2019 Dodge Charger Technical Service Bulletins

335 technical service bulletins (TSBs) are on record for the 2019 Dodge Charger. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10174192Mar 10, 2020Equipment, Visibility (wipers, defrost, mirrors). Customer Satisfaction Notification W10 HVAC Software
• 10175421Mar 4, 2020Equipment. CORE, Heater (with tubes) When replacing the heater core for LA, LX, and LD vehicles, make sure to return not only the heater core but also the connecting tubes, seals and retainers. For any questions contact FCA Redacted Content. If no response in 15 minutes, proceed with repair.
• 10175009Mar 4, 2020Equipment. CORE, Heater (with tubes) When replacing the heater core for LA, LX, and LD vehicles, make sure to return not only the heater core but also the connecting tubes, seals and retainers. For any questions contact FCA Redacted Content. If no response in 15 minutes, proceed with repair.
• 10174089Mar 4, 2020Engine cooling. CORE, Heater (with tubes) When replacing the heater core for LA, LX, and LD vehicles, make sure to return not only the heater core but also the connecting tubes, seals and retainers. For any questions contact FCA Redacted Content. If no response in 15 minutes, proceed with repair.
• 10173328Feb 26, 2020Electrical system, Equipment. Key Programming, Security Pin Request, Pin Invalid
• 10173367Feb 14, 2020Engine cooling. Inspect Throttle Body Assembly This bulletin involves inspecting the Julian date on the throttle body and possibly replacing it. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Code (DTC) has been set:P2100 - Electronic Throttle Control Motor Circuit/Open - Bank 1. The customer may also describe the…
• 10173271Feb 12, 2020Equipment. HEADLAMP After performing the headlamp condensation clearing service procedure, If the WK Headlamp is being replaced for Moisture / Condensation issue, please e-mail pictures of the Moisture / Condensation issue to FCA Redacted Content and then continue with the replacement.
• 10173307Feb 7, 2020Brakes. Pad Contact On Rotor After Brake Service
• 10173306Feb 7, 2020Steering. U11e8-00-lost communication with eps steering torque message
• 10173305Feb 6, 2020Equipment. Apple Carplay Inoperative Or Not Working, Phone Not Pairing, Carplay Lockup Or Freeze.
• 10170409Dec 20, 2019Equipment. UJQ without RS9 Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to 22.5. Customers may experience one or more of the following: Arabic language is missing. Navigation inoperable. Bottom menu bar of the radio is non responsive or frozen. After viewing the weather map following a flood advisory popup, the main soft key's at the bottom of the screen may not…
• 10170373Dec 20, 2019Wheels. Safety Recall VB0 - 2019 LA LD Incompatible Wheels Owners Letters (Dealer Advisement)
• 10170407Dec 19, 2019Electrical system. Right Rear Window Switch Inoperable at Times This bulletin involves replacing the right rear door wiring harness. The customer may describe the following: The right rear window switch intermittently will not power up or down the window.
• 10170384Dec 11, 2019Transmission and drivetrain, Electrical system. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may describe the following:Hearing a pre-detonation noise (Spark Knock) sound in the engine during acceleration. Odor of fuel at times(LD Pursuit Vehicles Only).
• 10170310Dec 11, 2019Transmission and drivetrain. Transfer case seal, Transmission Output Seal If vehicle has a fluid leak between the transfer case and the transmission on an AWD vehicle and it has been determined that the transfer case is leaking from the vent hole, don't replace the input seal.
• 10220101Nov 20, 2019Body and structure. Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
• 10220099Nov 20, 2019Body and structure. Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
• 10220098Nov 20, 2019Visibility (wipers, defrost, mirrors). Authentic Mopar® Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar® Glass.
• 10220097Nov 20, 2019Equipment, Body and structure. Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
• 10169249Nov 20, 2019Equipment, Body and structure. Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
• 10169246Nov 20, 2019Visibility (wipers, defrost, mirrors). Authentic Mopar® Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar® Glass.
