2015 Dodge Challenger Technical Service Bulletins

350 technical service bulletins (TSBs) are on record for the 2015 Dodge Challenger. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10217522Mar 15, 2017Wheels, Transmission and drivetrain. Rear Axle Assembly If replacing Limited Spin Differential (LSD)/Anti-Spin Differential rear axles for any reason, the Mopar replacement axle will need the oil drained and re-filled with oil PN: 68083381AA (which contains updated friction modifier). This change was recently introduced in production to help address axle noise concerns being reported from the field while the vehicle is performing tight turning…
• 10217521Mar 15, 2017Fuel system. Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 [email protected], or Joe Lovell (734) 309-6467 [email protected] before proceeding. If unable to reach after 15 minutes record the following information and proceed with oil pump…
• 10139990Mar 15, 2017Transmission and drivetrain. Rear Axle Assembly If replacing Limited Spin Differential (LSD)/Anti-Spin Differential rear axles for any reason, the Mopar replacement axle will need the oil drained and re-filled with oil PN: 68083381AA (which contains updated friction modifier). This change was recently introduced in production to help address axle noise concerns being reported from the field while the vehicle is performing tight turning…
• 10139989Mar 15, 2017Engine cooling. Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 [email protected], or Joe Lovell (734) 309-6467 [email protected] before proceeding. If unable to reach after 15 minutes record the following information and proceed with oil pump…
• 10139978Mar 8, 2017Seat belts. Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
• 10139985Mar 1, 2017Seat belts. Restraints Information Sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
• 10121890Nov 29, 2016Equipment. Replace Vehicle Emission Certification Information Label This bulletin involves replacing the Vehicle Emission Certification Information (VECI) Label.Owner may be turned away from Inspection and Maintenance (IM) station or fail IM testing because of missing emission components on VECI label. The customer may notice that some info is missing on their VECI labels.is missing.
• 10223853Sep 30, 2016Equipment. Replace Vehicle Emission Certification Information Label This bulletin involves replacing the Vehicle Emission Certification Information (VECI) Label.Owner may be turned away from Inspection and Maintenance (IM) station or fail IM testing because of missing emission components on VECI label. The customer may notice that some info is missing on their VECI labels.is missing.
• 10223849Sep 28, 2016Brakes. Vibration While Braking This bulletin involves resurfacing either front/rear or all rotors and if necessary, replacing either front/rear or all brake rotors due to inactivity on dealer lots. The customer may describe a shake and/or vibration in the steering wheel and/or the seat while the brakes are applied. This vibration may be caused by corrosion on the brake rotors.
• 10223843Sep 24, 2016Brakes. Vibration While Braking This bulletin involves resurfacing either front/rear or all rotors and if necessary, replacing either front/rear or all brake rotors due to inactivity on dealer lots. The customer may describe a shake and/or vibration in the steering wheel and/or the seat while the brakes are applied. This vibration may be caused by corrosion on the brake rotors.
