2012 Dodge Dart Technical Service Bulletins

152 technical service bulletins (TSBs) are on record for the 2012 Dodge Dart. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10166537Aug 7, 2019Equipment. RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Please verify that the radio part number and/or serial number is not "FFFF". If either field shows "FFFF", please contact Mike Wielgat at 248-576-6696 or Rohan Negandhi at 248-421-9608 If no response in 15 minutes, proceed with repair.
• 10140043Mar 23, 2017Electrical system, Steering, Exterior lighting, Back-over prevention (rear…. Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following DTCs set in the PCM memory: U1504 - Implausible Message Data Length Received From…
• 10139989Mar 15, 2017Engine cooling. Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 [email protected], or Joe Lovell (734) 309-6467 [email protected] before proceeding. If unable to reach after 15 minutes record the following information and proceed with oil pump…
• 10139978Mar 8, 2017Seat belts. Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
• 10139985Mar 1, 2017Seat belts. Restraints Information Sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
• 10121741Aug 27, 2016Brakes. (X62) Hydraulic Clutch Master Cylinder / Reservoir Hose - 2013-2015 Dodge Dart and 2014-2015 Jeep Cherokee (Rev. A) To announce an extended warranty on the Hydraulic Clutch Master Cylinder/ Reservoir Hose on the following vehicles: ? 2013-2015 Dodge Dart (PF) ? 2014-2015 Jeep Cherokee (KL)
• 10121714Aug 27, 2016Transmission and drivetrain, Equipment. Clutch Pedal Operation X62 Extended Warranty This bulletin involves the replacement of the hydraulic clutch master cylinder and reservoir hose. Some customers may experience a reduction in clutch pedal stroke.
• 10130085Aug 24, 2016Seat belts. Occupant Restraint Controller (ORC) For PF, KL or UF Vehicles ONLY:~ Prior to replacing ORC part numbers, please contact FCA engineering if ANY of the following Diagnostic trouble codes are Stored or Active in the ORC module:~ DTC: B223D-00 - OCM DTC Present~ DTC: B0050-13 - Driver Seatbelt Sensor-Circuit Open~ DTC: B0052-13 - Passenger Seatbelt Sensor-Circuit Open~ DTC: B00B5-13 - Driver Seat Track Position…
• 10140192Aug 11, 2016Exterior lighting, Engine cooling, Electrical system, Brakes, Back-over…. Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination or one or more of the following conditions. Upon further investigation the technician may find the following Diagnostic Trouble Codes (DTCs) set in the PCM…
• 10140130Jun 21, 2016Engine cooling, Electrical system. Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination or one or more of the following conditions. Upon further investigation the technician may find the following Diagnostic Trouble Codes (DTCs) set in the PCM…
• 10074916Jun 21, 2016Electrical system, Transmission and drivetrain. Flash: 2.4l powertrain diagnostic and system improvements. Bulletin involves reprogramming the powertrain control module (pcm) with the latest available software. A small number of customers may experience a malfunction indicator lamp (mil) illumination or one or more of the following conditions. Upon further investigation the technician may find the following diagnostic trouble codes (dtcs) set in the pcm…
• 10139941Jun 2, 2016Transmission and drivetrain. Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination or one or more of the following conditions. Upon further investigation the technician may find the following Diagnostic Trouble Codes (DTCs) set in the PCM…
• 10141274May 18, 2016Engine cooling, Electrical system. Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination or one or more of the following conditions.
• 10140254May 4, 2016Equipment, Electrical system. RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). The Telematics Module (and associated components) is the system responsible for these features.
• 10139956Apr 20, 2016Vehicle speed control. Adaptive Cruise Control Sensor 1) If you are replacing this part due to the cluster displaying Clean Radar Sensor in Front of Vehicle or DTC C1266 ACC Sensor Blinded, please verify that there is no blockage in front of the sensor. Blockage can occur from mud, ice, snow, front end damage, bracket damage, the sensor not attached to the bracket properly or an aftermarket fascia installed. This fault can occur…
• 10074256Mar 15, 2016Electrical system. Summary to be provided on a future date.
