2019 Dodge Challenger Technical Service Bulletins

315 technical service bulletins (TSBs) are on record for the 2019 Dodge Challenger. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10168469Oct 18, 2019Transmission and drivetrain, Electrical system. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Code (DTC) has been set:P0456 - EVAP System Small Leak.
• 10168467Oct 17, 2019Transmission and drivetrain, Electrical system. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Code (DTC) has been set: P0456 - EVAP System Small Leak.
• 10168388Oct 17, 2019Fuel system, Transmission and drivetrain. SEAL, Input If looking to replace stubshaft due to ATX fluid leaking, do not replace PTU seals. None of the seals from the PTU side will need to be replaced whenever the ATX stubshaft is replaced, even though V-seal (68408748A$) is in direct contact with the stubshaft, it will not avoid grease/oil leakage from transmission side. PTU V-seals are intended to act as a dust cover for stubshaft - PTU input shaft spline…
• 10168459Oct 12, 2019Transmission and drivetrain. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Code (DTC) has been set: P0456 - EVAP System Small Leak. Customers may also experience the following: Extended engine crank…
• 10168450Oct 11, 2019Transmission and drivetrain. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Code (DTC) has been set: P0456 - EVAP System Small Leak. Customers may also experience the following: Extended engine crank…
• 10168449Oct 11, 2019Equipment, Electrical system. Flash: HVAC System Enhancement This bulletin involves reprogramming the Heating Ventilation Air Conditioning (HVAC)Module with new software. Customers may experience one of the following:Unpleasant odor in the vehicle after driving from highway speed limits back downto city speed limits. The left temperature door is inoperable(2014-2018 Vehicles Only). Updating the HVAC software will correct these conditions.
• 10168434Oct 3, 2019Visibility (wipers, defrost, mirrors). Door Glass Stops Prior To Full Up Or Down Position This bulletin involves testing and if necessary, replacing the window regulator motor on one or both doors. The customer may describe the following:The door glass may stop prior to reaching full up or down position on one or both doors. Upon further investigation the technician may find the following Diagnostic Trouble Code (DTC) has been set:B18BA-13 - Window…
• 10166601Aug 29, 2019Electrical system, Back-over prevention (rear camera), Equipment. Radio and Back-up Camera Enhancements This bulletin involves updating the radio software level to 1848.24. Customers may experience one or more of the following: Green horizontal lines on back up display, in reverse (If this is the customer concern use camera LOP 18-60-02-W2, on DT and JL vehicles only). Ghost Touch, features, modes and App?s changing without drivers input. Speaker pop noise when using Bluetooth…
• 10166549Aug 28, 2019Engine cooling, Engine. RETAINER, Crankshaft Rear Oil Seal Oil leak from rear engine seal retainer or windage tray/gasket Check for other sources of leaks using dye such as gallery plugs, camshaft cup plug at rear of engine, rear of engine valley for possible MDS solenoid, VVT solenoid, block porosity or transmission leaks. If another source of the leak was identified, proceed with the appropriate repairs.
• 10166585Aug 16, 2019Electrical system, Back-over prevention (rear camera). Radio and Back-up Camera Enhancements This bulletin involves updating the radio software level to 1848.24. Customers may experience one or more of the following:Green horizontal lines on back up display, in reverse (If this is the customer concern use camera LOP 18-60-02-W2, on DT and JL vehicles only). Ghost Touch, features, modes and App?s changing without drivers input. Speaker pop noise when using Bluetooth…
• 10166537Aug 7, 2019Equipment. RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Please verify that the radio part number and/or serial number is not "FFFF". If either field shows "FFFF", please contact Mike Wielgat at 248-576-6696 or Rohan Negandhi at 248-421-9608 If no response in 15 minutes, proceed with repair.
• 10166535Aug 7, 2019Engine. SEAL, Crankshaft Oil, Front Front crankshaft oil seal leak: For concern of front crankshaft seal leak please send an email to [email protected] with VIN, Mileage, Photos and indicate where the leak is identified using dye such as: 1. Leak between the outer diameter of the seal to front cover? 2. Leak between the seal and damper 3. Leak through the damper bolt This will help in determining root cause and…
• 10162565May 21, 2019Equipment. UJQ with RS9 Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to 21.9. Customers may experience one or more of the following:Arabic language is not listed in language page. Radio may reset, turn itself off and then back on again. Radio display screen lock up. Park assist chime will continue to chime after the vehicle is turned off. Russian language is not…
• 10162476May 15, 2019Seats. ADJUSTER, Seat For passenger seat exhibiting high fore/aft adjuster effort, please call Randy Olejniczak ar 248-766-4821. If front passenger seat is unbolted, please notice if the seat tracks seem to be out of alignment or not aligned properly with the front mounting holes in the floor pan. If no response in 15 minutes, proceed with repair.
• 10162471May 15, 2019Equipment. ACTUATOR, A/C and Heater Before replacing HVAC actuator, please contact either Thomas Conway (248) 635-7090 or Paul Aquino (248) 854-4819. Engineering is looking to gather infomation on fail mode and customer concern. If no response in 15 minutes, proceed with repair.

← All problems reported for the 2019 Dodge Challenger