2007 GMC Sierra 1500 Technical Service Bulletins

722 technical service bulletins (TSBs) are on record for the 2007 GMC Sierra 1500. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10021415Jun 1, 2008Electrical system. Fuel gauge erratic in freezing temperatures p0463. *kb with one of the following engine rpo's: ly2, ly5, ly6. Lh6, l76, l92. Updated 1/30/08. *nj updated 12/5/08.
• 10024527May 1, 2008Exterior lighting. Turn signals flash fast after factory box removed. *nj updated 8/25/08.
• 10021013May 1, 2008Suspension. Suspension vibration or frame beaming at 40 - 60 mph. *kb updated 8/25/08.
• 10020722May 1, 2008Air bags. Passenger side airbag door does not flush with dash pad/warped. (reposition locking tabs on airbag panel). *kb updated 10/5/07. *nj updated 9/12/08.
• 10024712Apr 1, 2008Engine cooling. Duramax diesel dpf regeneration changes - vehicles equipped with the 6.6 duramax diesel engine rpo code lmm.
• 10023740Apr 1, 2008Engine cooling. Ses light on due to dtc p0101 and/or p0106 - inspect air filter and/or map sensor . With 6.6l diesel engine (rpo, lbz, lly, or lmm). *nj updated 5/13/08.
• 10024793Mar 1, 2008Electrical system. Left or right power outside mirror inoperative (inspect wire harness).
• 10024785Mar 1, 2008Brakes. Diagnostic information on mil/ses with dtc p0171 (fuel trim system lean bank 1) and/or p0174 (fuel trim system lean bank 2) after brake master cylinder replacement.
• 10024632Mar 1, 2008Brakes. Unwanted abs or valve activation on low speed turns.
• 10024601Mar 1, 2008Transmission and drivetrain. Dtc u0101, no engine crank and no tech ii communication with tcm. Equipped with allison lct1000 (rpo-mw7) automatic transmission.
• 10024345Feb 1, 2008Suspension, Transmission and drivetrain. Eaton locking differential chatter shudder noise on turns, equipped with a locking rear differential rpo g80. *nj updated 7/17/2008.
• 10024344Feb 1, 2008Engine cooling. Possible engine oil leak due to pcv freeze-up, equipped with the 4.8, 5.3, 6.0, and 6.2 v-8 engines.
• 10024342Feb 1, 2008Tires. Low tire light on and/or dic check tire pressure message when cold, with rpo uj6.
• 10024341Feb 1, 2008Fuel system. Duramax diesels with dtc p009e, vehicles equipped with the 6.6 duramax diesel engine rpo code lmn. *nj updated 4/7/08.
• 10024285Feb 1, 2008Engine cooling. Oil leak at rear of engine. Equipped with a 4.8, 5.3, 6.0 or 6.2 v8 engine.
• 10024282Feb 1, 2008Engine cooling. Engine stalls after being remote started.
• 10024281Feb 1, 2008Tires. Check low tire / aftermarket wheels / tire pressure monitor / fmvss 138 with (rpo uj6).
• 10024204Feb 1, 2008Engine cooling. Short duration cold start lifter tick noise. Equipped with the 5.3 or 6.0 active fuel management engines.
• 10023434Feb 1, 2008Brakes. Unwanted abs or valve activation on low speed turns. With stabilitrac (rpo jl4). *nj updated 4/1/08.
• 10022916Feb 1, 2008Transmission and drivetrain. Diagnosis for service fast learn adapts fails, no forward or no reverse. *nj updated 4/1/08.
• 10024406Jan 1, 2008Electrical system. Instrument panel (ip) gauges/gages difficult to read or see, poor backlighting (replace ip and program).
• 10017464Jan 1, 2008Transmission and drivetrain. Service 4wd light illuminated, diagnostic trouble code (dtc) c0374 set. *tt updated 10/05/07. *nj inspect wiring harness to transfer case speed sensors, replace wiring harness. Updated 7/18/08
• 10023474Dec 13, 2007Latches, locks and linkages. Outside door handle loose, inoperative or does not retract.
• 10020881Dec 13, 2007Air bags. Air bag indicator light is on. *kb updated on 12/13/07.
