2016 Chevrolet Tahoe Technical Service Bulletins

1,769 technical service bulletins (TSBs) are on record for the 2016 Chevrolet Tahoe. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10082860Aug 3, 2016Equipment. This informational bulletin provides information on gm does not approve the use of “clipping” to repair collision damage to vehicles. Gm has not tested or validated a “clipped vehicle” repair; therefore, gm cannot endorse this type of repair or confirm the crash performance during a subsequent collision.
• 10082437Aug 3, 2016Air bags. This informational bulletin provides information on locating and reconnecting airbag connectors that are not fully seated to correct a customer concern of an airbag warning lamp illuminated, or one, or more, airbag dtc(s) set.
• 10082861Aug 2, 2016Electrical system. This technical bulletin provides a procedure to remove the transport mode on message displayed in the dic due to vehicles shipped over long distances outside the u.s. And canada.
• 10082823Aug 2, 2016Engine cooling. This informational bulletin explains the use of diesel fuel additives in an engine, are not required unless the customer desires additives to prevent fuel concerns depending on fuel or temperature related conditions.
• 10082814Aug 2, 2016Engine. This informational bulletin provides information to gm dealers on the correct cleaning methods when cleaning engine gasket sealing surfaces.
• 10082422Aug 2, 2016Equipment. This technical bulletin provides diagnostic tips to help correct multiple concerns regarding the usb port being inoperative or unable to play music through the usb port.
• 10082820Aug 1, 2016Engine. This informational bulletins provides information on the intake manifold inspection/replacement after servere internal engine damage.
• 10126063Jul 12, 2016Engine. This informational bulletin provides information on intake manifold inspection/replacement after severe internal engine damage.
• 10126062Jul 11, 2016Brakes. This informational bulletin provides information on installing the correct tires for vehicles with the condition of under hard acceleration at higher speeds, the traction control light will flash. Or, they may come in for ABS or general handling/braking concerns.
• 10100822Jul 11, 2016Engine. This informational bulletin provides the technician with what may happen to an engine due to lack of maintenance.
• 10100806Jul 11, 2016Engine cooling. This technical bulletin provides a procedure to replace the valve lifter oil manifold and the lifters to correct the customers concern of engine misfire, tick noise and mil on.
• 10100805Jul 11, 2016Seats. This engineering informational bulletin is requesting information from the field with the conditons of a rattle noise originating from the second row seat.
• 10089108Jun 30, 2016Equipment. This technical bulletin provides a procedure to reprogram the hmi module to correct a condition of gps inoperative, red line across gps indicator or the location is stuck in warren michigan.
• 10089121Jun 29, 2016Tires, Equipment. This informational bulletin provides guidance to gm dealers when using gm approved tire force variation measurement equipment.
• 10080981Jun 29, 2016Equipment. This preliminary information communicates the procedure to the technician how to regain blu-ray/cd/dvd player function on all new generation infotainment systems with regular production option code u42 or uwg blu-ray players. If this concern is encountered, cycle the cd player/media disc player fuse and re-evaluate the concern.
• 10081053Jun 27, 2016Brakes. This preliminary information communication provides information to the technician on the steps to diagnose and repair vehicles that may have issues were the customer will need increased effort to depress the brake pedal. Technician may find fluid in the brake booster and/or the booster vacuum line. Technician will need to replace vacuum pump, brake booster, master cylinder, vacuum pump belt and the vacuum line…
• 10081323Jun 22, 2016Electrical system, Equipment. This preliminary information communication advises the technician that some vehicles may have a dim driver information center when the interior of the vehicle is hot from a sun load or extended heater operation. The driver information center is designed to dim with high temperature exposure. This is done to protect the driver information center from damage.
• 10081049Jun 21, 2016Equipment, Seats. This preliminary information communication provides information to the technician on how to diagnose and repair vehicles that may have a rattle noise from the second row seat. Technician will need to inspect the striker not aligned properly in latch opening. To repair this condition, rework/adjust the striker in the direction to center it in the latch opening. An adjustable wide mouth metal working tool may be used…
• 10081961Jun 14, 2016Visibility (wipers, defrost, mirrors). This technical bulletin provides information on the proper reconnection of the rear window defroster tab if a customer comments one loose or broken.
• 10081241Jun 14, 2016Electrical system. This preliminary information communication provides information to the technician on how to diagnose and repair vehicle that may have a "check trailer wiring" or "service trailer brake system” message on the driver information center when a trailer is connected to the vehicle. Diagnostic trouble code c1114 set in the chassis control module. Chassis control module has to determine the type of trailer brake system…
• 10081043Jun 14, 2016Fuel system, Engine. This preliminary information communication provides information to the technician on how to diagnose and repair vehicles that may have rattle or ticking noise that is louder inside the vehicle than outside. The noise may also sound like a lifter tick. If the noise is heard best at the fuel line and the sound will be real loud with a stethoscope. The fuel line will need to be replaced.
• 10081022Jun 14, 2016Electrical system. This preliminary information communication advises the technician that ,when testing any circuit for open or resistance, it is imperative that all related terminal pin fit and tension be checked when the test steps require disconnection of the connector or component, prior to any component replacement. Always use the recommended terminal test tool during these tests.
• 10080702Jun 13, 2016Engine. This preliminary information communication provides information to the technician on how to diagnose and repair vehicles that may have diagnostic trouble code p06dd or no or low oil pressure. Technician will replace timing chain tensioner guide. If oil pump face is damaged and or worn thru replace oil pump. Inspect bearings for damage wear due to debris from oil pump.
• 10089201Jun 8, 2016Equipment. This warranty administration bulletin provides policy information on using gm service policies and procedure manual that represent key gm requirements for service operations.
