2015 Honda Crosstour Technical Service Bulletins

43 technical service bulletins (TSBs) are on record for the 2015 Honda Crosstour. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10186009Jan 23, 2021Equipment. "Service Bulletin - There are several A/C leak detection tools available. -Refrigerant Gas Leak Detector -Ultrasonic Leak Detector -Leak Dye"
• 10172570Mar 10, 2020Air bags. Service Bulletin - This bulletin is a notification of a class action settlement relating to airbag inflators. American Honda is offering a Customer Support Program (Warranty Extension) to cover any manufacturing defects in the replacement front passenger's airbag inflator only.
• 10163784Aug 13, 2019Air bags. Warranty Extension: Customer Support Program For Front Passenger's Airbag Inflator for 2010-12 Accord and Other Listed Years and Models (Expires September 30, 2028)
• 10165333Jul 11, 2019Suspension. This SKU is a Front Upper Ball Joint. The customer communication requested return of unsold inventory to inspect for the outer diameter of the ball joint housing being too small. The outer diameter being too small would prevent the part from being installed, and would therefore have no impact on the end user besides time to complete installation.
• 10163132Jul 8, 2019Body and structure. Dealer Message - American Honda Motor Co., Inc. (AHM) is investigating certain 2014-2015 Crosstours with a customer complaint of paint peel (NH603P White Diamond Pearl). To fully understand the cause of this condition, AHM would like to inspect the vehicle prior to you attempting a repair of any kind.
• 10161650Jun 19, 2019Body and structure. Dealer Message - American Honda Motor Co., Inc. (AHM) is investigating certain 2014-2015 Crosstours with a customer complaint of paint peel (NH603P White Diamond Pearl). To fully understand the cause of this condition, AHM would like to inspect the vehicle prior to you attempting a repair of any kind.
• 10160916May 31, 2019Body and structure. Engineering Request for Investigation - American Honda Motor Co., Inc. (AHM) is investigating certain 2014-2015 Crosstours with a customer complaint of paint peel (NH603P White Diamond Pearl). To fully understand the cause of this condition, AHM would like to inspect the vehicle prior to you attempting a repair of any kind.
• 10160598May 24, 2019Body and structure. Dealer Message - American Honda Motor Co., Inc. (AHM) is investigating certain 2014-2015 Crosstours with a customer complaint of paint peel (NH603P White Diamond Pearl). To fully understand the cause of this condition, AHM would like to inspect the vehicle prior to you attempting a repair of any kind.
• 10160545May 16, 2019Steering. ServiceNews Article - When removing and installing a cable reel, you need to keep both the cable reel and the steering angle sensor in position. If you don't , the VSA indicator may come on along with one or more VSA DTCs. And when you run the Neutral Memorization Procedure in the i-HDS, it won't complete.
• 10152750Jan 18, 2019Air bags. Service bulletin - This bulletin is a notification of a class action settlement relating to airbag inflators. American Honda is offering a Customer Support Program (Warranty Extension) to cover any manufacturing defects in the replacement front passenger's airbag inflator only.
• 10143331Jul 12, 2018Equipment. Servicenews article - If the On Demand Multi-Use Display? (ODMD) isn't responding to touch or is freezing up, the reason could be there's debris lodged in the gap between the touch screen and the bezel. Lodged debris contacting the screen can cause a false input, resulting in this issue. And since that gap widens and narrows with cabin temperature, this issue can be intermittent, especially in cold weather.
• 10143158Jul 12, 2018Equipment. Servicenews article - If the On Demand Multi-Use Display? (ODMD) isn't responding to touch or is freezing up, the reason could be there's debris lodged in the gap between the touch screen and the bezel. Lodged debris contacting the screen can cause a false input, resulting in this issue. And since that gap widens and narrows with cabin temperature, this issue can be intermittent, especially in cold weather.