• 10220071Nov 1, 2019Engine cooling. wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK
• 10169219Nov 1, 2019Fuel system, Engine. wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK
• 10168496Oct 30, 2019Electrical system, Transmission and drivetrain. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with updated software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination.
• 10168492Oct 29, 2019Electrical system, Transmission and drivetrain. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Code (DTC) has been set: P0456 - EVAP System Small Leak.
• 10168388Oct 17, 2019Fuel system, Transmission and drivetrain. SEAL, Input If looking to replace stubshaft due to ATX fluid leaking, do not replace PTU seals. None of the seals from the PTU side will need to be replaced whenever the ATX stubshaft is replaced, even though V-seal (68408748A$) is in direct contact with the stubshaft, it will not avoid grease/oil leakage from transmission side. PTU V-seals are intended to act as a dust cover for stubshaft - PTU input shaft spline…
• 10168451Oct 11, 2019Transmission and drivetrain. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Code (DTC) has been set:P0456 - EVAP System Small Leak. Customers may also experience the following:Extended engine crank times.
• 10168449Oct 11, 2019Equipment, Electrical system. Flash: HVAC System Enhancement This bulletin involves reprogramming the Heating Ventilation Air Conditioning (HVAC)Module with new software. Customers may experience one of the following:Unpleasant odor in the vehicle after driving from highway speed limits back downto city speed limits. The left temperature door is inoperable(2014-2018 Vehicles Only). Updating the HVAC software will correct these conditions.
• 10166601Aug 29, 2019Electrical system, Back-over prevention (rear camera), Equipment. Radio and Back-up Camera Enhancements This bulletin involves updating the radio software level to 1848.24. Customers may experience one or more of the following: Green horizontal lines on back up display, in reverse (If this is the customer concern use camera LOP 18-60-02-W2, on DT and JL vehicles only). Ghost Touch, features, modes and App?s changing without drivers input. Speaker pop noise when using Bluetooth…
• 10166549Aug 28, 2019Engine cooling, Engine. RETAINER, Crankshaft Rear Oil Seal Oil leak from rear engine seal retainer or windage tray/gasket Check for other sources of leaks using dye such as gallery plugs, camshaft cup plug at rear of engine, rear of engine valley for possible MDS solenoid, VVT solenoid, block porosity or transmission leaks. If another source of the leak was identified, proceed with the appropriate repairs.
• 10166585Aug 16, 2019Electrical system, Back-over prevention (rear camera). Radio and Back-up Camera Enhancements This bulletin involves updating the radio software level to 1848.24. Customers may experience one or more of the following:Green horizontal lines on back up display, in reverse (If this is the customer concern use camera LOP 18-60-02-W2, on DT and JL vehicles only). Ghost Touch, features, modes and App?s changing without drivers input. Speaker pop noise when using Bluetooth…
• 10166537Aug 7, 2019Equipment. RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Please verify that the radio part number and/or serial number is not "FFFF". If either field shows "FFFF", please contact Mike Wielgat at 248-576-6696 or Rohan Negandhi at 248-421-9608 If no response in 15 minutes, proceed with repair.
• 10166535Aug 7, 2019Engine. SEAL, Crankshaft Oil, Front Front crankshaft oil seal leak: For concern of front crankshaft seal leak please send an email to [email protected] with VIN, Mileage, Photos and indicate where the leak is identified using dye such as: 1. Leak between the outer diameter of the seal to front cover? 2. Leak between the seal and damper 3. Leak through the damper bolt This will help in determining root cause and…
• 10162565May 21, 2019Equipment. UJQ with RS9 Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to 21.9. Customers may experience one or more of the following:Arabic language is not listed in language page. Radio may reset, turn itself off and then back on again. Radio display screen lock up. Park assist chime will continue to chime after the vehicle is turned off. Russian language is not…
• 10162471May 15, 2019Equipment. ACTUATOR, A/C and Heater Before replacing HVAC actuator, please contact either Thomas Conway (248) 635-7090 or Paul Aquino (248) 854-4819. Engineering is looking to gather infomation on fail mode and customer concern. If no response in 15 minutes, proceed with repair.

← All problems reported for the 2019 Dodge Charger