2005 Chevrolet Uplander Recalls

NHTSA lists 3 recall campaigns for the 2005 Chevrolet Uplander. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.

• 10V110000Mar 19, 20105,375 vehicles potentially affected
  Suspension › Rear
  Covers: Chevrolet Uplander 2005–2008, Pontiac Montana 2005–2008, Buick Terraza 2005–2008

  Reported issue: The braun corporation has notified nhtsa about a defect in certain model year 2005-2008 general motors mobility conversion, handicapped accessible low floor minivans. During conversion, the driver or passenger side trailing arm modification may not have been adequately welded.

  Possible consequence: A squeaking or clunking noise may develop. The trailing arm bushings may prematurely wear and the trailing arm may fracture or separate, allowing the rear axle to become partially separated from the chassis increasing the risk of a crash.

  Remedy: Dealers will inspect and will have a supply of retrofit parts available to remedy the vehicles free of charge. The safety recall began on june 4, 2010. Owners may contact braun at 1-800-488-0359.

  Full campaign details →

• 05V287000Jun 20, 200514,600 vehicles potentially affected
  Parking brake
  Covers: Chevrolet Uplander 2005, Pontiac Montana 2005, Buick Terraza 2005 +1 more

  Reported issue: Certain sport utility vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 135, 'passenger car brake systems.' to meet the standard, the vehicle must not move for five minutes when stopped on a steep hill with the parking brake applied and the vehicle in neutral (n). Some of these vehicles failed this test.

  Possible consequence: When the parking brake is released, the driver may notice unintended braking when accelerating, decelerating, or coasting, and a noise coming from the rear of the vehicle. Unintended vehicle movement could occur increasing the risk of a crash.

  Remedy: Dealers will inspect for parking brake lever slippage at each rear brake caliper and replace the caliper if lever slippage is identified. The recall began on november 14, 2005. Owners may contact buick at 1-866-608-8080, chevrolet at 1-800-630-2438, pontiac at 1-800-620-7668, or saturn at 1-800-972-8876.

  Full campaign details →

• 05V061000Feb 18, 200518,850 vehicles potentially affected
  Seats › Mid/rear assembly
  Covers: Chevrolet Uplander 2005, Pontiac Montana 2005, Saturn Relay 2005

  Reported issue: On certain minivans, the outboard release handle on the impact-side second-row bucket seat may be actuated and the rear latches may unlatch early in a side impact crash. This was discovered in a side impact test run by gm, under conditions similar to nhtsa's new car assessment program (ncap) side impact test.

  Possible consequence: If the rear latches of the seat release early in a severe side impact, the front outboard latch may disengage and increase the potential for injury to the occupant of the seat.

  Remedy: Dealers will remove the seat latch release handle and install a black plastic cap over the exposed metal stud to eliminate the side impact safety concern free of charge. The recall began on april 5, 2005. Owners may contact saturn at 1-800-972-8876, chevrolet at 1-800-630-2438, and pontiac at 1-800-620-7668.

  Full campaign details →

← All problems reported for the 2005 Chevrolet Uplander