• 10223855Sep 7, 2016Visibility (wipers, defrost, mirrors). Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform the this inspection. Inspect the sensor for a fluid coating on the sensor pins. Orange colored rain repellant can cause this fluid build-up. Clean the pins, drain the reservoir, and fill with Mopar approved washer fluid. Check to determine if the issue has…
• 10217746Aug 17, 2016Equipment, Electrical system, Steering. Electric Power Steering Gear For LA, LD and LX Models ONLY; Before this part is replaced for: A) Electrical, Communication or DTC issue please contact: Terry Gavit @ cell (248) 882-6108 [email protected] Engineering is requesting a copy of VSR to be emailed to the above address. B) Noise or Mechanical issue please contact: Barbara Strace @ cell (586) 246-4211. If you do not receive a return call within 15…
• 10135122Aug 17, 2016Electrical system. Electric Power Steering Gear For LA, LD and LX Models ONLY; Before this part is replaced for: A) Electrical, Communication or DTC issue please contact: Terry Gavit @ cell (248) 882-6108 [email protected] Engineering is requesting a copy of VSR to be emailed to the above address. B) Noise or Mechanical issue please contact: Barbara Strace @ cell (586) 246-4211. If you do not receive a return call within 15…
• 10129037Aug 17, 2016Transmission and drivetrain, Steering. Electric Power Steering Gear For LA, LD and LX Models ONLY; Before this part is replaced for: A) Electrical, Communication or DTC issue please contact: Terry Gavit @ cell (248) 882-6108 [email protected] Engineering is requesting a copy of VSR to be emailed to the above address. B) Noise or Mechanical issue please contact: Barbara Strace @ cell (586) 246-4211. If you do not receive a return call within 15…
• 10228153Aug 10, 2016Wheels, Brakes. Hub & Bearing Assy - Front For LA, LD SRT vehicles with the 2-piece front brake rotor (BR7 sales code), do NOT replace the front Hub & Bearing Assy for a clicking noise occurring while turning during low speed parking lot maneuvers. Instead, remove front wheels and rotors and clean mating surfaces (wheel mounting face, rotor mounting faces (both sides), and hub face) with a Scotch Brite Pad or equivalent, and…
• 10220269Aug 10, 2016Transmission and drivetrain. Hub & Bearing Assy - Front For LA, LD SRT vehicles with the 2-piece front brake rotor (BR7 sales code), do NOT replace the front Hub & Bearing Assy for a clicking noise occurring while turning during low speed parking lot maneuvers. Instead, remove front wheels and rotors and clean mating surfaces (wheel mounting face, rotor mounting faces (both sides), and hub face) with a Scotch Brite Pad or equivalent, and…
• 10140197Aug 10, 2016Wheels. Hub & Bearing Assy - Front For LA, LD SRT vehicles with the 2-piece front brake rotor (BR7 sales code), do NOT replace the front Hub & Bearing Assy for a clicking noise occurring while turning during low speed parking lot maneuvers. Instead, remove front wheels and rotors and clean mating surfaces (wheel mounting face, rotor mounting faces (both sides), and hub face) with a Scotch Brite Pad or equivalent, and…
• 10084055Aug 5, 2016Transmission and drivetrain. "flash: diagnostic and system improvements this bulletin involves reprogramming of the powertrain control module (pcm) with the latest available software. Customers may experience one or more of the following symptoms and/or a malfunction indicator lamp (mil) illumination. Upon further investigation the technician may find one or more of the following dtcs: · **p2299 - brake pedal position/accelerator pedal…
• 10084057Jul 30, 2016Transmission and drivetrain. "flash: powertrain diagnostic and system enhancements. This bulletin involves reprogramming the powertrain control module (pcm) and transmission control module (tcm) the latest available software.customers may experience a malfunction indicator lamp (mil) illumination. Upon further investigation, the technician may find one or more of the following diagnostic trouble codes (dtcs) stored in the pcm memory:
• 10121683Jul 20, 2016Engine cooling. 3.2L - 3.6L Cylinder Head Assy Multiple cylinder head replacement. If cylinder head is replaced on a vehicle more than 1 time for any reason, please call any of the following people.~ First: Ron Dallison ? Cell (248) 292-9510 [email protected] ~ Second: Joe Lovell - Cell (734) 309-6467 [email protected]~ If a response is not received within 15 mins, then proceed with the necessary repair.
• 10121692Jul 19, 2016Equipment, Visibility (wipers, defrost, mirrors), Engine cooling. Flash: HVAC System Enhancement This bulletin involves reprogramming the Heating Ventilation Air Conditioning (HVAC) Module with new software. Customers may describe an unpleasant odor in the vehicle after driving from highway speed limits back down to city speed limits or they may also notice that the left temp door is inoperable. Updating the HVAC software will correct these conditions.
• 10121676Jul 15, 2016Body and structure, Electrical system, Transmission and drivetrain. Flash: 5.7L Diagnostic And System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs): · **P0456 - Evap System Small Leak. · P2610 - PCM Internal…
• 10121649Jul 8, 2016Electrical system. RG3 RG4 RJ3 RJ4 Radio EnhancementsThis bulletin involves inspecting and if required, updating the radio software.A small number of customers may experience one or more of the following: · Blind Spot module beep or chime sound may be heard continuously (KL Only). · Radio may keep the CAN bus network awake, causing a battery drain.