• 10074226Mar 15, 2016Electrical system. Summary to be provided on a future date.
• 10141309Feb 26, 2016Electrical system, Transmission and drivetrain. MODULE, Transmission Control This generic TCM must be flashed with the ignition in the accessory position. Attempts to flash with the ignition in the run position may result in flash failures
• 10121927Jan 26, 2016Engine cooling. NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA).~
• 10121901Jan 8, 2016Transmission and drivetrain. Clutch Pedal Operation X62 Extended Warranty This bulletin involves the replacement of the hydraulic clutch master cylinder and reservoir hose. Some customers may experience a reduction in clutch pedal stroke.
• 10076429Jan 8, 2016Brakes. Hydraulic clutch master cylinder/reservoir hose (x62)-2013-2015 dodge dart and 2014-2015 jeep cherokee.
• 10074212Jan 8, 2016Transmission and drivetrain. Summary to be provided on a future date.
• 10160073Dec 22, 2015Electrical system, Transmission and drivetrain. Flash: Body Control Module (BCM) Diagnostic And System Improvements This bulletin involves updating the BCM software. Some customers may experience any of the following conditions: ? Engine starts then immediately stalls when using Remote Start system (Instrument Cluster may display the message ?Remote Start Disabled, Start Vehicle to Reset?). ? Engine cranks and does not start following the condition described…
• 10160068Dec 22, 2015Transmission and drivetrain, Electrical system. Flash: Transmission Shift And Drivability Enhancements This bulletin involves reprogramming of the Transmission Control Module (TCM) with the latest available software. Customers may experience any of the following symptoms: ? Transmission shift improvements when using cruise control. ? Improved garage shift feel and quality. NOTE: The Body Control Module (BCM) and Powertrain Control Module (PCM) must be up to date…
• 10160066Dec 22, 2015Transmission and drivetrain, Electrical system, Engine cooling. Flash: 2.0L Powertrain Diagnostic And System Enhancements This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. Some customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs) has been set in the PCM memory: ? P0456 - Evap System…
• 10074645Dec 22, 2015Electrical system. Summary to be provided on a future date.
• 10160052Dec 18, 2015Transmission and drivetrain, Engine cooling, Electrical system. Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination or one or more of the following conditions. Upon further investigation the technician may find the following Diagnostic Trouble Codes (DTCs) set in the PCM…
• 10074394Dec 18, 2015Electrical system. Summary to be provided on a future date.
• 10159990Dec 9, 2015Wheels, Equipment. Part Description: Nut - Front Hub & Bearing Issue Description: Whenever replacing the front Hub & Bearing Halfshaft Nut, make sure to torque to proper spec of 150 ft/lbs (200 Nm) and crimp according to procedure in TechConnect. (This torrque is higher than other platforms). Failure to do so will result in eventual Hub & Bearing failure (noise).~
• 10074730Oct 26, 2015Electrical system, Transmission and drivetrain. Summary to be provided on a future date.
• 10151774Oct 24, 2015Engine, Engine cooling. Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination or one or more of the following conditions. Upon further investigation the technician may find the following Diagnostic Trouble Codes (DTCs) set in the PCM…
• 10151773Oct 24, 2015Engine, Transmission and drivetrain. Flash: Driveability Enhancements This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the Technician may find that the following Diagnostic Trouble Codes (DTCs) have been set: ? P1128 - Closed Loop Fueling Not Achieved - Bank 1 Upstream…
• 10074729Oct 24, 2015Transmission and drivetrain. Summary to be provided on a future date.
