2008 GMC Sierra 1500 Technical Service Bulletins

644 technical service bulletins (TSBs) are on record for the 2008 GMC Sierra 1500. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10139436Jan 23, 2015Equipment. This informational bulletin adds 2014 - 2015 model years to information regarding comeback prevention and using Customer Concern Verification Sheets (CCVS).
• 10139433Jan 23, 2015Electrical system. This informational bulletin provides information on control module diagnostics and configuration, programming using the TIS Service Programming System (SPS), set-up and warranty.
• 10095345Jan 23, 2015Equipment, Electrical system. This preliminary information communication advises the technician that the drive motor generator control module and accessory power module are being placed on restriction through the general motors technical assistance center. Dealer will need to contact general motors technical assistance center for further assistance.
• 10139430Jan 22, 2015Wheels. This informational bulletin provides information on chemical staining, pitting, corrosion and/or spotted appearance of chromed aluminum wheels, along with warranty information regarding these conditions.
• 10139428Jan 22, 2015Equipment. This technical bulletin provides a procedure to correct a customer concern of reduced heater performance with winter grille cover installed.
• 10094982Jan 21, 2015Equipment, Engine, Transmission and drivetrain. This preliminary information communication provides information to the technician that some vehicles may have a service engine soon lamp, engine misfire on cylinder 1, 4, 6, or 7 and/or tick noise. Technician will follow service information diagnosis first. If service information diagnosis does not isolate the cause of this concern perform a cylinder deactivation active fuel management system compression test in…
• 10139422Jan 16, 2015Engine cooling. This preliminary informational bulletin provides technicians an engine repair tip for installation of pistons.
• 10139421Jan 16, 2015Electrical system. This informational bulletin adds models to information on voltmeter gauge fluctuation due to regulated voltage control system and concerns about camper/trailer battery charging.
• 10139418Jan 15, 2015Engine cooling. This preliminary informational bulletin provides a diagnostic tip for coolant leak at oil cooler inlet pipe o-ring after service engine replacement.
• 10139415Jan 14, 2015Electrical system. This warranty administration bulletin provides policy information on ACDelco® replacement battery warranty procedures.
• 10139414Jan 14, 2015Equipment. This warranty administration bulletin adds 2012 - 2015 model years to information communicating a change in the product field action customer reimbursement procedure (U.S. Dealers Only).
• 10094888Jan 14, 2015Equipment, Electrical system. This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. Technician will need to determine what type of call the customer is having that is unwanted. The vehicle may receive an incoming call just like any other phone. Typically the customer will hear the phone ringing in the vehicle. This…
• 10139412Jan 12, 2015Engine cooling. This informational bulletin supplies infomation for identifying non-GM (Aftermarket) engine calibrations for gasoline engines using Tech 2® or GDS 2 (U.S. and Canada).
• 10139411Jan 12, 2015Equipment. This preliminary informational bulletin provides information that accessory remote start does not work with OnStar RemoteLink? phone application.
• 10139409Jan 12, 2015Electrical system. This informational bulletin adds 2011 - 2014 model years to information on voltmeter gauge fluctuation due to regulated voltage control system and concerns about camper/trailer battery charging.
• 10139199Jan 6, 2015Suspension. This informational bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure, when diagnosing vibration concerns.
• 10079302Jan 5, 2015Transmission and drivetrain. 14308 - special coverage. Heavy duty diesel powered vehicles equipped with a 6 speed automatic transmission, may have a condition in which increased transmission oil cooling circuit pressure may cause transmission fluid to weep or leak. This loss of fluid occurs near the transmission cooler at the crimp joints on the metal ends of the cooler line where it joins the rubber hose. The increased oil cooling circuit…
• 10126251Dec 19, 2014Transmission and drivetrain. This informational bulletin was created for the Manual Transmission Operating Characteristics. The different noises caused by driver habit, weather conditions , and normal manual transmission noises.
• 10126248Dec 18, 2014Wheels. This preliminary information bulletin provides information on how to remove stainless steel wheel nut caps with the matching depth of socket used on the wheel nut.
• 10126231Dec 10, 2014Equipment. This information provides the proper way to install the floor mats .
• 10126221Dec 8, 2014Electrical system. This warranty informational bulletin advised the technician that when performing a wiring repair, more information is required.
• 10247716Dec 1, 2014Equipment, Electrical system. J-35616-64B Terminal Test Probe / Replacement Terminal / Terminated Lead.
