2007 Hummer H2 Technical Service Bulletins

829 technical service bulletins (TSBs) are on record for the 2007 Hummer H2. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10126163Nov 30, 2012Electrical system. This informational bulletin provides information regarding the aftermarket device interference with onstar diagnostic service.
• 10112614Nov 29, 2012Equipment. This Preliminary Information communication provides information to the technician about customers may inquire about the availability of the passenger compartment air filter. Dealer should advise the customer starting in 2003 the passenger compartment air filter is no longer available as a factory option.
• 10126171Nov 28, 2012Equipment. This informational bulletin provides a step by step procedure on how to properly use the GM chemicals to eliminate unwanted odors in vehicles and which products to use for each application.
• 10112608Nov 28, 2012Equipment. This Preliminary Information communication provides information to the technician on how to diagnose and repair vehicles that may have an OnStar Turn-By-Turn Navigation the system that is inoperative. Technician verifies there are no Diagnostic Trouble Codes are present in the Antilock Braking System and Vehicle Communication Interface Module of the vehicle. If no Diagnostic Trouble Codes found call OnStar using…
• 10112607Nov 28, 2012Equipment. This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Technical Assistance Center with the scan tool data from the OnStar system.
• 10138213Nov 26, 2012Wheels, Equipment. This informational bulletin provides a description of the proper wheel installation and proper wheel torque techniques used to install wheels onto vehicles
• 10137471Nov 26, 2012Wheels. This informational bulletin provides a description of the proper wheel installation and proper wheel torque techniques used to install wheels onto vehicles
• 10126191Nov 26, 2012Transmission and drivetrain. This informational bulletin provides a description of the proper wheel installation and proper wheel torque techniques used to install wheels onto vehicles
• 10112600Nov 26, 2012Transmission and drivetrain. This Preliminary Information communication provides information to the technician with the axel setup information from American Axle Manufacturing. Technician should be advised that the maximum pinion shim to be used or stacked behind the pinion is 0.050?, and the minimum pinion shim is 0.020? for an 8.6 axle. The range for available pinion depth shims for the 10.5? axle is 0.006? to 0.024?. When setting the…
• 10138211Nov 20, 2012Equipment. This warranty administration bulletin provides information regarding customer concerns not duplicated and which labor operations to claim when the concern cannot be duplicated. Also provides information on how to submit claims within the global warranty managment.
• 10137469Nov 20, 2012Equipment. This warranty administration bulletin provides information regarding customer concerns not duplicated and which labor operations to claim when the concern cannot be duplicated. Also provides information on how to submit claims within the global warranty managment.
• 10126192Nov 20, 2012Equipment. This warranty administration bulletin provides information regarding customer concerns not duplicated and which labor operations to claim when the concern cannot be duplicated. Also provides information on how to submit claims within the global warranty managment.
• 10138201Nov 13, 2012Equipment. This informational bulletin provides information and rules for GM keycode look up applicationa dn the key code security rules and regulations for Canada only.
• 10137459Nov 13, 2012Equipment. This informational bulletin provides information and rules for GM keycode look up applicationa dn the key code security rules and regulations for Canada only.
• 10137458Nov 13, 2012Equipment. This informational bulletin provides information for requesting a new key code for customers with lost or stolen keys
• 10126197Nov 13, 2012Equipment. This informational bulletin provides information for requesting a new key code for customers with lost or stolen keys
• 10126196Nov 13, 2012Equipment. This informational bulletin provides information and rules for GM keycode look up applicationa dn the key code security rules and regulations for Canada only.
• 10138197Nov 12, 2012Brakes, Engine, Equipment, Transmission and drivetrain. This informational bulletin provides a revision for 01-00-89-010I to add the 2013 model year.
• 10137454Nov 12, 2012Equipment. This informational bulletin provides a revision for 01-00-89-010I to add the 2013 model year.
• 10126200Nov 12, 2012Equipment. This informational bulletin provides a single point reference and strategy document to aid in reducing customer comebacks, and the possibility of buyback situations by outlining specific guidelines, strategy and forms that will assist with this goal, by identifying, clarifying and documenting customer concerns accurately at each service visit.
• 10126198Nov 12, 2012Equipment. This informational bulletin provides a list of newly released PI and Bulletins in regards to recent released vehicles so that vehicles can be fixed right the first time in for service.
• 10112560Nov 9, 2012Brakes. This Preliminary Information communication provides information to the technician about brake rotors on new vehicles and replacement parts from General Motors Service Parts Operations. Technician should be advised the costing should not be removed from the brake rotor it will wear off with normal brake usage. Dealer should communicate to the customer this condition is a normal operating characteristic of their…
• 10126203Nov 8, 2012Equipment. This warranty administration bulletin provides information on what should be considerd warranty damage or damage that was at fault of the cutomer and how to properly claim them on the warranty paperwork
• 10112546Nov 6, 2012Brakes. This Preliminary Information communication advises the technician that the Hydro-Boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.
• 10112544Nov 6, 2012Brakes, Steering. This Preliminary Information communication provides information to the technician about vehicles that may have a power steering pump whine noise. Technician will need to flush and refill the power steering system with Lucas Power Steering Fluid with Conditioners. Technician will replace the power steering pump with the latest design if the fluid is not available.
• 10112529Nov 1, 2012Equipment. This Preliminary Information communication provides information to the technician about vehicles that have an OnStar system that will not power up. Technician should turn off the ignition and cancel retained accessory power. After the vehicle has powered down, remove power to the OnStar module for five minutes. After the power has been removed for five minutes, if the OnStar system is working release the vehicle.
