2022 GMC Sierra 1500 Technical Service Bulletins

1,606 technical service bulletins (TSBs) are on record for the 2022 GMC Sierra 1500. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10232842Feb 28, 2023Transmission and drivetrain, Brakes. This Preliminary information communicates an issue when remote start is used the engine may stall when the push to start button is pressed. On certain models, dealerships are to reprogram the BCM to correct the issue. The remaining models engineering is working on a fix.
• 10232474Feb 28, 2023Electrical system, Engine cooling, Equipment. This technical bulletin provides repair information to correct a customer concern of After a Remote Start When the Start Button Is Pressed the Engine May Stall or Will Not Restart.
• 10232840Feb 27, 2023Visibility (wipers, defrost, mirrors), Back-over prevention (rear camera). This Preliminary information communicates information on how to disable the Side Blind Zone Detection and Park Assist systems when a customer removes the pickup box from the vehicle to install an aftermarket bed or body.
• 10232838Feb 27, 2023Visibility (wipers, defrost, mirrors). This Preliminary information provides information to the technician on installing a roof beacon light. Technician will need to reference the latest version of General Motors Up-fitter Integration Bulletin 157. The information can be found at http://www.gmupfitter.com/ under the "Technical Bulletin" Tab and then "Show all bulletins."
• 10232837Feb 27, 2023Body and structure, Back-over prevention (rear camera). This Preliminary information communicates an issue with a wind noise while driving at highway speeds and dealers are to inspect the body harness pass through for being full seated into the cowl.
• 10232469Feb 27, 2023Equipment. This Warranty Administration bulletin provides policy information on Causal Part requirements for transactions submitted to GM for payment.
• 10232835Feb 24, 2023Forward collision avoidance. This Preliminary information communicates a "Forward Collision System Reduced" message displayed on the DIC when the Forward Automatic Braking has been set to the "Alert" setting. This is normal when the FAB has been set to "Alert".
• 10232468Feb 24, 2023Engine cooling. This engineering information (EI) is requesting information from technicians to perform the check list provided and contact the engineer listed in regards to the Check Engine Lamp Illuminated on the Driver Information Center (DIC).
• 10232830Feb 23, 2023Back-over prevention (rear camera). This Preliminary information communicates an issue with the front view camera setting a DTC U3000 and disabling. Engineering is working on a fix.
• 10232829Feb 22, 2023Electrical system. This Preliminary information communicates vehicles being built without certain options due to a parts shortage.
• 10232459Feb 22, 2023Engine cooling, Electrical system. This technical bulletin provides a procedure to program the Reductant Control Module and Setup and Perform the Reductant Fluid Tank Level Reset.
• 10232458Feb 22, 2023Back-over prevention (rear camera), Equipment. This service bulletin provides repair information on release of Radio Software Version V160 Update to correct customer concerns of radio software issues.
• 10232287Feb 21, 2023Equipment. This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
• 10232037Feb 21, 2023Steering. Due to the industry-wide semiconductor shortage, the heat feature on the steering wheel is not functional on certain 2022-2023 model year vehicles listed above, built beginning January 6, 2022. The affected vehicle owners should have been made aware of the condition at sale, and notified that once parts are available, they would be eligible for a no additional cost retrofit to enable the feature. Dealers are to…
• 10232288Feb 20, 2023Equipment. This warranty administration bulletin provides policy information, proper labor operation selection and causal part identification for warranty transactions (U.S. Only).
• 10232283Feb 17, 2023Body and structure, Visibility (wipers, defrost, mirrors), Other or unknown. This PI provides information on Rear and Side Tempered Glass Spots (Quench Marks) and that they are a normal characteristic.
• 10232273Feb 17, 2023Electrical system, Engine cooling. This technical bulletin provides repair information to correct a customer concern of Engine Control Module Software Anomalies with MIL Illuminated and DTC P060C Set.
• 10232143Feb 17, 2023Equipment. This warranty administration bulletin provides policy information for variable diagnostic time allowances on select labor operations (U.S. Only).
• 10232822Feb 16, 2023Back-over prevention (rear camera). This Preliminary information communicates a diagnostic tip for a thump, click, pop, clunk type noise that is heard from the front end. Dealers are to inspect for something contacting the grill shutters as they open and close.
• 10232821Feb 16, 2023Equipment. This Preliminary information communicates a diagnostic tip on how to resolve a issue if the serial data authentication configuration did not complete correctly.
• 10232819Feb 16, 2023Air bags, Electronic stability control. This Preliminary Information communication provides information to the technician about vehicles that have an unwanted Stability Activation and/or a Service Stability message on the Driver Information Center. Technician may find a Diagnostic Trouble Code C0710. Technician should inspect for vehicles modifications before any in-depth diagnostics are performed.
• 10232286Feb 16, 2023Equipment, Engine cooling. This engineering information (EI) closure ends the need for information from technicians in regards to the check engine lamp illuminated on driver information center (DIC).
• 10232275Feb 16, 2023Transmission and drivetrain. This service bulletin provides information on Driveline Clunk Noise and what is acceptable and what is considered normal operation.
• 10232155Feb 16, 2023Fuel system. This technical bulletin provides a procedure to replace the fuel feed line if found the cause of the failure which set the DTC.
