2002 Honda VFR800 Recalls

NHTSA lists 2 recall campaigns for the 2002 Honda VFR800. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.

• 07V359000Aug 15, 20076,952 vehicles potentially affected
  Electrical system › Wiring
  Covers: Honda VFR800 2002–2005

  Reported issue: On certain motorcycles, the front fairing sub-harness (section of the wiring harness) transfers the electrical grounding load of the headlights, front turn signals, instrument panel, and various relays to the main wiring harness via an 18-pin connector. Under certain conditions, the ground wire terminals inside the connector can overheat, resulting in melting of the connector and a loss of power to various circuits.

  Possible consequence: As a result, a loss of critical lighting or engine power could occur without warning, which could cause a crash.

  Remedy: Dealers will install a re-designed sub-harness. If damage is found, the main wiring harness will also be replaced free of charge. An interim letter was mailed to owners on september 26, 2007. Owners were re-notified on november 10, 2007, to take their motorcycles to dealers to have the parts installed. Owners may…

  Full campaign details →

• 05V010000Jan 24, 200536,046 vehicles potentially affected
  Service brakes, hydraulic
  Covers: Honda VFR800 2002–2004, GL1800 2002–2004, GL1800A 2002–2004 +4 more

  Reported issue: Certain motorcycles equipped with combined-brake systems have a proportioning control valve (pcv) that mechanically proportions brake force when the rear brake is applied. A seal in some pcvs is improperly shaped, and brake fluid leakage may occur.

  Possible consequence: If the motorcycle continues to be used after a leak occurs, the rear brake would eventually become inoperative. A loss of rear brake force could increase the risk of a crash.

  Remedy: Dealers will inspect the rear brake forleakage. If leakage is confirmed, the dealer will replace the pcv free of charge. The recall began on january 31, 2005. Owners may contact honda at 866-784-1870.

  Full campaign details →

NHTSA investigations

• PE05047Stalling & sudden headlight outageClosed · Sep 2, 2005

← All problems reported for the 2002 Honda VFR800