2019 Hyundai Ioniq Hybrid Technical Service Bulletins

73 technical service bulletins (TSBs) are on record for the 2019 Hyundai Ioniq Hybrid. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10169373Nov 7, 2019Electrical system. Certain vehicles may incur dash warning light(s) On with DTC(s) stored including either of the following DTC: ? U1116 - Lost Communication With Motor Electronics Coolant Pump (C-CAN) ? U1118 - Lost Communication With Hybrid/EV Battery Electronic Coolant Pump (P-CAN) The vehicle may operate in limp home at a reduced power. The above DTC(s) may occur due to coolant leaking into the Electric Water Pump (EWP) Can Case…
• 10169370Nov 4, 2019Back-over prevention (rear camera), Lane departure. The Blind Spot Detection (BSD) or Blind-Spot Collision Warning (BCW) is a system that measures the speed of and distance from the following vehicles by using two magnetic wave radar sensors attached in the rear bumper. The BSD/BCW detects vehicles within the blind spot zone and gives off an alarm (visual and audible). The two magnetic radar sensors provide these functions for BSD/BCW: ? Senses other vehicles in the…
• 10167770Oct 28, 2019Equipment, Engine. Hyundai is conducting a Service Campaign to install a new Air Filter Kit with an updated filter to help prevent DTC P0456 on certain 2017-2019 Ioniq (AE) HEV vehicles.
• 10167766Oct 28, 2019Electrical system, Engine, Equipment. Certain 2017-2019 vehicles may experience check engine light ?ON? with the following DTC stored: ? DTC P0456 - Evaporative System (EVAP) - Very Small LeakThese conditions primarily occur in the California coastal areas that are subject to marine layer cloud cover. Salt particulate deposit can form inside the Natural Vacuum Leak Detection (NVLD) which may cause intermittent operation prompting the DTC P0456 and the…
• 10167270Oct 28, 2019Engine cooling. Hyundai is conducting a Service Campaign to install a new Air Filter Kit with an updated filter to help prevent DTC P0456 on certain 2017-2019 Ioniq (AE) HEV vehicles.
• 10167262Oct 28, 2019Engine cooling. "Certain 2017-2019 vehicles may experience check engine light “ON” with the following DTC stored: DTC P0456 - Evaporative System (EVAP) - Very Small LeakThese conditions primarily occur in the California coastal areas that are subject to marine layer cloud cover. Salt particulate deposit can form inside the Natural Vacuum Leak Detection (NVLD) which may cause intermittent operation prompting the DTC P0456…
• 10167253Oct 14, 2019Equipment. This bulletin provides instruction detailing the proper methodology for scanning and uploading captured GDS data files to the Techline Repository. Compliance with this bulletin ensures that the GDS data files are correctly transferred and matched with a Techline Case number.
• 10165461Aug 13, 2019Equipment, Electrical system. This service campaign provides information related to a BMS software update to the diagnostic logic for DTC P1B77 ? ?High Voltage Battery Pre-charging Fault?.
• 10165457Aug 13, 2019Electrical system. This bulletin provides information related to a BMS (Battery Management System) software update to the diagnostic logic for DTC P1B77 ? ?High Voltage Battery Precharging Fault?.
• 10163863Jul 10, 2019Electrical system, Equipment. This bulletin provides information on how to return a Hyundai HEV/PHEV/EV/Fuel Cell Lithium Battery for proper disposal and safe environmental recycling using Hyundai?s authorized vendor Kinsbursky Brothers Intl. (KBI).
• 10161751May 16, 2019Lane departure, Forward collision avoidance. This bulletin provides information for troubleshooting of the Blind-Spot Collision Warning (BCW/BSD) system whenever it exhibits Diagnostic Trouble Code (DTC) C120B/D or C160A.
• 10160148Apr 23, 2019Electrical system. The following summarizes the service procedures for Lithium Battery replacement:
• 10160106Apr 22, 2019Steering. This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.
• 10160102Apr 19, 2019Engine, Engine cooling. This bulletin provides additional service diagnostic information and repair procedures related to electric A/C compressors equipped in hybrid electric vehicles, plug-in hybrid electric vehicles, and electric vehicles.
• 10160098Apr 15, 2019Electrical system, Transmission and drivetrain. This bulletin provides the procedure to write the Vehicle Identification Number (VIN) during the replacement of the Engine Control Module (ECM) or Powertrain Control Module (PCM). Once the VIN has been programmed to the ECM/PCM, it cannot be removed or overwritten.
• 10158803Mar 13, 2019Visibility (wipers, defrost, mirrors). This bulletin provides information on the serviceable parts for the outside mirror assembly. When diagnosing and repairing the outside mirror, do not replace the entire assembly. Refer to page 2 of this TSB for replacement of individual parts.
• 10154676Feb 12, 2019Electrical system. Some vehicles equipped with the wireless charging pad may experience a no charging condition. This bulletin provides information of how to diagnose the no charging condition.
• 10152891Jan 30, 2019Electrical system. This bulletin provides information on how to return a Hyundai HEV/PHEV/EV/Fuel Cell Lithium Battery for proper disposal and safe environmental recycling using Hyundai?s authorized vendor Kinsbursky Brothers Inc. (KBI).
• 10152867Dec 20, 2018Electrical system. This bulletin provides information related to an ECM (Engine Control Module) ECU software update for OBD (On Board Diagnostics) logic improvement. The Freeze Frame Data has been updated for multiple DTC.
• 10152866Dec 20, 2018Electrical system. Hyundai Motor America is conducting a Service Campaign to update the ECM software on certain Dealer Stock 2019 Model Year Ioniq Hybrid and Plug-In vehicles. Service Campaign T3P provides a procedure to update the ECM software.
• 10152856Dec 6, 2018Electrical system. This bulletin provides the procedures for calibrating Ioniq Hybrid sensors using GDS whenever the components listed below are replaced or the DTC listed are stored.
• 10147417Oct 24, 2018Electrical system. This bulletin describes the procedure to update the ESCAHB (Electronic Stability Control Active Hydraulic Braking) software on 2019 model year Ioniq Hybrid/Plug-in Hybrid (AE HEV/PHEV) vehicles to revise the sensitivity of the brake pedal application.
• 10147416Oct 24, 2018Electrical system. Hyundai Motor America is conducting Service Campaign to update the ESCAHB(electronic stability control active hydraulic braking) software on certain dealer stock 2019 Ioniq Hybrid and Plug-In Hybrid vehicles. Service Campaign T3H provides a service procedure to update the ESCAHB software.

← All problems reported for the 2019 Hyundai Ioniq Hybrid