• 10139551May 19, 2018Transmission and drivetrain, Equipment. Service bulletin - A judder from the torque converter lock-up clutch may be felt while driving between 20 and 60 mph. The problem is typically diagnosed as a bad torque converter. American Honda investigated the judder and found that the torque converter was not causing the judder and the transmission was not damaged by this judder.
• 10139550May 19, 2018Equipment, Transmission and drivetrain. Service bulletin - A judder from the torque converter lock-up clutch may be felt while driving between 20 and 60 mph. The problem is typically diagnosed as a bad torque converter. American Honda investigated the judder and found that the torque converter was not causing the judder and the transmission was not damaged by this judder.
• 10129336Feb 14, 2018Transmission and drivetrain. Dealer message - Every Service Bulletin requires you to take an HDS snap shot and use the job aid or Tech2Tech to confirm the judder/shudder is coming from the torque converter.
• 10129334Feb 13, 2018Electrical system. Tech line summary article - If the On Demand Multi-Use Display? (ODMD) isn?t responding to touch or is freezing up, the reason could be there?s debris lodged in the gap between the touch screen and the bezel. Lodged debris contacting the screen can cause a false input, resulting in this issue. And since that gap widens and narrows with cabin temperature, this issue can be
• 10115802Aug 11, 2017Transmission and drivetrain. Service bulletin - The starter grinds or spins at startup. The clearance between the starter motor gear and the torque converter ring gear is not optimal.
• 10115757Aug 3, 2017Steering. Service news article - To prevent damage during shipping, leather-wrapped steering wheels come with a protective plastic covering. The easiest way to remove it during PDI is to grab the covering with both hands near the top of the steering wheel and pull it toward you, like you see here. The covering comes right off.
• 10108880Jun 21, 2017Transmission and drivetrain. Service bulletin - This bulletin is replaced by 17-041, 2013?15 Crosstour V6: Judder from the Torque Converter Lock-Up Clutch
• 10108884Jun 20, 2017Transmission and drivetrain. Service bulletin - A judder from the torque converter lock-up clutch may be felt while driving between 20 and 60 mph. The problem is typically diagnosed as a bad torque converter. American Honda investigated the judder and found that the torque converter was not causing the judder and the transmission is not damaged by this judder.
• 10108883Jun 20, 2017Transmission and drivetrain. Service bulletin - A judder from the torque converter lock-up clutch may be felt while driving between 20 and 60 mph. The problem is typically diagnosed as a bad torque converter. American Honda investigated the judder and found that the torque converter was not causing the judder and the transmission was not damaged by this judder.
• 10108046Feb 23, 2017Engine, Equipment. Service bulletin - at cold start-up, the engine rattles loudly for about 2 seconds. This may be intermittent and occurs when the outside temperature is below 40° f. The variable valve timing control (vtc) actuator is defective.
• 10099110Nov 18, 2016Equipment. Service news article - something to keep in mind: aftermarket radar detectors may interfere with the gps antenna mounted behind the instrument panel. A common issue that’s been reported from this interference is the vehicle position (vp) icon isn’t in the right spot on the navigation screen.
• 10084330Jun 28, 2016Engine. Service news article - while driving under steady cruise (between 30 and 65 mph) or light acceleration, does the engine intermittently rattle or runs rough with the mil blinking? Since these driving conditions are likely to activate vcm operation, the probable reason for these symptoms is sticking vcm rocker arms.
• 10078580May 5, 2016Air bags. This communication is informing honda of a delamination issues within an I.c. Produced by nxp and assembled into airbag sensor supplied by denso international america, inc. This delamination issue manifests itself as an open circuit within the sensor, causing a dtc to be set on the vehicle along with a declaring “airbag” light.
• 10204285Feb 13, 2016Engine cooling. Engine Rattles at Cold Start-Up
• 10088283Feb 13, 2016Engine. Service bulletin - at cold start-up, the engine rattles loudly for about 2 seconds. This may be intermittent and occurs when the outside temperature is below 40° f. Replace the vtc actuator to remedy this condition.
