2015 Dodge Charger Technical Service Bulletins

328 technical service bulletins (TSBs) are on record for the 2015 Dodge Charger. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10160063Dec 19, 2015Exterior lighting. Premature Headlamp Bulb Failure This bulletin involves replacement of both headlamp bulbs. The customer may experience premature headlamp failure.
• 10160058Dec 19, 2015Electrical system. Flash: Vehicle System Interface Module Enhancements This bulletin involves updating the Vehicle System Interface Module (VSIM) software. A customer may experience that the VSIM controlled systems become inoperative. Upon further investigation the technician should find the following: ? There should be NO DTCs set, stored by or against the VSIM. ? VSIM?s hard wired outputs should be locked, but VSIM should be alive…
• 10160057Dec 19, 2015Electrical system, Transmission and drivetrain. Flash: Vehicle System Interface Module Enhancements This bulletin involves updating the Vehicle System Interface Module (VSIM) software. A customer may experience that the VSIM controlled systems become inoperative. Upon further investigation the technician should find the following: ? There should be NO DTCs set, stored by or against the VSIM. ? VSIM?s hard wired outputs should be locked, but VSIM should be alive…
• 10160054Dec 19, 2015Equipment, Electrical system. Flash: Bass, Mid, Treble Adjustment Causes Erratic Volume Increases This bulletin involves reprogramming the Amplifier (AMP) with the latest available software. The customer may describe when changing the radio tone settings (bass, mid, treble) the volume levels may be erratic. Depending where the volume is set, the volume changes may be very loud or very quiet. Example: When the volume is set to 8 and making…
• 10159998Dec 16, 2015Vehicle speed control. Part Description: Accelerator Pedal Issue Description: Vehicle has accelerator pedal fault code. Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. DTC P2299 is usually caused by a two footed driver and accelerator pedal should not be replaced for this fault.
• 10159997Dec 16, 2015Steering. Before replacing this part for any issue, please record DTCs and call John Grzecki at cell (248) 379-0969. If you do not receive a return call within 15 minutes, then proceed with necessary repair.~ Please document all DTCs identified with the scan tool on the repair order narratives.~
• 10159993Dec 9, 2015Brakes. Part Description: Rotor - Front 2 Piece Issue Description: For SRT vehicles with the 2-piece Front Rotor (BR7 sales code), do NOT replace the rotor for a clicking noise occuring while turning at low parking lot speeds. Instead, remove front wheels and rotors and clean mating surfaces (wheel mounting face, rotor mounting faces (both sides), and hub mounting face) with a Scotch Brite Pad or equivalent, and…
• 10159989Dec 9, 2015Transmission and drivetrain. Part Description: Powertrain Control Module Issue Description: Before replacing the Powertrain Control Module on 2015-2016 6.2L Supercharged Hellcat equipped Challengers/Chargers for a P2227 (Barometric Pressure Circuit Performance) fault, please call Nick Lynn on his cell (586) 295-0917. If no response is received within 15 minutes, please continue with repair
• 10160021Dec 5, 2015Seat belts. Seat Belt Interaction With Police Equipment
• 10159893Nov 24, 2015Engine cooling. Before replacing this part for debris issue faults, please call the following people;~ Engineering is seeking information regarding this part.~ Bob Smith ? Cell (248) 202-9458 - [email protected]~ If a response is not received within 15 mins, then proceed with the necessary repair.~
• 10159878Nov 4, 2015Equipment, Visibility (wipers, defrost, mirrors). Part Description: Motor, Sunroof Issue Description: If looking to replace the sunroof motor and these conditions are occurring:~ 1) Vent switch does not work.~ 2) Open switch only moves the sunroof an inch no matter how long the switch is held.~ 3) When the close switch is used, sunroof closes but then goes into vent.~ The sunroof motor does not need to be replaced, but only reinitialized. Please follow…
• 10217376Oct 28, 2015Air bags, Vehicle speed control. Part Description: AIR BAG MODULE-PASSENGER I/P Issue Description: Before replacing this part due to Air Bag Light illumination in the Instrument Cluster, please contact Chuck Hood at cell (248) 613-7591. If you don't receive a response within 15 minutes, then continue with normal repair procedure
• 10216138Oct 28, 2015Equipment, Air bags, Electrical system. Part Description: AIR BAG MODULE-PASSENGER I/P Issue Description: Before replacing this part due to Air Bag Light illumination in the Instrument Cluster, please contact Chuck Hood at cell (248) 613-7591. If you don't receive a response within 15 minutes, then continue with normal repair procedure
• 10151719Oct 28, 2015Air bags. Part Description: AIR BAG MODULE-PASSENGER I/P Issue Description: Before replacing this part due to Air Bag Light illumination in the Instrument Cluster, please contact Chuck Hood at cell (248) 613-7591. If you don't receive a response within 15 minutes, then continue with normal repair procedure
• 10217366Oct 14, 2015Electrical system, Brakes. Part Description: Powertrain Control Module Issue Description: Before replacing the Powertrain Control Module on 2015-2016 6.2L Supercharged Hellcat equipped Challengers/Chargers for a P2227 (Barometric Pressure Circuit Performance) fault, please call Nick Lynn on his cell (586) 295-0917. If no response is received within 15 minutes, please continue with repair.
