2014 Jaguar XJ Technical Service Bulletins

625 technical service bulletins (TSBs) are on record for the 2014 Jaguar XJ. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10096610Jul 1, 2015Electrical system. "issue the message ""radar sensor blocked"" appears in instrument pack display. If blockage occurs while acc is being used, “driver intervene” and/or ""radar sensor blocked"" message will appear on the cluster and dtc c1a67-97 is also set. Blockage can also occur when acc is not being used. Cause ""radar sensor blocked"" indicates that the adaptive speed control system's visibility has been reduced due to an…
• 10058422Jul 1, 2015Transmission and drivetrain. Jaguar: when at a stop, transmission appears in neutral even when transmission control switch was not moved and gear position indicator and instrument cluster flashing d or s in message cluster. Model 2014-16 f-type (x152), 2013-15 xf (x250), xj range (x351.
• 10079081Jun 17, 2015Equipment. "issue: customer complains of damage/marking on the surface of the vehicle’s instrument pack lens. Cause: damage/marking caused by object impact against the lens. Staining/discoloration contamination caused by using any type of cleaning product on lens."
• 10079083Jun 11, 2015Electrical system. "issue the message ""radar sensor blocked"" appears in instrument pack display. If blockage occurs while acc is being used, “driver intervene” and/or ""radar sensor blocked"" message will appear on the cluster and dtc c1a67-97 is also set. Blockage can also occur when acc is not being used. Cause ""radar sensor blocked"" indicates that the adaptive speed control system's visibility has been reduced due to an…
• 10079082Jun 11, 2015Electrical system. "issue b1412-96 being flagged in the gateway module cause under investigation."
• 10096582May 19, 2015Engine. "situation: a 'humming' noise may be evident from the engine when the engine is idling. Cause: this may be caused by dust and/or water ingress to the primary drive belt idler pulley bearing."
• 10096579May 19, 2015Engine cooling, Engine. "situation: the fluid level in the engine coolant system expansion tank may fall below the minimum level over a period of time or a ‘low coolant level’ message is displayed in the message center. Upon inspection, a leak may be found to be from the front of the engine-driven coolant pump, together with excessive wear of the coolant pump bearing."
• 10096569Apr 8, 2015Equipment. "situation: the face of the compact key handset may peel away from the handset main body or the handset case may be bulging. Cause: this may be caused by the handset manufacturing process."
• 10096567Apr 8, 2015Equipment, Electrical system. "situation: when attempting to use an mp3 player through the auxiliary (aux) input jack, there may be no audio from right-hand-side speakers. Cause: this may be caused by an incorrectly wired connector c32-m."
• 10096601Apr 1, 2015Electrical system, Transmission and drivetrain. "situation: after coming to a stop, the vehicle will not move off and the transmission may appear to be in neutral even though the transmission control switch has not been moved. The transmission gear position indicator on the gear selector and in the instrument cluster message center may be flashing 'd' or 's'. If the engine is stopped and restarted or neutral (n) or park (p) and then drive (d) or sport (s) is…
• 10096535Mar 20, 2015Transmission and drivetrain. "situation: after coming to a stop, the vehicle will not move off and the transmission may appear to be in neutral even though the transmission control switch has not been moved. The transmission gear position indicator on the gear selector and in the instrument cluster message center may be flashing 'd' or 's'. If the engine is stopped and restarted or neutral (n) or park (p) and then drive (d) or sport (s) is…
• 10096534Mar 19, 2015Equipment, Engine. "situation: a metallic 'clicking' / 'rasping' noise may be evident from the engine. The noise may be more noticeable when the engine is at idle speed and when the engine is cold. Cause: this may be caused by a noisy high pressure fuel pump outlet valve."
• 10096546Mar 6, 2015Equipment, Body and structure. "issue: jlr engineering are currently receiving a number of epqr’s regarding x351 rear door electric sunblind’s not operating at pdi or following battery disconnect causing the loss of the single press function and also the sunblind material will appear distorted on the front edge. Please view example pdf attachment. Cause: rear door sunblind module is not initialized at pdi or the module has lost the power…
• 10096533Mar 6, 2015Equipment, Engine, Fuel system. "situation: a metallic 'clicking' / 'rasping' noise may be evident from the engine. The noise may be more noticeable when the engine is at idle speed and when the engine is cold. Cause: this may be caused by a noisy high pressure fuel pump outlet valve."
• 10096516Feb 27, 2015Steering. "issue: a steering wheel shimmy may be evident during the pre-delivery inspection (pdi) road test due to temporary flat spots on the rolling surface of the tire. Cause: temporary flat spots naturally develop on the rolling surface of a tire when the wheels of the vehicle are stationary over a period of time."
• 10096517Feb 13, 2015Visibility (wipers, defrost, mirrors). "issue rear vanity mirror, when opened may become dislodged or hang down.(see attached picture) cause incorrect process during manufacture causing swivel pin to fracture and eventually fail."
• 10096507Jan 29, 2015Electrical system, Transmission and drivetrain. "issue: for the models identified above, a concern has been identified with the latest tcm software released on dvd 139 patch 15. Cause: currently under investigation with jlr engineering."
• 10096505Jan 20, 2015Fuel system, Equipment. "issue: high pressure fuel pump diagnostics on 3.0l aj126 and 5.0l aj133 engines have been updated. Action: please refer to the procedure below for information on how to access the new information through sdd."
• 10096455Jan 7, 2015Equipment. "situation: inadequate a/c performance, low pressure recorded on the high pressure system, and/or high pressure recorded on the low pressure system may be exhibited with the compressor clutch (where applicable) working properly. Cause: this may be caused by the a/c compressor direct pressure sensing (dps) valve being worn."
