2012 International Prostar Technical Service Bulletins

496 technical service bulletins (TSBs) are on record for the 2012 International Prostar. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10117237Jul 28, 2015Electrical system. A jump start or electrical load dump event could result in an overvoltage condition of the cab Linear Power Module (LPM). The overvoltage condition could eventually cause overheating of the LPM circuit board.
• 10117231Jul 28, 2015Engine cooling. Front Blower Motor Runs Breifly At Initial Power Up
• 10117227Jul 28, 2015Equipment, Interior lighting. Mirror / Map Light / Visor LED Lighting Up when CB MIC is keyed
• 10117172Jul 28, 2015Exterior lighting. Newer Brake Light Operation
• 10117235Jul 24, 2015Electrical system. Pressure Transducer (PT) Switch Install
• 10117229Jul 23, 2015Equipment. Offensive Odors Inside Cabin
• 10117226Jul 23, 2015Equipment. Mirror Repair Procedures and Replacement Parts Availability
• 10117174Jul 17, 2015Engine. N13, MaxxForce 11, 13 engine Two Cylinder Air Compressor Testing
• 10117173Jul 17, 2015Brakes. Rear S Cam Tube / Bracket part update
• 10057954Jul 17, 2015Brakes. Navistar: various types navistar vehicles will be receiving updates on the rear s cam tube/ bracket parts. *ta updated 9/10/15
• 10117181Jul 14, 2015Equipment. HVAC faults 520211 and 520465
• 10117189Jul 13, 2015Transmission and drivetrain. Eaton Clutch Information
• 10117232Jul 9, 2015Equipment. ESPAR AirTronic Low Run Time.
• 10117234Jul 2, 2015Equipment. Symptom 3: NoIdle HVAC Inoperative
• 10117233Jul 1, 2015Equipment. 2010 and Newer Vehicle Air Conditioning Diagnostics (Start Here)
• 10117175Jul 1, 2015Engine cooling. DPF Snap Accel Test - Quick Test to All vehicles with DPFs
• 10125327Jun 30, 2015Engine cooling, Engine. 2010 and Newer Vehicle Air Conditioning Diagnostics (Start Here)
• 10054087Jun 24, 2015Transmission and drivetrain, Electrical system. Navistar: steering wheel will not have shift controls due to phoenix shifter being programmed to look for steering wheel mounted shift controls and if an error is detected, a fault will be set. Model prostar. *pe updated 9/14/15
• 10052502Jun 24, 2015Latches, locks and linkages, Visibility (wipers, defrost, mirrors), Electrical…. International: information regarding issue with power windows failing to operate properly or power doors failing to lock or when window stops, button pressed and window resumes operation. Models terrastar, durastar, workstar, transstar, prostar and lonestar. No model years listed. *pe updated 12/16/13. *pe updated 12/18/13. *pe updated 9/14/15
• 10125326Jun 15, 2015Engine cooling, Engine. Grille/Bug Screen Rubbing Against A/C Condenser
• 10115388May 26, 2015Equipment. Vehicle Air Conditioning Diagnostics (Start Here)
• 10115391May 20, 2015Electrical system. An incorrect terminal may have been installed on harness part number 4047811C91. This terminal does not allow the harness to be installed without modifying the harness.
• 10115387May 15, 2015Equipment. Air Conditioning Mechanical Pressures Diagnostics
• 10115389May 12, 2015Equipment. Pressure Transducer (PT) Switch Install
• 10115364May 11, 2015Equipment. Coolant odor in cab with rear HVAC; equipped with Feature 0595BJN or 0595BWZ
• 10115385May 7, 2015Equipment. MaxxPower No Idle Battery-Powered A/C System Diagnostic Guide; models equipped with feature 16UZL
• 10115386May 4, 2015Equipment. Air Conditioning Electrical Diagnostics
• 10117136Apr 27, 2015Fuel system. Dual Fuel Tank Transfer Pump System With Two Wire Pump Troubleshooting; equipped with feature 595192 built after 08/19/2002
• 10117137Apr 24, 2015Fuel system, Other or unknown. Dual Fuel Tank Transfer Pump Troubleshooting on Post-2007 NGV and ProStar
• 10117093Apr 23, 2015Electronic stability control. The First Check to make when Troubleshooting any Body Controller or ESC Issue
• 10117144Apr 21, 2015Equipment. MaxxPower No Idle Battery-Powered A/C System Diagnostic Guide; models equipped with feature 16UZL
• 10117089Apr 16, 2015Equipment. 04SPL, MCAC 476, Yoosung, Compressor - Service Information
• 10117138Apr 14, 2015Engine. Davco Fuel Filter Replacements Recommendation for Maxx Force 11 and 13, 2010 Engines
• 10117143Apr 9, 2015Equipment. Vehicle Air Conditioning Diagnostics (Start Here)
• 10117142Apr 8, 2015Equipment. HVAC Diagnostic Information
• 10115483Mar 27, 2015Equipment. Air Conditioning Electrical Diagnostics
• 10115481Mar 26, 2015Equipment. MaxxPower No Idle Battery-Powered A/C System Diagnostic Guide; equipped with Feature 16UZL
• 10115482Mar 23, 2015Equipment. HVAC Diagnostic Information
• 10115462Mar 17, 2015Engine cooling. Charge Air Cooler Outlet Temperature Sensor Damaged; equipped with N13, MaxxForce 11, 13 engines
• 10115490Mar 16, 2015Equipment. Symptom 5: No-Idle HVAC Blows Warm Air
• 10115489Mar 16, 2015Equipment. Symptom 4: No-Idle HVAC Digital Display Inoperative
• 10115488Mar 16, 2015Equipment. Symptom 3: No-Idle HVAC Inoperative
• 10115487Mar 16, 2015Equipment. Symptom 2: No-Idle HVAC Fault Codes
• 10115486Mar 16, 2015Equipment. No-Idle HVAC Operational Check - STARTING POINT
• 10115485Mar 16, 2015Equipment. Symptom 1: No Idle HVAC Cools but Operates Incorrectly
• 10115484Mar 16, 2015Equipment. 2010 and Newer Vehicle Air Conditioning Diagnostics (Start Here)
• 10058008Jan 12, 2015Transmission and drivetrain. Navistar: some navistar prostar vehicles with the cummins isx 15l engines installed were built with the front left frame crossmember bolt installed in the wrong direction.
• 10096283Dec 29, 2014Equipment. Air pressure gauges and a/c pressure transducer troubleshooting
• 10096380Dec 16, 2014Equipment. 2010 and newer vehicle air conditioning diagnostics (start here)
• 10096375Dec 10, 2014Visibility (wipers, defrost, mirrors). Mirror repair procedures and replacement parts availability

← All problems reported for the 2012 International Prostar