• 10216128Oct 14, 2015Equipment, Transmission and drivetrain, Electrical system. Part Description: Powertrain Control Module Issue Description: Before replacing the Powertrain Control Module on 2015-2016 6.2L Supercharged Hellcat equipped Challengers/Chargers for a P2227 (Barometric Pressure Circuit Performance) fault, please call Nick Lynn on his cell (586) 295-0917. If no response is received within 15 minutes, please continue with repair.
• 10151709Oct 14, 2015Transmission and drivetrain. Part Description: Powertrain Control Module Issue Description: Before replacing the Powertrain Control Module on 2015-2016 6.2L Supercharged Hellcat equipped Challengers/Chargers for a P2227 (Barometric Pressure Circuit Performance) fault, please call Nick Lynn on his cell (586) 295-0917. If no response is received within 15 minutes, please continue with repair.
• 10217398Oct 8, 2015Equipment. Flash: Poor Audio Sound Quality This bulletin involves updating the Amplifier (AMP) software. The customer may describe one or more of the following symptoms/conditions: ? Speakers not loud enough. ? Speakers Buzz/Rattle. ? Poor Sound Quality from Speakers. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs): ? B1474-13-Channel 5 Audio Speaker Output…
• 10216160Oct 8, 2015Equipment, Electrical system. Flash: Poor Audio Sound Quality This bulletin involves updating the Amplifier (AMP) software. The customer may describe one or more of the following symptoms/conditions: ? Speakers not loud enough. ? Speakers Buzz/Rattle. ? Poor Sound Quality from Speakers. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs): ? B1474-13-Channel 5 Audio Speaker Output…
• 10151741Oct 8, 2015Equipment. Flash: Poor Audio Sound Quality This bulletin involves updating the Amplifier (AMP) software. The customer may describe one or more of the following symptoms/conditions: ? Speakers not loud enough. ? Speakers Buzz/Rattle. ? Poor Sound Quality from Speakers. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs): ? B1474-13-Channel 5 Audio Speaker Output…
• 10148662Sep 12, 2015Equipment, Electrical system. Flash: Bass, Mid, Treble Adjustment Causes Erratic Volume Increases This bulletin involves reprogramming the Amplifier (AMP) with the latest available software. The customer may describe when changing the radio tone settings (Bass, Mid, Treble) the volume levels may be erratic. Depending where the volume is set, the volume changes maybe very loud or very little. Example: Volume set to 8 and making adjustments to…
• 10148660Sep 9, 2015Equipment, Electrical system. Flash: Bass, Mid, Treble Adjustment Causes Erratic Volume Increases This bulletin involves reprogramming the Amplifier (AMP) with the latest available software. The customer may describe when changing the radio tone settings (Bass, Mid, Treble) the volume levels may be erratic. Depending where the volume is set, the volume changes maybe very loud or very little. Example: Volume set to 8 and making adjustments to…
• 10148986Aug 22, 2015Equipment. Unable To Register With Uconnect This bulletin involves retrieving MDN and MEID numbers from the radio. Creating a Star case and recording the MDN and MEID with in the Star Case. The Star center will reply back with an access code that will need to be entered into the radio. The customer may notice that their Uconnect Apps do not work and they can?t register with Uconnect.