• 10080686Jun 8, 2016Electrical system. This preliminary information communication provides information to the technician on the steps to diagnose and repair vehicles that may have an intermittent "check trailer wiring" or "service trailer brake" message on the driver information center. Technician will inspect and clean the ground wire (normally white wire) connection on the trailer side of the 7-pin connector. Inspect that the wires inside the trailer…
• 10080684Jun 8, 2016Engine. This preliminary information communication provides information to the technician the steps needed to diagnose and repair vehicles with a rough idle and/or vibration at idle in drive. This condition will not be present in park, or neutral. This concern may be caused by ground out within the one or both engine mounts. Technician will use ch-51450-a (pico oscilloscope) to measure the vibration disturbance.
• 10245966Jun 1, 2016Back-over prevention (rear camera). No Audio Except Chime Distorted Or Inoperative Rear Camera -No Audio- Displayed On Audio Page In DIC.
• 10114105May 31, 2016Engine, Electrical system. This informational bulletin provides information on identifying non-GM (aftermarket) engine calibrations for gasoline engines using Tech 2 or GDS 2.
• 10114101May 25, 2016Wheels. This informational bulletin updates General Motor's position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening or re-machining. Only cosmetic refinishing of the wheel's coatings, using recommended procedures, is allowed.
• 10118548May 24, 2016Visibility (wipers, defrost, mirrors), Equipment. This informational bulletin provides repair information on reconnection of rear window (defroster) contact or tab.
• 10078921May 24, 2016Equipment. This preliminary information communication provides the technician with a diagnostic aid for identifying infotainment components on the vehicles to ensure that the correct component is ordered or replaced and the correct labor code is used for warranty submission.
• 10118547May 20, 2016Tires. This informational bulletin provides information on the temporary tire flat spotting condition.
• 10114107May 20, 2016Electrical system. This informational bulletin provides information on service programming system (SPS) errors.
• 10078887May 18, 2016Steering, Equipment. This preliminary information communication provides information to the technician on how to diagnose and repair vehicles with one of the two concerns. Vehicle may have an intermittent "service power steering, drive with care" on the driver information center and a diagnostic trouble code c0545 symptom 00 set in the power steering control module.
• 10114111May 17, 2016Electrical system. This engineering information bulletin is requesting information from the dealers on a customer concern that one of the USB ports is not charging, allowing data to transfer.
• 10118546May 16, 2016Equipment. This informational bulletin provides information on a new U.S. dealer special tool loan program.
• 10118545May 16, 2016Electrical system, Equipment. This informational bulletin provides warranty policy information on revised wiring repair labor operations and required additional information.
• 10078881May 16, 2016Equipment, Electrical system. This preliminary information communication advises the technician that diagnostic trouble code b127e in the human machine interface with regular production option code u42 or uwg will be current when playing a dvd or blu-ray on the integrated center stack display. When the disc is ejected the diagnostic trouble code will be history.
• 10134546May 13, 2016Equipment, Back-over prevention (rear camera). This technical bulletin provides a procedure to reprogram the radio to correct a customer concern of radio Inoperative, blue Screen, AM clipping noise, HD on/off status not retained in stations, time lag on transitions, no audio with internal amp, and park assist symbol position wrong in rear view camera.
• 10134545May 13, 2016Electrical system. This informational bulletin provides warranty information on accessory power outlet and trailer lighting fuse replacement.
• 10078877May 11, 2016Electrical system. This preliminary information communication provides the technician with the steps needed to diagnose and repair a vehicle with wi-fi or bluetooth inoperative or poor performance concern. Technician will need to obtain data from global diagnostics services 2 and call general motors technical assistance center for further assistance.
• 10134541May 10, 2016Electrical system, Visibility (wipers, defrost, mirrors). This technical bulletin provides a procedure to reprogram the BCM to correct a customer concern on a dead battery or no start and DTC B1527 set caused by to the child window lock, when active, causing the BCM to continuously wake up and run the battery down.
• 10078875May 10, 2016Electrical system, Brakes. This preliminary information communication advises the technician that vehicles equipped with ultrasonic park assist system regular production option code ud5 or ud7 with a diagnostic trouble code u0159 set in the instrument panel cluster and /or the body control module engineering is currently working on an updated calibration to correct the concern.
• 10134536May 6, 2016Equipment. This warranty administration bulletin provides information on GM?s policy on performing GM covered vehicle services and maintenance on vehicles originating/sold in Canada.
• 10081365May 6, 2016Electrical system. This informational bulletin provides information on the identification of vehicles that are shipped with the transport mode on and how to turn it off.
• 10078860May 2, 2016Visibility (wipers, defrost, mirrors). This preliminary information communication provides the technician with steps to resolve the issue of an oily substance that may be found on the inside windshield surface, and appears to be leaking from the rear view mirror area. Technician will remove the moisture sensor and clean the glass and mounting bracket with alcohol wipe. If the gel separates from the sensor the sensor will need to be replaced.
• 10078583May 1, 2016Equipment. This informational bulletin provides information to advise the customers that have enrolled their vehicle into the onstar advanced diagnostics & real time diagnostic alerts they may receive alerts from their vehicle when it is being serviced.
• 10078571May 1, 2016Equipment. This informational bulletin provide information on the product quality center (pqc) assembly replacement process.
• 10078569May 1, 2016Fuel system, Other or unknown. This informational bulletin provides information on vehicles designed to operate on gaseous fuels.
• 10078568May 1, 2016Transmission and drivetrain, Equipment. This informational bulletin provides information on how to inspect the upper valve body to determine the correct rpo usage to correct a concern that after installation of a replacement upper valve body, the transmission may have no reverse and no 2nd gear due to the installation of the incorrect upper valve body.

← All problems reported for the 2016 Chevrolet Tahoe