• 10088442Feb 5, 2016Electrical system. Service bulletin - the starter grinds at startup due to inadequate clearance between the starter motor gear and the torque converter ring gear.
• 10100042Dec 10, 2015Engine. "techline summary article - editor’s note: this article replaces the one posted in september 2015 to extend that article’s shelf life. The issues covered are still being addressed. Do you have a vehicle that makes an engine rattle for 1 to 2 seconds when started after a cold overnight soak below 32° f? This rattle is most likely related to the vtc actuator."
• 10100175Nov 19, 2015Engine. Service news article - does the engine rattle at cold startup for 1 to 2 seconds when it’s cold outside? Chances are the vtc actuator is the culprit. Keep in mind simply replacing the vtc actuator using current parts stock won’t fix this rattle if it’s only heard under these conditions.
• 10107324Jul 17, 2015Engine. Engineering request - american honda (ahm) is investigating certain 2013-2015 accord v6s & crosstour v6s with a customer complaint of engine not starting or grinding noise at engine start. To fully understand the cause of this condition, ahm would like to collect specific parts from the vehicle in certain condition prior to you attempting a repair of any kind.
• 10107306Jul 13, 2015Engine. Dealer message - american honda (ahm) is investigating certain 2013-2015 accord v6s & crosstour v6s with a customer complaint of engine not starting or grinding noise at engine start. To fully understand the cause of this condition, ahm would like to collect specific parts from the vehicle in certain condition prior to you attempting a repair of any kind.
• 10108224May 29, 2015Engine, Electrical system. "dealer message - american honda (ahm) is investigating certain 2013-2015 accords & crosstours with the customer reporting a no start or grinding noise when trying to start. To fully understand the cause of this occurrence, ahm would like to inspect the vehicle prior to you attempting a repair of any kind."
• 10108256May 21, 2015Air bags, Steering, Equipment. A rubbing or groaning is heard from the driver’s front airbag module while turning the steering wheel.
• 10110854Jan 10, 2015Air bags. Service bulletin - An error during manufacture of tubing attached to the side curtain airbag inflator may result in the improper deployment of a side curtain airbag in a crash, increasing the risk of occupant injury.
• 10110853Jan 10, 2015Air bags. Service bulletin - An error during manufacture of tubing attached to the side curtain airbag inflator may result in the improper deployment of a side curtain airbag in a crash, increasing the risk of occupant injury.
• 10110852Jan 10, 2015Air bags. Service bulletin - An error during manufacture of tubing attached to the side curtain airbag inflator may result in the improper deployment of a side curtain airbag in a crash, increasing the risk of occupant injury.
• 10115219Dec 17, 2014Tires. Service bulletin - For any TPMS-related warranty repairs, all recorded DTCs must now be entered into the warranty claim. Make sure your repair order includes those DTCs.
• 10115795Dec 12, 2014Air bags. Service bulletin - An error during manufacture of tubing attached to the side curtain airbag inflator may result in the improper deployment of a side curtain airbag in a crash, increasing the risk of occupant injury.
• 10115794Dec 12, 2014Air bags. Service bulletin - An error during manufacture of tubing attached to the side curtain airbag inflator may result in the improper deployment of a side curtain airbag in a crash, increasing the risk of occupant injury.
• 10115793Dec 12, 2014Air bags. Service bulletin - An error during manufacture of tubing attached to the side curtain airbag inflator may result in the improper deployment of a side curtain airbag in a crash, increasing the risk of occupant injury.
• 10115783Dec 12, 2014Air bags. Dealer message - On December 11, 2014, American Honda notified NHTSA of a Stop Sale order and Safety Recall for 1,252 model year 2015 Crosstour vehicles.
• 10115775Dec 12, 2014Air bags. 2015 Crosstour Side Curtain Airbag Failure Safety Recall Q&A

← All problems reported for the 2015 Honda Crosstour