• 10148981Aug 21, 2015Transmission and drivetrain. Flash: Transmission Shift And Drivability Enhancements This bulletin involves reprogramming of the Transmission Control Module (TCM) with the latest available software. A small number of customers may experience an erroneous Malfunction Indicator Lamp (MIL) Illumination. Upon further investigation, the technician may find a Diagnostic Trouble Code (DTC) stored in the TCM memory. 3.6L Engine (Sales Code ERB) with…
• 10058957Aug 21, 2015Transmission and drivetrain. 2015 dodge charger and 2015 chrysler 300 transmission control module needs reprogramming with the latest software available.
• 10148978Aug 18, 2015Transmission and drivetrain, Equipment. Flash: 6.2L / 6.4L Diagnostic And System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. A small number of customers may experience one or more of the following symptoms and/or a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs). (LA)…
• 10058718Aug 18, 2015Engine. Bulletin on powertrain control module reprogramming with the latest software
• 10148963Aug 11, 2015Engine cooling. Intermittent Coolant Weepage From Upper Radiator Hose Or Radiator This bulletin involves installing an additional clamp on the upper radiator hose along with replacing the radiator assembly. Customers may experience a slight coolant weepage underhood. After further inspection, the technician may notice coolant weeping from the upper radiator hose connection at the radiator or the radiator itself.
• 10148947Aug 10, 2015Equipment. To announce a VIP LOP Restriction Program on the Multi-Displacement Solenoid (MDS) in an effort to monitor and correct quality issues in a timely and efficient manner
• 10148949Aug 4, 2015Equipment. RA3 RA4 Radio Enhancements This bulletin involves inspecting and, if required, updating the radio software. A small number of customers may experience one or more of the following: ? Intermittently blind spot chime will not turn off (KL vehicles only). ? Enable High Definition (HD) feature, (RA4 radios located in Canada and Mexico). ? Low battery condition due to the radio remaining powered up after the ignition…
• 10058295Aug 4, 2015Equipment, Electrical system. Some vehicles need radio software update due to incorrect navigation guidance exiting highway, teleprompter fails to appear when voice recognition (vr) button is pressed, blind spot chime intermittently fails to turn off, previous radio camera image is displayed before current image. Model 2015 charger, ram 4500, 5500, ram 3500, 2500, 1500 pickup, viper, cherokee, challenger, grand cherokee, durango, chrysler 300.
• 10149700Jul 29, 2015Equipment. RG3 RG4 RJ3 RJ4 Radio Enhancements This bulletin involves inspecting and if required, updating the radio software. A small number of customers may experience one or more of the following: ? Blind Spot module beep or chime sound may be heard continuous (KL Only). ? Radio may keep the CAN bus network awake, causing a battery drain. ? Voice Recognition (VR) to set temperature, will indicate wrong setting to rear seat…
• 10149685Jul 18, 2015Seats. Rear Half Shaft Vibration This bulletin involves replacing both rear halfshafts. Customers may experience a slight shake/vibration felt in the seat and/or floor, generated from the rear of the vehicle. Condition is most noticeable on very smooth roads, at steady-state cruising speeds 50-80 mph (80-130 kph). Upon further investigation, the concern may be narrowed down to the rear axle shafts.
• 10058709Jul 16, 2015Electrical system. Ra3 ra4 radio enhancements. Bulletin involves inspecting and updating radio software
• 10149674Jul 13, 2015Electrical system. RA2 Radio Software Enhancements This bulletin involves updating the radio's software. A customer may experience one or more of the following: ? Radio display screen intermittently may go blank. ? Radio display screen may lock up. ? Back up display may not turn off. ? Audio mutes. ? Not able to change state of heated seats and/or steering wheel during stop event on Stop/Start vehicles. ? Touchscreen confirmation…
• 10058565Jul 13, 2015Electrical system, Equipment. Chrysler: some vehicles experience screen lock up on radio display or the screen goes blank, intermittently, text message is grayed out soft keys, back up display turns off. Model 2015 charger, durango, grand cherokee, cherokee, ram 1500, 2500, 3500, 3500 cab, 4500 cab, truck.