• 10097045Jan 5, 2015Suspension. "re-issued dec 2015 issue: engineering is investigating reports of xj (x351) ride height sensors not operating correctly. Cause: the air suspension and active dynamics modules include checks of the height sensors during vehicle usage. If there is a fault with the height sensor, wiring harness, or connector, then a dtc will be stored. The affected ride height sensor part numbers are c2d6859, c2d16582, c2d6857…
• 10096542Jan 5, 2015Equipment. "issued march 2015. Issue: coolant leak from 5.0l v8 (aj133) water pump. Cause: a number of changes to the water pumps have been made to improve product quality."
• 10096502Jan 5, 2015Engine cooling, Equipment. "issue: low coolant message displayed. A coolant leak is found from the seam on coolant pipe (aj8 9664). See the attached file for an example of the leak location. Cause: a process issue at component supplier"
• 10096462Jan 5, 2015Seats, Equipment. "situation: a 'creak' noise from the base of the front seat may be evident. Cause: this may be caused by insufficient lubricant during the assembly process."
• 10096458Jan 5, 2015Steering. "situation: this is an information only bulletin to aid in the diagnosis of hydraulic power steering issues. Action: when diagnosing customer concerns relating to the hydraulic power steering system, refer to the service information below."
• 10226147Dec 19, 2014Visibility (wipers, defrost, mirrors). Inadequate A/C Performance / Direct Pressure Sensing Valve Replacement
• 10214657Dec 19, 2014Steering. Steering gear fixing.
• 10096411Dec 19, 2014Equipment. "situation: inadequate a/c performance may be exhibited. Upon inspection, low pressure is recorded on the high pressure system, high pressure recorded on the low pressure system, and the compressor clutch (where applicable) is working properly. Cause: this may be caused by the a/c compressor direct pressure sensing (dps) valve being worn."
• 10065178Dec 19, 2014Equipment. Summary to be provided on a future date.
• 10096430Dec 17, 2014Fuel system. "issue: high pressure fuel pump diagnostics on 3.0l aj126 and 5.0l aj133 engines have been updated. Action: please refer to the procedure below for information on how to access the new information through sdd."
• 10226154Dec 8, 2014Transmission and drivetrain, Electrical system. Transfer Case Control Module Rotary Position Sensor Fault Misdetection
• 10214391Dec 8, 2014Transmission and drivetrain. Potential Transmission Filter Detachment from Fluid Pan.
• 10096423Dec 8, 2014Transmission and drivetrain. "situation: an issue has been identified on a number of 2015 model year f-type (x152) and 2014 model year xf (x250) and xj (x351) vehicles where the transmission filter may become detached from the transmission fluid pan. This could result in harsh shifting of the transmission and a transmission fault message maybe displayed on the instrument cluster message center.
• 10096421Dec 8, 2014Equipment, Transmission and drivetrain. "situation: a '2wd only' warning message may be displayed on the instrument cluster during a cold weather start-up. Cause: this may be caused by a transfer case control module (tccm) rotary position sensor fault misdetection."
• 10096407Dec 8, 2014Equipment, Transmission and drivetrain. "description an issue has been identified on a number of 2015 model year f-type (x152) and 2014 model year xf (x250) and xj (x351) vehicles within the listed vin ranges where the transmission filter may become detached from the transmission oil pan base."
• 10065231Dec 8, 2014Transmission and drivetrain. Summary to be provided on a future date.
• 10065185Dec 8, 2014Transmission and drivetrain. Summary to be provided on a future date.
• 10063959Dec 8, 2014Transmission and drivetrain. Summary to be provided on a future date.
• 10229413Dec 4, 2014Engine cooling. XF/XJ Eco Stop/Start Additional Diagnostics Information
• 10229412Dec 4, 2014Engine cooling. XF/XJ Eco Stop/Start Additional Diagnostics Information
• 10096504Dec 4, 2014Electrical system. "issued january 2015. Issue: a customer may report one of the following symptoms: 1) battery charging warning message or eco stop inhibited message is displayed in the instrument cluster 2) eco stop is non-functional over a number of drive cycles 3) the vehicle experiences an un-commanded shutdown after an eco stop event and requires an ignition restart. Cause: various conditions can lead to the concern, as…
• 10096426Dec 4, 2014Electrical system. "issue: a customer may report one of the following symptoms: 1) battery charging warning message or eco stop inhibited message is displayed in the instrument cluster 2) eco stop is non-functional over a number of drive cycles 3) the vehicle experiences an un-commanded shutdown after an eco stop event and requires an ignition restart. Cause: various conditions can lead to the concern, as detailed below"
• 10065293Dec 4, 2014Electrical system. Summary to be provided on a future date.
• 10229417Dec 1, 2014Engine cooling, Fuel system. 3.0 & 5.0 Gasoline engines ? High pressure fuel pump diagnostics
• 10096403Nov 24, 2014Equipment, Engine. "issue a significant number of tss motors have been replaced under warranty, when returned to the supplier for analysis many are deemed as “no fault found”. Dtc’s may be present, due to this carry out a dtc global read using the recommended diagnostic and follow the help text for each dtc’s. It is possible during an eco stop start that the vehicle does not re-start. Cause incorrect diagnosis."
• 10228526Nov 21, 2014Brakes. underbody brake pipe
• 10216230Nov 21, 2014Brakes. Brake Pipe Torque Integrity.
• 10065239Nov 21, 2014Brakes. Summary to be provided on a future date.
• 10064296Nov 21, 2014Brakes. Summary to be provided on a future date.
• 10228498Nov 13, 2014Brakes. brake booster solenoid connector spring locking mechanism may not be engaged
• 10214402Nov 13, 2014Brakes. Brake Booster Solenoid Connector Spring Locking Mechanism Not Engaged.

← All problems reported for the 2014 Jaguar XJ