• 10023994Dec 1, 2007Brakes. Service stabilitrak message c0196 and/or u2142.
• 10023760Dec 1, 2007Transmission and drivetrain. U0106 loss of communication with glow plug control module. Equipped with the 6.6l duramax diesel engine rpo code lmm.
• 10023755Dec 1, 2007Electrical system. Sir light on, dtc's b0085, b0086, b0087 and b0088.
• 10023744Dec 1, 2007Transmission and drivetrain. 4 wheel drive inoperative front axle will not engage - keywords clunk grind growl k2 k3 equipped with a 9.25 front differential. *nj updated 2/27/08.
• 10023722Dec 1, 2007Electrical system. No start/no crank - loss of high speed gmlan communication.
• 10023721Dec 1, 2007Engine cooling. High idle, elevated idle, and pto all different options.
• 10022901Dec 1, 2007Engine cooling. Engine has low power on acceleration or when towing. Equipped with the 6.0l ly6 and l76 engine. *nj updated 1/29/08.
• 10022592Dec 1, 2007Engine cooling. Duramax diesels with ses light and dtc p0402. *kb updated 2/27/08.
• 10021081Dec 1, 2007Tires. Tire sidewall irregularities. *kb updated 1/30/08.
• 10020031Dec 1, 2007Electrical system. Crank no start, rough running, or dtc p0335. *tt equipped with 5.3l, 6.0l, 6.2l engines. Updated 1/30/08.
• 10023400Nov 1, 2007Steering. Steering wheel off center while driving straight, clunk noise while turning, early front tire wear (perform torque to tighten analysis and repair as necessary) *nj updated 2/25/08.
• 10022262Nov 1, 2007Tires. Tire pressure monitor system concerns. *kb 2008 passenger cars and trucks (including saturn). Updated 2/26/08.
• 10022914Oct 4, 2007Electrical system. One of the following concerns when programming the mileage or the hours into an exchange instrument panel cluster that is received from an electronic service center (esc).
• 10022913Oct 4, 2007Tires. Unable to lower spare tire from underneath the vehicle.
• 10023936Oct 1, 2007Transmission and drivetrain. Whine type noise coming from rear of vehicle (diagnose and replace rear propeller shaft).
• 10023215Oct 1, 2007Fuel system. Ei07239 - 5.3l, lmg, lc9 driveability symptoms, hesitation, miss, lack of power, dtc p0300, p0301, p0302, p0303, p0304, p0305, p0306, p0307, p0308, p0171, p0172, p0174, p1174, p1175, check engine light, mil, injector. *nj updated 2/19/08.
• 10023212Oct 1, 2007Equipment. Ei07264 - manual hvac performance, temperature, mode, a/c does not cool, dtc b0228, b0413, b0423, b0433, b3779, b3782 *nj updated 2/15/08.
• 10021847Oct 1, 2007Other or unknown. Procedure for installation of an aftermarket trailer brake controller in lieu of factory installed integrated trailer brake controller. *kb updated 11/02/07. *nj updated 2/19/08.
• 10022796Sep 27, 2007Engine cooling. Perceived hesitation or lack of power during throttle reapply at slow speeds.
• 10022794Sep 27, 2007Transmission and drivetrain. 2-3 upshift slip or flare.
• 10022769Sep 26, 2007Transmission and drivetrain. Transmission slips, will not shift, ses light may be illuminated.
• 10022768Sep 26, 2007Electrical system. Auxiliary power to 7-way trailer connector.
• 10022766Sep 26, 2007Electrical system. Blown mbec 1 or lbec 1 fuse.
• 10022697Sep 20, 2007Steering. Engineering information request during rear ring and pinion replacement.
• 10023221Sep 1, 2007Electrical system. Various electrical concerns - intermittently functioning or inoperative component, ip warning light on, dic message displayed, dtc set, no crank/start (repair ip wiring harness)
• 10023217Sep 1, 2007Exterior lighting. Turn signal in camper style outside rearview mirror (rpo dpn) does not illuminate turn signal flash (replace upper mirror glass)

← All problems reported for the 2007 GMC Sierra 1500