2007 Hyundai Santa FE Technical Service Bulletins

81 technical service bulletins (TSBs) are on record for the 2007 Hyundai Santa FE. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10059640May 15, 2014Equipment. Summary to be provided on a future date.
• 10060570Nov 1, 2012Equipment. Summary to be provided on a future date.
• 10038212Dec 1, 2010Engine cooling. Hyundai: a revised procedure for replacing the timing chain tensioners.
• 10034649Aug 1, 2010Engine cooling. Hyundai: dtc p2135/p0638 or cold engine rpm fluctuation; tps replacement and ecm update. Some 2.7l, 3.3l or 3.8l engines in models identified in the applicability list may experience one or more of the conditions listed.
• 10034232Feb 1, 2010Wheels. Hyundai: rear hub bearing replacement 4wd. Describes the procedure to replace the rear hub bearings on certain vehicles. The procedure includes installation instructions for dust covers included in the replacement hub bearing kit.
• 10032908Oct 1, 2009Engine cooling, Transmission and drivetrain. Hyundai: ata solenoid diagnostic trouble codes p0740, p0741, p0742, p0743, p0746, p0748, p0750, p0755, p0760, p0765, p0770. Incorrect operation of the transaxle solenoids may result in the following symptoms-check engine light illuminated; transaxle held in 3rd gear fail safe.
• 10032793Oct 1, 2009Engine cooling, Equipment. Hyundai: some vehicles may experience a malfunction indicator lamp illuminated with the etc (electronic throttle control) system related dtc p2135 ( forced limited power) or dtc p0638 (power management).
• 10031906Sep 1, 2009Transmission and drivetrain. Hyundai: rear hub bearing replacement 4wd. The procedure to replace the rear hub bearings on certain santa fe vehicles. The procedure includes installation instructions for dust covers included in the replacement hub bearing kit.
• 10031964Aug 1, 2009Seats. Hyundai: power seat switch replacement. Procedures to replace the power seat switch some vehicles.
• 10030984Jul 1, 2009Transmission and drivetrain, Engine cooling. Hyundai: automatic transaxle range switch diagnostic trouble codes p0705 (range switch signal problems), p0707 (range switch open circuit), and p0708 (range switch short circuit or multiple inputs). An improperly adjusted or improperly operating range switch may result in the above mentioned conditions. Malfunction indicator light (mil) illuminated; impossible engine start in p or n.
• 10031008Jun 1, 2009Exterior lighting. Hyundai service campaign: see document search button for owner letter. Stop lamp switch replacement (campaign 092). This bulletin describes the procedure to remove, replace, and adjust the stop lamp switch.
• 10030877Jun 1, 2009Electrical system, Engine cooling. Hyundai: wire attachment-engine room junction box. Vehicles equipped with the fully automatic temperature control (fatc) a or the manual hvac system with the optional trip computer may display an incorrect outside temperature reading.
• 10030355May 21, 2009Electrical system. Hyundai: (service campaign t85). Conducting a service campaign to update the ecu software on certain vehicles. Reflash the ecu with the appropriate file listed in the charts in this tsb.
• 10030356May 15, 2009Electrical system, Engine cooling. Hyundai: (service campaign t83). Some vehicles equipped with a temperature control display may show an incorrect outside temperature reading. This bulletin describes the procedure to connect two wires in the engine room junction box using a wire joint kit to repair this condition.
• 10029229Apr 1, 2009Fuel system, Engine cooling. Hyundai: mil on dtc p2135 or p0638 or cold engine rpm fluctuation- tps replacement & ecm update. Some vehicles may experience either slight engine rpm fluctuation at cold warm up or malfunction indicator lamp illuminated with the etc (electronic throttle control) system.
• 10028825Feb 1, 2009Engine cooling. Hyundai: some vehicles may experience a malfunction indicator lamp illuminated with the etc (electronic throttle control) system related dtc p2135 or dtc p0638.
• 10027907Nov 1, 2008Steering. Hyundai: power steering gear box yoke kit installation procedure. If vehicle exhibits a slight rattle noise originating from the steering gear box when turning right on uneven road surfaces, replace the support yoke and yoke spring with the support yoke kit using the procedure described in this bulletin. Note: no steering performance issues associated with this condition.
• 10026549Sep 1, 2008Suspension. Hyundai: change of lower arm ball joint assembly. The cover type has changed from a separate component to an integrated type.
• 10024905Mar 1, 2008Engine cooling. Check engine light p2135 dtc diagnosis - vehicles equipped with 2.7l, 3.3l, or 3.8l engines.
• 10024542Mar 1, 2008Other or unknown. Trailer hitch wiring harness replacement procedure (campaign 082).
• 10024303Feb 1, 2008Engine cooling. Ecm updated - (ep) entourage and (cm) santa fe 3.3l mil on with dtc p0110, p0128 & p0300.
• 10024302Feb 1, 2008Engine cooling. Check engine light p2135 dtc diagnosis -- some 2006-2007 vehicles equipped with 2.7l, 3.3l, or 3.8l engines.
• 10023629Nov 1, 2007Electrical system. Ecm update - mil (malfunction indicator lamp) on with dtc p0110 or p0300, even though there are no system faults.
• 10022202Jun 1, 2007Body and structure. Tailgate garnish contacts the tailgate. Procedures to repair if contact has occured.
• 10021501Apr 1, 2007Engine cooling. Insertion of washer between front hub and driveshaft.
• 10021486Apr 1, 2007Electrical system. Front impact sensor (fis) code b1327 and b1332 diagnostics.
• 10020988Feb 20, 2007Suspension. Insertion of washer between front hub and drive shaft.
• 10020908Dec 1, 2006Brakes. Adjustable brake pedal removal and installation prcedure.
• 10020709Nov 1, 2006Body and structure. Insertion of washer between front hub and driveshaft.
• 10021137Oct 1, 2006Engine cooling. 3.3l & 3.8l timing chain tensioner - part update.
• 10021136Oct 1, 2006Transmission and drivetrain. Automatic transaxle shift lever will not shift out of park.

← All problems reported for the 2007 Hyundai Santa FE