1992 Dodge Caravan Recalls
NHTSA lists 9 recall campaigns for the 1992 Dodge Caravan. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.
- Visibility › Windshield wiper/washer › LinkagesCovers: Dodge Caravan 1991–1993, Plymouth Voyager 1991–1993, Chrysler Town And Country 1991–1993 +2 more
Reported issue: Vehicle description: minivans. The left hand windshield wiper pivot drive arm was not mechanically staked to the pivot shaft.
Possible consequence: This could allow the drive arm to disengage from the shaft leading to a loss of wiper function. The driver's visibility would be impaired, increasing the risk of a crash.
Remedy: Dealers will replace the left hand side windshield wiper pivot assembly.
- Seat belts › Front › Buckle assemblyCovers: Dodge Caravan 1991–1993, Plymouth Voyager 1991–1993, Chrysler Town And Country 1991–1993 +2 more
Reported issue: Vehicle description: passenger mini-vans. Covers on the solid stalk mounted seat belt buckles can become dislodged causing the release button to stick inside the cover. The buckle would then be only partially latched.
Possible consequence: In the event of a vehicle crash, the occupant may not be properly restrained increasing the risk of personal injury.
Remedy: Dealers will install a cover retaining clip to the stalk mounted buckle cover to prevent dislocation of the buckle cover.
- Seat belts › Front › AnchorageCovers: Dodge Caravan 1991–1993, Plymouth Voyager 1991–1993, Chrysler Town And Country 1991–1993 +2 more
Reported issue: Vehicle description: passenger mini-vans. The center rear seat, right outboard side, safety belt anchor hook can become unattached from the body anchor position.
Possible consequence: In the event of a vehicle crash, the occupant may not be properly restrained increasing the risk of personal injury.
Remedy: Dealers will replace the anchor hook retaining clip with a revised profile clip and a cover plate.
- Structure › Body › Hatchback/liftgate › Support device/strutCovers: Dodge Caravan 1992, Plymouth Voyager 1992, Chrysler Town And Country 1992 +2 more
Reported issue: The bolts used to attach the strut to the body and the rear liftgate can accumulate fatigue damage if three factors combine. If the bolt is loose, the gas strut is over-pressurized, and the frequency of opening and closing cycles is higher than for the average customer, the bolt can fail.
Possible consequence: Personal injury could occur if the bolts break allowing the liftgate to fall suddenly.
Remedy: Dealers will inspect for loose fasteners, if the fasteners are loose, the strut (and integral bolts) will be replaced. If the bolt shows evidence of torque, the bolt will be removed, larger washers will replace the existing washer and the bolt will be reinstalled and hand tightened to the target torqued.
- Steering › Steering wheel/handle barCovers: Dodge Caravan 1991–1992, Plymouth Voyager 1991–1992, Chrysler Town And Country 1991–1992 +4 more
Reported issue: The steering wheel armature stamping can crack and separate from the center hub attachment to the steering column.
Possible consequence: If the steering wheel separates from the center hub attachment to the steering column, loss of control can occur increasing the risk of an accident.
Remedy: Dealers will inspect the steering wheel for armature cracks in the center hub attachment area. Any steering wheels showing cracks will be replaced. All other vehicles will have a reinforcement plate installed to prevent steering wheel separation in the event cracking occurs.
- Service brakes, hydraulic › Antilock/traction control/electronic limited slipCovers: Dodge Caravan 1991–1993, Dynasty 1990–1993, Chrysler NEW Yorker 1990–1993 +7 more
Reported issue: The abs hydraulic control unit can experience excessive brake actuator piston seal wear causing pump-motor deterioration.
Possible consequence: If this condition occurs, the abs function could be lost and reduced power assist would be experienced during vehicle braking increasing the potential for a vehicle accident.
Remedy: Dealers will test the vehicle's anti-lock brake system and repair the vehicles if necessary. Also the warranty on all abs components will be extended to 10 years or 100,000 miles (except for the brake actuator piston assembly and the pump-motor assembly which will have a lifetime coverage). Owners will also be…
- Fuel system, gasolineCovers: Dodge Caravan 1992, Plymouth Voyager 1992, Chrysler Town And Country 1992
Reported issue: Fuel tank flanges were not bent as required to allow the specified clearance for the fuel tank mounting straps and fuel lines at the tank.
Possible consequence: The unbent flanges to the fuel tank will damage themounting straps and/or fuel lines. The damaged mounting straps may break causingthe tank to drop and the damaged fuel line will leak fuel. In either case a firecould result if the spilled fuel is exposed to an ignition source.
Remedy: Repair the flange by bending to the correct angle; replace damaged fuel lines and mounting straps.
- Steering › Steering wheel/handle barCovers: Dodge Caravan 1992, Plymouth Acclaim 1992, Voyager 1992 +10 more
Reported issue: The zinc plating operation performed on the upper steering column shaft coupling bolt caused hydrogen embrittlement and breakage of the bolt.
Possible consequence: Fractures of the upper steering column shaft couplingbolt result in a lack of coupling load on the shaft and loss of steeringcontrol.
Remedy: Replace the zinc plated bolt with a phosphate plated bolt.
- Service brakes, hydraulic › Pedals and linkagesCovers: Dodge Caravan 1992, Plymouth Voyager 1992
Reported issue: The brake pedal pad attachment to the pedal arm may not have adequate strength due to mislocation of welds, and could break.
Possible consequence: Failure of the pedal pad to pedal arm attachment resultsin loss of braking ability, and could result in an accident.
Remedy: Replace inadequate brake pedals with properly manufactured pedals.
NHTSA investigations
← All problems reported for the 1992 Dodge Caravan
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 29, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.