• 10151757Oct 15, 2015Equipment, Electrical system. Hands Free Feature Inoperative This bulletin involves updating the Convergence Telematics Module (CTM) software. NOTE: Convergence Telematics Module (CTM) was also known as the Hands Free Module (HFM). The customer may notice that the hands free feature (Bluetooth) does not work. On further inspection one or more of the following DTCs may be found: ? U11F6-00 Lost Communication With Convergence Telematics Module. ?…
• 10151728Oct 3, 2015Brakes. Front Brake Squeak/Squeal Noise This bulletin involves replacing the front brake rotors, front brake pads, and related hardware. The customer may describe a front brake squeak/squeal high frequency noise in the 6-7 kHz range while stopping, noise may be intermittent (not every stop).
• 10148994Aug 27, 2015Transmission and drivetrain. Flash: Driveability Enhancements This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the Technician may find that the following Diagnostic Trouble Codes have been set: ? P1128 - Closed Loop Fueling Not Achieved - Bank 1 Upstream. ?…
• 10058924Aug 27, 2015Engine, Equipment. 2012-2013 dodge dart customers may notice a malfunction indicator lamp illumination. Also the engine may crank as if it has no compression, engine knocking sounds at idle and when using low octane fuel spark knock is present.
• 10148976Aug 18, 2015Equipment. RE2 RE6 RB5 RB6 Radio Software Enhancements This bulletin involves updating the radio software and navigation if equipped. A customer may experience one or more of the following conditions: ? Radio display screen will lock up and reset intermittently (2013-2014 MY Vehicles). ? Navigation screen goes blank (Software has been updated to better address this condition). ? Navigation system freezes/locks up (Software…
• 10148971Aug 15, 2015Equipment, Transmission and drivetrain. Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination or one or more of the following conditions.
• 10058714Aug 15, 2015Equipment. Customers may experience a malfunction indicator lamp illumination. Power control module requires reprogramming with latest software available *cn updated 12/21/15
• 10149699Jul 25, 2015Transmission and drivetrain. Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. In addition, some customers may describe engine flare at startup or idle surge.
• 10149682Jul 17, 2015Transmission and drivetrain, Electrical system. Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Codes (DTCs) set in the PCM memory: 2015 UF Vehicles with (sales codes ED6…
• 10149660Jul 13, 2015Electrical system. Fast Feedback Program - Hands Free Module - 2013-2015 Dodge Dart (PF) Rev. A
• 10150542Apr 18, 2015Tires. Tire Pressure Monitoring System May Display Wrong Tire Location The Body Control Module (BCM) must be reconfigured to a Premium Tire Pressure Monitor System (TPMS). The customer may notice a message ?Low Tire? displayed on the cluster: ? Tire Pressure Monitoring screen on the instrument cluster may indicate the incorrect tire location shown when low tire pressure is detected. ?
• 10057931Apr 18, 2015Tires. Chrysler 2013-2014 dodge dart aero: service bulletin information regarding the tire pressure monitoring system displaying wrong tire location. Customers may notice a "low tire" message on the cluster.
• 10150477Apr 14, 2015Electrical system. Fast Feedback Program - Hands Free Module - 2013-2015 Dodge Dart (PF)
• 10144832Mar 10, 2015Electrical system, Transmission and drivetrain. Flash: MIL Illumination P1D73, P1CEA And/Or P0456 Includes Various Driveability Enhancements This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the Technician may find that the following Diagnostic Trouble Codes have been set: ?…
• 10144900Feb 27, 2015Steering, Suspension, Equipment. Cold Temperature Squeak/Creak Noise While Turning The Steering Wheel This bulletin involves applying Nye® lubricant to the front strut mounts. Customer may describe a creak or squeak noise while turning the steering wheel. Noise is typically more noticeable during cold temperatures below 4°C (40°F), noise may go away when temperature warms up.
• 10144899Feb 26, 2015Transmission and drivetrain, Electrical system, Equipment. Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Codes (DTCs) set in the PCM memory: 2015 UF Vehicles, built on or before…
• 10148568Jan 28, 2015Electrical system. Part Description: IP Center Bezel Issue Description: Please call Mike Wicker at cell (248) 821-9350 before ordering a replacement due to damage OR not fully illuminated IP center bezel. Thank you.

← All problems reported for the 2012 Dodge Dart