• 10080403Jun 29, 2016Engine cooling. "exhaust actuator and valve spring if an electronic exhaust valve spring is broken, please replace the spring with pn 68319331aa~ - if spring is not broken and replacing actuator, please contact jason maltese cell (248) 931-4179 - exhaust engineer. ~ if no response in 15 minutes, proceed with repair"
• 10218282Jun 24, 2016Back-over prevention (rear camera). Inspect And Replace Propeller Shaft This bulletin involves inspecting and replacing the propeller shaft due to a whining noise at high speeds. SYMPTOM/CONDITION: The customer or technician may hear a whining noise coming from the rear axle area.
• 10140149Jun 24, 2016Transmission and drivetrain. Inspect And Replace Propeller Shaft This bulletin involves inspecting and replacing the propeller shaft due to a whining noise at high speeds. SYMPTOM/CONDITION: The customer or technician may hear a whining noise coming from the rear axle area.
• 10082441Jun 24, 2016Transmission and drivetrain. "inspect and replace propeller shaft this bulletin involves inspecting and replacing the propeller shaft due to a whining noise at high speeds. Symptom/condition: the customer or technician may hear a whining noise coming from the rear axle area."
• 10218267Jun 22, 2016Electrical system, Brakes. Anti-Lock Brake Module (ABS) Before replacing the ABS module, please call Fadi Korkis at cell (586) 722-4100. If you don't receive response within 15 minutes, please continue with normal repair procedure.
• 10140134Jun 22, 2016Brakes, Electrical system. Anti-Lock Brake Module (ABS) Before replacing the ABS module, please call Fadi Korkis at cell (586) 722-4100. If you don't receive response within 15 minutes, please continue with normal repair procedure.
• 10080220Jun 22, 2016Brakes. "anti-lock brake module (abs) before replacing the abs module, please call fadi korkis at cell (586) 722-4100. If you don't receive response within 15 minutes, please continue with normal repair procedure."
• 10217608Jun 17, 2016Electrical system, Transmission and drivetrain. Flash: Transmission Shift And Drivability Enhancements This bulletin involves reprogramming of the Transmission Control Module (TCM) with the latest available software. A small number of customers may experience an erroneous Malfunction Indicator Lamp (MIL) Illumination. Upon further investigation, the technician may find a Diagnostic Trouble Code (DTC) stored in the TCM memory.
• 10217606Jun 17, 2016Transmission and drivetrain, Engine cooling, Electrical system. Flash: Diagnostic And System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with updated software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following (DTCs) set in the PCM memory: · **P0456 - EVAP System Small Leak. · P0335 - Crankshaft Position Sensor Circuit. · P2610 - PCM Internal Engine…
• 10140118Jun 17, 2016Electrical system, Transmission and drivetrain. Flash: Transmission Shift And Drivability Enhancements This bulletin involves reprogramming of the Transmission Control Module (TCM) with the latest available software. A small number of customers may experience an erroneous Malfunction Indicator Lamp (MIL) Illumination. Upon further investigation, the technician may find a Diagnostic Trouble Code (DTC) stored in the TCM memory.
• 10140116Jun 17, 2016Transmission and drivetrain, Electrical system. Flash: Diagnostic And System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with updated software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following (DTCs) set in the PCM memory: · **P0456 - EVAP System Small Leak. · P0335 - Crankshaft Position Sensor Circuit. · P2610 - PCM Internal Engine…
• 10080071Jun 17, 2016Transmission and drivetrain, Electrical system. "flash: transmission shift and drivability enhancements this bulletin involves reprogramming of the transmission control module (tcm) with the latest available software. A small number of customers may experience an erroneous malfunction indicator lamp (mil) illumination. Upon further investigation, the technician may find a diagnostic trouble code (dtc) stored in the tcm memory.
