorrect idle, misfire, malfunction indicator lamp (mil) or flashing requiring o2 sensor replacement.
• 10016714Sep 28, 2005Suspension. Automatic level control inoperative due to water ingestion.
• 10016562Sep 22, 2005Tires. Low tire light on and or dic check tire pressure message when cold.
• 10016560Sep 22, 2005Tires. Check tire pressure message.
• 10016558Sep 22, 2005Transmission and drivetrain. Intermittent service 4wd light comes on with diagnostic trouble code (dtc) c0306 or c0308 stored in tccm.
• 10016554Sep 21, 2005Brakes. Hoot or squeak type noise on rapid brake apply.
• 10016529Sep 20, 2005Visibility (wipers, defrost, mirrors). Service vme - outside rearview mirror vibration.
• 10015018Sep 1, 2005Equipment. Information on upgrading certain onstar generation 5 analog/digital-ready systems to onstar generation 6 dual-mode (analog/digital).

← All problems reported for the 2004 Chevrolet Tahoe