• 10232818Feb 15, 2023Brakes, Transmission and drivetrain. This Preliminary information communicates an issue when remote start is used the engine may stall when the push to start button is pressed. On certain models, dealerships are to reprogram the BCM to correct the issue. The remaining models engineering is working on a fix.
• 10232817Feb 15, 2023Electrical system. This Preliminary information communicates a diagnostic tip for an issue where the starter stays engaged after the engine starts. Dealers are to suspect/monitor the crankshaft position sensor.
• 10232136Feb 15, 2023Exterior lighting. This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.
• 10231836Feb 15, 2023Body and structure. Customer Satisfaction Program. Added population.
• 10232813Feb 14, 2023Other or unknown. This Preliminary information communicates that when they connect a trailer to the truck that there is a Service Trailer Brake message displayed in the DIC. When checking for DTC's a C159C sym49 maybe set for the Trailer Brake Control Switch. GM Engineering released an updated trailer brake switch, See Customer Satisfaction Program N222384930.
• 10232137Feb 14, 2023Exterior lighting. This service bulletin provides technicians with information on available BCM calibrations to restore bulb outage detection on vehicles produced by a second stage manufacturer (Upfitter), and/or turn signals flash fast after factory box removed.
• 10231817Feb 13, 2023Electrical system. Customer Satisfaction Program - certain vehicles may have a “Service Trailer Brake” message set when a trailer with electric brakes is connected and the driver attempts to use the manual apply slider on switch or depress the brake pedal while towing. Dealers are to replace the Trailer Brake Control Switch.
• 10232811Feb 10, 2023Equipment. This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
• 10232810Feb 10, 2023Transmission and drivetrain, Brakes. This Preliminary information communicates an issue when remote start is used the engine may stall when the push to start button is pressed. Engineering is working on a fix.
• 10232809Feb 10, 2023Transmission and drivetrain. This Preliminary information communicates to the dealer a diagnostic and repair direction to a possible engine crankshaft bearing failure.
• 10232074Feb 10, 2023Electrical system, Engine cooling. This informational bulletin provides Changes to the Automatic Stop/Start feature for Certain 2021 Escalade models, Silverado 1500, Suburban, Tahoe, Sierra 1500, Yukon models Equipped with RPO NSS.
• 10232069Feb 10, 2023Equipment, Exterior lighting, Latches, locks and linkages. This service bulletin provides information for dealers/technicians on the process to disable and enable passive unlocking.
• 10232804Feb 9, 2023Body and structure. This Preliminary information communicates that trucks built at Oshawa assembly utilize a powder anti-chip material process for stone guard protection, which does not have a textured appearance. The anti-chip performance meets all engineering criteria for durability and quality without a visibly textured surface. Trucks built at Flint, Fort Wayne, and Silao will have a textured appearance to the stone guard…
• 10232803Feb 8, 2023Electrical system. This Preliminary information communicates to dealer that GM is aware of an issue with Apple Carplay, and is working on a resolution.
• 10232071Feb 8, 2023Engine cooling. This service bulletin provides a service procedure to correct a condition of a Ticking Noise from the Engine.
• 10232799Feb 7, 2023Equipment. This Preliminary information provides a proactive communication to dealers advising that engineering is aware of the Turn by Turn concern, and working on a resolution. It also advises that once a repair is available that the PI will be replaced by a Service Bulletin.
• 10232079Feb 7, 2023Electrical system, Equipment. This technical bulletin provides repair information to correct a customer concern of Unable to Dismiss Turn By Turn Directions from the DIC.
• 10232076Feb 7, 2023Equipment, Electrical system. This service bulletin provides repair information to correct a customer concern of Wireless Charging Intermittent When Using Samsung Phones at Offset Positions.
• 10232073Feb 7, 2023Electrical system, Transmission and drivetrain. This service bulletin provides information for the technician that may experience a condition when after performing a DTC Clear/Reset on the TCM during diagnosis or after completion of a transmission repair or replacement, the DTCs did not clear or appear to reset on the next engine start.
• 10232070Feb 7, 2023Electrical system, Equipment. This service bulletin provides repair information to correct a customer concern of Blue or Black Screen and Service Rear Vision System Message on Radio Display Shifting into Reverse.
• 10232793Feb 6, 2023Back-over prevention (rear camera). This Preliminary information communicates diagnostics aids for rear view camera issues that may be encountered.
• 10232078Feb 6, 2023Engine cooling. This Informational bulletin advises the technician of possible areas the oil may leak from the engine.
• 10231349Feb 6, 2023Seats. Due to the industry-wide semiconductor shortage, the front heated/ventilated seats, front heated seats, or rear heated seats are not functional on certain 2022-2023 model year vehicles listed above, built beginning November 15, 2021. The affected vehicle owners should have been made aware of the condition at sale, and notified that once parts are available, they would be eligible for a no additional cost retrofit…
• 10231342Feb 6, 2023Seats. We are pleased to announce that additional 2022-2023 model year Buick Envision vehicles have been moved to Open status in IVH.
• 10232789Feb 3, 2023Equipment. This Preliminary information communicates to dealers that there is a known issue with a loss of audio and the concern is being investigated by GM Engineering.
• 10232786Feb 2, 2023Electrical system, Body and structure. This Preliminary information communicates a diagnostic tip on how to resolve a issue with the Body Control Module setting DTC: P0606 and turning on a Check Engine Lamp.

← All problems reported for the 2022 GMC Sierra 1500