• 10247214Dec 1, 2014Electrical system. Chassis Electronic Control Module Internal Contamination
• 10247061Dec 1, 2014Electrical system. J-35616-64B Terminal Test Probe / Replacement Terminal / Terminated Lead.
• 10081065Nov 12, 2014Equipment. 09184b - customer satisfaction (revised vehicle population, condition statement and service procedure). Certain vehicles currently or previously registered in alaska, connecticut, delaware, district of columbia, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, and wisconsin may have…
• 10252163Nov 1, 2014Equipment. XM Audio Traffic And Travel Link Availability And Operation.
• 10250089Nov 1, 2014Electrical system. Material Over Sensing and Diagnostic Module Retaining Moisture
• 10247748Nov 1, 2014Electrical system. Speedometer Needle Accuracy Information.
• 10247711Nov 1, 2014Electrical system, Other or unknown. Intermittent Battery Draw Dead Battery Or HVAC Odor.
• 10247093Nov 1, 2014Electrical system. Speedometer Needle Accuracy Information.
• 10247063Nov 1, 2014Visibility (wipers, defrost, mirrors). A/C Blows Warm Or Poor Performance.
• 10247056Nov 1, 2014Electrical system, Visibility (wipers, defrost, mirrors). Intermittent Battery Draw Dead Battery Or HVAC Odor.
• 10246576Nov 1, 2014Electrical system. Material Over Sensing and Diagnostic Module Retaining Moisture
• 10245951Nov 1, 2014Equipment. Canadian Customers Unable To Place Calls And Turn By Turn Inoperative In The United States.
• 10066126Nov 1, 2014Electrical system. Summary to be provided on a future date.
• 10142238Sep 30, 2014Suspension. This technical bulletin provides a procedure to add a lubricant to the rear leaf springs to correct the customers concern of a squeaking noise from the rear suspension.
• 10112251Sep 24, 2014Engine cooling. This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is missing needle bearings. Be sure to clean the oil drains to retrieve the needle bearings. Each roller rocker has 66 bearings.
• 10142220Sep 19, 2014Fuel system. This informational bulletin provides information on top tier fuels and what brands are available.
• 10142219Sep 18, 2014Electrical system, Body and structure. This informational bulletin provides information for an available BCM calibrations that would restore bulb outages when using a second stage manufacturer
• 10095922Sep 16, 2014Engine. This technical bulletin provides a procedure to correct the customers concern to replace the left side valve cover and active fuel management oil deflector to reduce oil consumption.
• 10094823Sep 10, 2014Equipment. This preliminary bulletin provides a information on how to remove the seized temperature sensors from the dpf.
• 10248493Sep 1, 2014Equipment. Bluetooth Stays Connected After RAP Is Canceled.
• 10248492Sep 1, 2014Equipment. Bluetooth Stays Connected After RAP Is Canceled.
• 10138703Aug 28, 2014Engine cooling, Equipment. This informational bulletin advises of a new testing tool for EGR cooling pressure tester.
• 10112160Aug 8, 2014Equipment. This Preliminary Information communication provides information to the technician about installing General Motors Accessory pats. Technician can check Service Information for some accessories. Technician can also contact Partect for assistance. Technician can also contact Techline Customer Support Center for programming issues.
• 10052379Aug 1, 2014Steering. Buick/cadillac/chevrolet/gmc: during extreme low temperature conditions, the power steering makes noises or fluid leaks from high pressure hose, power steering pump or gear. *pe updated 9/30/13. *pe updated 11/7/14.
• 10112144Jul 31, 2014Equipment. This Preliminary Information communication provides information to the technician about vehicle that has no XM audio on certain channels but XM channel info is displayed. Technician will need to contact XM and deactivate and activate the module.
• 10112142Jul 30, 2014Equipment. This Preliminary Information communication provides information to the technician about vehicles that have a message on the radio "maximum number of phones are currently paired to the vehicle". Dealer should advise the customer this is normal operation of the vehicle due to the maximum number of five phones can be paired to a vehicle.
• 10112137Jul 30, 2014Equipment. This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Technical Assistance Center with the scan tool data from the OnStar system.
• 10112116Jul 17, 2014Engine cooling. This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blow by. Technician will need to inspect the engine for Cylinder damage or scoring, An out of round cylinder bore, Dirt intrusion, and Catalytic Converter failure.

← All problems reported for the 2008 GMC Sierra 1500