• 10112528Nov 1, 2012Electrical system. This Preliminary Information communication provides information to the technician about vehicles that during battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the OnStar system. Technician should understand the power cycles of the various OnStar systems. All Generation 6, 7, 8, and 9 systems are powered up continuously for 48 hours from ignition…
• 10112519Oct 29, 2012Suspension, Wheels. This Preliminary Information communication provides information to the technician about vehicles that have grease leaking from front hub bearings. Technician should not replace the bearing for grease purge. Technician should be advised to not clean the purged grease from the area immediately on or adjacent to the seals because this grease provides additional protection.
• 10112494Oct 18, 2012Equipment. This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts. Technician can check Service Information for some accessories. Technician can also contact Partech for assistance.
• 10118638Oct 15, 2012Engine cooling. This informational bulletin provides information on Identifying Non-GM (Aftermarket) Engine Calibrations for Gasoline Engines Using Tech 2 or GDS 2
• 10118637Oct 15, 2012Equipment. This informational bulletin provides information on dealer responsibility for cargo carrying capacity labeling and the part numbers for the labels.
• 10118635Oct 15, 2012Visibility (wipers, defrost, mirrors). This preliminary informational bulletin provides a procedure for relearning the power folding mirriors and road testin to verify they correct a condtion of the power folding mirriors glass shakes, flutters at normal driving conditions.
• 10118634Oct 15, 2012Transmission and drivetrain. This warranty administration bulletin provides information on the change in automatic transmission add conditions documentation and claim submissions
• 10084683Oct 15, 2012Equipment, Body and structure, Visibility (wipers, defrost, mirrors). This preliminary informational bulletin provides a procedure for relearning the power folding mirriors and road testin to verify they correct a condtion of the power folding mirriors glass shakes, flutters at normal driving conditions.
• 10118626Oct 10, 2012Equipment. This warranty administrational bulletin provides information on Clarification of Use - Dealer Empowerment Labor Operations and Customer Enthusiasm
• 10118623Oct 9, 2012Equipment. This warranty administrational bulletin provides information on courtesy transportation and roadside assistance programs offered through GM.
• 10118619Oct 5, 2012Equipment. This informational bulletin provides information on newly release bulletins used to fi the vehicles in the field the first time.
• 10246951Oct 1, 2012Equipment. Programming And Activation Of Replacement OnStar Modules.
• 10037570Apr 1, 2012Body and structure. Gm: on some truck models there is some frame corrosion. *rm updated on 5/2/2012.
• 10038294Jan 1, 2012Seat belts. Gm: there are seat belt problems: difficulty latching and unlatching buckle. Buckle release button is sticking. Seat belt warning light illuminated. Likely caused by sticky beverages that are spilled into the buckle assembly. *rm updated 4/3/12.
• 10043307Dec 1, 2011Engine cooling. Hummer: see document search button for owner letter. Recall bulletin pertaining to the erosion of the mat support material inside catalytic converter assembly and may cause malfunctioning of indicator light, noise and/or performance reduction in engine.
• 10032332Dec 1, 2011Electrical system. Gm/hummer/saab: intermittent illumination of mil, service lamps, service messages, or dtc set by various control modules-diagnosing and repairing fretting corrosion (disconnect affected connector and apply dielectric lubricant). *pe updated 3/26/10. *pe updated 6/6/11. *pe updated 3/12/12.
• 10037184Oct 1, 2011Seat belts. Gm: service bulletin explaining when the safety belts are supposed to lock. *rm updated 12/6/11.
• 10036464May 1, 2011Engine cooling. Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. Upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/11. *pe updated 5/9/11. *pe updated 5/25/11. *pe updated 06/16/2011. *kb updated a second time on 06/16/2011. *kb updated 6/27/11.
• 10037933Jan 1, 2011Engine cooling. Gm: the service engine soon light is on, there is also a misfire or engine noise. There are multiple possible causes.
• 10028790Nov 1, 2010Brakes. General motors: on all 1988-2009 full size chevrolet/gmc pickups, utilities and vans, the brake pedal will move down or self apply during full lock turns or near full lock turns. Chevrolet astro and gmc safari vans; hummer 2 are included. *pe updated 5/24/11.
• 10036545Oct 1, 2010Steering. Buick/cadillac/chevrolet/gmc/oldsmobile and hummer: information on pitman arm shaft seal service kit. Do not replace entire steering gear for pitman seal leak. Technicians have been replacing entire steering gears due to not being able to service just leaking pitman shaft seal. *pe updated 5/9/11.
• 10022702Jun 1, 2010Engine cooling. Intermittent mil/ses, dtc p2138 with reduced engine power (repair instrument panel (ip) to body harness connector). 2005-2008 gm passenger cars and light duty trucks including saturn. *nj updated 11/19/10. *pe updated 3/30/11.
• 10032462Aug 1, 2009Steering. Saab/hummer/gm: diagnostic tips/recommendations when power steering pump replacement is necessary. Analysis of returned power steering (ps) pumps that had been replaced for noise, no power assist, no or low pressure and leaking conditions has indicated a high number of no trouble found results. All 1997-2010 vehicles and light trucks; 2010 and prior hummers h2/h3 and saab 9-7x vehicles.
• 10021799Apr 1, 2009Fuel system. Various driveability functions due to clogged fuel injectors, mil/ses dtc's p0171, p0172, p0174, p0300, p1174, p1175. *kb updated 08-15-07. *kb updated 8/4/09.

← All problems reported for the 2007 Hummer H2