• 10080067Jun 17, 2016Electrical system, Transmission and drivetrain. "flash: diagnostic and system improvements this bulletin involves reprogramming the powertrain control module (pcm) with updated software. Customers may experience a malfunction indicator lamp (mil) illumination. Upon further investigation the technician may find the following (dtcs) set in the pcm memory: · **p0456 - evap system small leak. · p0335 - crankshaft position sensor circuit. · p2610 - pcm internal…
• 10226262Jun 8, 2016Electrical system. Integrated Center Stack If vehicle is found within 50 mile radius of the Detroit Metro area please hold vehicle and contact:~ Contact one of the following:~ Daniel Acciacca CELL (586) 709-1537~ Michael Savich CELL (248) 214-7270~ Ayed Hadaad CELL (248) 941-8707~ Issue: On a 2015 & 2016MY LA (Challenger), LD(Charger) and LX (300), the Integrated Center Stack (ICS) may experience a lock-up/Inop condition (complete…
• 10219814Jun 1, 2016Transmission and drivetrain. 9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH pop ups and Warranty Payment Guidelines. If this vehicle contains 1 of the 30 Diagnostic Codes in the 9 Speed Tutorial located on the Service Home Page then please follow the repair steps and submit a Topology report as well as a Vehicle Scan Report with the Warranty Claim.~
• 10218250Jun 1, 2016Transmission and drivetrain. 9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH pop ups and Warranty Payment Guidelines. If this vehicle contains 1 of the 30 Diagnostic Codes in the 9 Speed Tutorial located on the Service Home Page then please follow the repair steps and submit a Topology report as well as a Vehicle Scan Report with the Warranty Claim.~
• 10218248Jun 1, 2016Engine cooling. Pentastar Oil Filter Adapter: Before replacing this part, please call any one of the following people. Engineering is seeking information regarding this part.~ Dye must be used to determine where the leak is coming from before replacing. Also please check the recently updated Service Bulletin Number 09-008-15.
• 10139936Jun 1, 2016Transmission and drivetrain. 9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH pop ups and Warranty Payment Guidelines. If this vehicle contains 1 of the 30 Diagnostic Codes in the 9 Speed Tutorial located on the Service Home Page then please follow the repair steps and submit a Topology report as well as a Vehicle Scan Report with the Warranty Claim.~
• 10139934Jun 1, 2016Engine cooling. Pentastar Oil Filter Adapter: Before replacing this part, please call any one of the following people. Engineering is seeking information regarding this part.~ Dye must be used to determine where the leak is coming from before replacing. Also please check the recently updated Service Bulletin Number 09-008-15.
• 10228120May 25, 2016Equipment, Back-over prevention (rear camera), Transmission and drivetrain. Manual Transmission Shifter Noise This bulletin involves greasing or replacing the manual transmission rear shifter bushing. Customers may experience a clunk, squeak, or similar noise heard from center console area while shifting.
• 10181486May 25, 2016Equipment, Transmission and drivetrain. Manual Transmission Shifter Noise This bulletin involves greasing or replacing the manual transmission rear shifter bushing. Customers may experience a clunk, squeak, or similar noise heard from center console area while shifting.
• 10141286May 25, 2016Transmission and drivetrain. Manual Transmission Shifter Noise This bulletin involves greasing or replacing the manual transmission rear shifter bushing. Customers may experience a clunk, squeak, or similar noise heard from center console area while shifting.
• 10228135May 19, 2016Equipment, Electrical system. RA3/RA4 Radio Software Enhancements
• 10228098May 18, 2016Engine cooling. 3.2L - 3.6L Cylinder Head Assy Multiple cylinder head replacement. If cylinder head is replaced on a vehicle more than 1 time for any reason, please call any of the following people.~ First: Ron Dallison ? Cell (248) 292-9510 [email protected] ~ Second: Joe Lovell - Cell (734) 309-6467 [email protected]~ If a response is not received within 15 mins, then proceed with the necessary repair.~
• 10228134May 13, 2016Equipment, Electrical system. RA3/RA4 Radio Software Enhancements
• 10220438May 13, 2016Back-over prevention (rear camera). Radio software enhancement.
• 10220437May 13, 2016Equipment. Radio software enhancement.

← All problems reported for the 2015 Dodge Challenger