2005 Chevrolet Tahoe Technical Service Bulletins

725 technical service bulletins (TSBs) are on record for the 2005 Chevrolet Tahoe. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10017177Oct 27, 2005Electrical system. Voltmeter is flucuating between 12 and 14 volts on their new 2005 chevrolet/ gmc/ cadillac model year light duty full size pickup and utility.
• 10017155Oct 26, 2005Engine cooling. Diagnostic trouble code p0128 or engine will not reach operating temperature.
• 10017149Oct 26, 2005Visibility (wipers, defrost, mirrors). Sunroof stuck open or will not close fully.
• 10017132Oct 25, 2005Visibility (wipers, defrost, mirrors). Blower motor inoperative at low ambient temperatures.
• 10017123Oct 25, 2005Visibility (wipers, defrost, mirrors). Service vme-outside rear view mirror inoperative.
• 10017100Oct 24, 2005Transmission and drivetrain. Tcc surge and/or fluid contamination.
• 10017099Oct 24, 2005Electrical system. Stability system disabled or service stability message with diagnostic trouble code c0455.
• 10017092Oct 24, 2005Brakes. Service brake booster message.
• 10017065Oct 21, 2005Transmission and drivetrain. No drive in d4 or d3. To include 2005 gmc jimmy.
• 10017015Oct 20, 2005Visibility (wipers, defrost, mirrors). Rear blower turns on by itself/defaults to high blower speed and/or defaults to full cold.
• 10016866Oct 13, 2005Tires. Bridgestone dueler product information update.
• 10016821Oct 12, 2005Electrical system. Bulletin-sit-bulletin-1656326: pit3569. Low tire light on and or dic check tire pressure message when cold.
• 10017764Oct 1, 2005Seats. Unwanted/loose seat movement.
• 10017760Oct 1, 2005Engine cooling. Lm7, l59 or l33 engines with cold start rough or incorrect idle, misfire, malfunction indicator lamp (mil) or flashing requiring o2 sensor replacement.
• 10016714Sep 28, 2005Suspension. Automatic level control inoperative due to water ingestion.
• 10016562Sep 22, 2005Tires. Low tire light on and or dic check tire pressure message when cold.
• 10016560Sep 22, 2005Tires. Check tire pressure message.
• 10016558Sep 22, 2005Transmission and drivetrain. Intermittent service 4wd light comes on with diagnostic trouble code (dtc) c0306 or c0308 stored in tccm.
• 10016554Sep 21, 2005Brakes. Hoot or squeak type noise on rapid brake apply.
• 10016529Sep 20, 2005Visibility (wipers, defrost, mirrors). Service vme - outside rearview mirror vibration.
• 10017831Sep 1, 2005Equipment. Navigation radio loses some options, dims or goes blank after a few hours of use (bulletin cancelled-no action required).
• 10017380Aug 1, 2005Seats. Intermittent heated seats inoperative, diagnostic trouble code b3941 set.
• 10011232Aug 1, 2005Seats. Memory seat may not return to requested position.
• 10017532Jun 1, 2005Tires. Tire pressure monitoring (tpm) system - system messages.
• 10014953May 12, 2005Transmission and drivetrain. Rear axle retainer button breakage.
• 10014931May 12, 2005Suspension. 8.625 axle phasing, growl, cyclic, noise while driving.
• 10014907May 11, 2005Transmission and drivetrain. To better understand sprag damage an engineering investigation is being conducted. Typical symptoms include no forward movement in d4 or d3 shift lever position. Movement can be obtained in d2, d1 or reverse.
• 10014899May 11, 2005Steering. Steering idler arm inspection procedure.
• 10014880May 11, 2005Transmission and drivetrain. 4l60e/4l65e no reverse.
• 10014879May 11, 2005Transmission and drivetrain. Investigation of pump area leaks.
• 10014870May 11, 2005Engine cooling. 1999 - 2005 gen ii cold engine misfire at idle with possible p0171 and/or p0174.
• 10014857May 11, 2005Transmission and drivetrain. Service 4wd light on with either a variety of diagnostic trouble codes or no communication with the transfer case control module.
• 10014853May 11, 2005Transmission and drivetrain. Intermittent malfunction indicator lamp (mil) with diagnostic trouble code (dtc) c0374 or erratic 4wd/awd operation.
• 10017409May 1, 2005Engine cooling. Oil leak under extreme cold temperatures (-34 degrees c) (-30 degrees f) or colder).
• 10017360May 1, 2005Visibility (wipers, defrost, mirrors). Sunroof jams when closing.
• 10017355May 1, 2005Transmission and drivetrain. 4l60-e/4l65-e automatic transmission 2-3 shift clunk.
• 10017354May 1, 2005Transmission and drivetrain. 4l60-e/4l65-e automatic transmission second gear start, lack/loss of power when accelerating from a stop.
• 10017348May 1, 2005Visibility (wipers, defrost, mirrors). Service information if sunroof will not close and synchronization procedure.
• 10013572Apr 21, 2005Transmission and drivetrain. 4wd models with noise, vibration on dry pavement.
• 10013548Apr 21, 2005Transmission and drivetrain. Investigation of extension seal leaks on 4l60e automatic transmission.
• 10013540Apr 21, 2005Electrical system. Unwanted operation of the hazard flashers.
• 10013537Apr 21, 2005Electronic stability control. Service stability message displayed in the dic. Diagnostic trouble codes c0290, c0292, c0131, or c0196 set in the ebcm.
• 10013533Apr 21, 2005Steering. Lack of steering assist or shudder during parking lot type maneuvers.
• 10013523Apr 21, 2005Air bags. Sir light on steady after bulb test and no diagnostic trouble codes (dtcs).
• 10013516Apr 20, 2005Engine cooling. Shudder or bind on truns in 4 hi. *eh updated 03-01-07.
• 10013502Apr 20, 2005Fuel system. Rust found in the injector inlet filter during injector repairs.
• 10013378Apr 18, 2005Electrical system. Application of horn at horn pad inoperative. Rke function for panic alarm works.
• 10017340Apr 1, 2005Tires. Tire pressure monitoring (tpm) system - tire mounting and dismounting.
• 10017339Apr 1, 2005Wheels. Handling characteristics of vehicles with 20 inch wheel/tire assemblies installed.
• 10014838Mar 9, 2005Equipment. Cds stick in cd player.

← All problems reported for the 2005 Chevrolet Tahoe