• 10149672Jul 9, 2015Equipment. RG2 Or RJ2 Radio Software Enhancements This bulletin involves updating the radio's software. A customer may experience one or more of the following: ? Radio display screen intermittently may go blank. ? Radio display screen may be locked. ? Backup display may not turn off. ? Audio Mutes. ? Not able to change state of heated seats and/or steering wheel during stop event on Stop/Start vehicles. ? Touchscreen…
• 10057668Jul 9, 2015Electrical system. Chrysler 2015 jeep cherokee, ram 1500 pickup- ram 2500,3500,4500. Customers are not able to change temp. Of heated seats , radio not allowing selection of proper language, radio fans continue to run at high speed. *lj updated 10/13/15.
• 10150624Jun 23, 2015Transmission and drivetrain, Engine, Electrical system. Flash: 6.2L / 6.4L Diagnostic And System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. A small number of customers may experience one or more of the following symptoms and/or a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs). Symptoms: ?
• 10220431Jun 10, 2015Wheels. Incorrectly installed front wheel speed sensor wire.
• 10191402Jun 10, 2015Back-over prevention (rear camera), Wheels. Incorrectly installed front wheel speed sensor wire.
• 10058298Jun 5, 2015Exterior lighting. On some vehicles, the low headlamps beams would be yellow or a lot dimmer compared to other vehicles. Model 2015 challenger, charger, chrysler 300. *pe updated 9/30/2015
• 10148944May 30, 2015Transmission and drivetrain. Rear Half Shaft Vibration This bulletin involves replacing both rear halfshafts. A small number of customers may experience a slight noise of vibration from the rear of the vehicle. Upon further investigation, the concern may be narrowed down to the rear axle.
• 10148930May 27, 2015Electrical system. Flash: 5.7L Diagnostic And System Improvements This bulletin involves reprogramming of the Powertrain Control Module (PCM) with the latest software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs). ? P219A - Bank 1 Air-Fuel Ratio Imbalance ? P219B - Bank 2…
• 10229242May 22, 2015Equipment. This bulletin involves modification or replacement of the backlite rear shelf
• 10148925May 22, 2015Equipment. Rattle Or Buzzing Noise In Rear Shelf Area With Radio On Or While Driving On Bumpy Roads This bulletin involves modification or replacement of the backlite rear shelf. The customer may describe a rattle or buzz noise coming from the rear of the vehicle with the radio on or while driving on bumpy roads. This may be caused by the rear shelf moving relative to the backlite.
• 10148909May 8, 2015Exterior lighting. Low Beam Headlamps Dim Or Appear Yellow This bulletin involves verifying the current BCM headlamp voltage set point and performing a vehicle reconfiguration if needed. The customer may describe a condition where the low beam headlamps appear dimmer or yellow when compared to a similarly equipped vehicle.
• 10148903May 6, 2015Engine cooling. Flash: Poor Audio Sound Quality This bulletin involves upgrading the software in the Amplifier (AMP). The customer may experience poor audio sound quality.
• 10148894May 2, 2015Electrical system. Passive Entry Door Unlock Setting Missing This bulletin involves performing a vehicle reconfiguring. The customer may notice that the personal setting ?Passive Entry Unlock? is missing from the menu. This setting allows the customer to select either the approach door (driver or passenger) to unlock by itself or both front doors to unlock together when the outside door handle is touched.
• 10148893May 2, 2015Exterior lighting. Low Beam Headlamps Dim Or Appear Yellow This bulletin involves verifying the current BCM headlamp voltage set point and performing a vehicle reconfiguration if needed. The customer may describe a condition where the low beam headlamps appear dimmer or yellow when compared to a similarly equipped vehicle.

← All problems reported for the 2015 Dodge Charger