2002 GMC Sierra Recalls
NHTSA lists 4 recall campaigns for the 2002 GMC Sierra. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.
- Service brakes, hydraulic › Antilock/traction control/electronic limited slipCovers: GMC Sierra 1999–2002, Chevrolet Silverado 1999–2002, Suburban 2000–2002 +4 more
Reported issue: Certain pickup trucks and sport utility vehicles may experience unwanted antilock brake system (abs) activation. This condition is more likely to occur in environmentally corrosive areas. This recall will be launched in the "salt belt" states of connecticut, delaware, illinois, indiana, iowa, maryland, massachusetts, maine, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania…
Possible consequence: This can cause increased stopping distances during low-speed brake applications, which could result in a crash.
Remedy: Dealers are to remove the wheel speed sensor and thoroughly clean the wheel speed sensor mounting surface on the bearing, apply rust inhibitor to the cleaned surface, grease the mounting surface, reinstall the wheel speed sensor, and check the peak-to-peak output voltage to ensure the wheel speed signal is within…
- Parking brakeCovers: GMC Sierra 1999–2005, Chevrolet Silverado 1999–2005
Reported issue: On certain pickup trucks equipped with manual transmissions and built with either pbr parking brake systems or trw parking brake systems, the parking brake friction linings may wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.
Possible consequence: If the parking brake does not hold, unintended vehicle movement could occur, which could result in a crash.
Remedy: Dealers will install a low-force spring clip retainer for vehicles equipped with a pbr parking brake system. On vehicles equipped with the trw parking brake system, dealers will install a redesigned parking brake cable assembly. The recall began on july 29, 2005. Owners may contact chevrolet at 1-800-630-2438 or gmc…
- Structure › Body › Tailgate › Hinge and attachmentsCovers: GMC Sierra 2000–2004, Chevrolet Silverado 2000–2004, Avalanche 2002–2004 +3 more
Reported issue: On certain pickup trucks and sport utility vehicles, the galvanized steel tailgate support cables that retain the tailgate in the full open (horizontal) position may corrode, weaken, and eventually fracture. If both cables fractured, the tailgate would suddenly drop and strike the top surface of the rear bumper.
Possible consequence: Anyone sitting or standing on the horizontal surface of the tailgate when both cables fractured could be injured by falling from the tailgate. On vehicles that have had the bumper removed, the tailgate may drop even lower. Additionally, if there is cargo on the tailgate the cargo may fall off if the support cables…
Remedy: Dealers will replace the cables. Interim owner notification began on april 7, 20004. The recall began on september 24, 2004, when replacement parts were available, and will continue through october 29, 2004. Owners should contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463, or…
- Fuel system, other › DeliveryCovers: GMC Sierra 2002, Chevrolet Silverado 2002
Reported issue: Some 2wd and 4wd pickup trucks, converted to either dedicated or bi-fuel compressed natural gas (cng) fuel usage, were assembled with a throttle cable that can contact and rub through the flexible pressurized fuel line creating a pinhole leak of natural gas to the atmosphere.
Possible consequence: A strong odor of natural gas may be detected from inside the vehicle, possibly accompanied by a hissing noise. If the natural gas were accidentally ignited, serious injury could result.
Remedy: Dealers will secure the throttle cable to eliminate the possibility of contact with the cng fuel line. The cng fuel line, throttle cable, and cruise control cable are also to be inspected and replaced if necessary. Owner notification began on december 11, 2003. Owners should contact chevrolet at 1-800-630-2438 or gmc…
← All problems reported for the 2002 GMC Sierra
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 29, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.