2005 Jeep Grand Cherokee Recalls
NHTSA lists 3 recall campaigns for the 2005 Jeep Grand Cherokee. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.
- Electrical system › Ignition › SwitchCovers: Jeep Grand Cherokee 2005–2007, Commander 2006–2007
Reported issue: This defect can affect the safe operation of the airbag system. Until this recall is performed, drivers should adjust their seat to allow clearance between the driver's knee and the ignition key, and remove all items from their key ring, leaving only the vehicle key. Chrysler Group LLC (Chrysler) is recalling certain model year 2005-2007 Jeep Grand Cherokee vehicles manufactured February 11, 2004, to July 5, 2007…
Possible consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the…
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch, free of charge. Chrysler sent interim notifications to owners in September 2014. The recall began on October 9, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P41.
- Electrical systemCovers: Jeep Grand Cherokee 2005–2010, Commander 2006–2010
Reported issue: Chrysler Group LLC (Chrysler) is recalling certain model year 2005-2010 Jeep Grand Cherokee vehicles manufactured February 11, 2004, through March 9, 2010; and 2006-2010 Jeep Commander vehicles manufactured January 31, 2005, through March 10, 2010. A transfer case electrical failure may result in an unintentional shifting of the transfer case into the neutral position.
Possible consequence: If the vehicle shifts into neutral, it may roll away increasing the risk of a crash or personal injury.
Remedy: Chrysler will notify owners, and dealers will reflash the final drive controller which governs the transfer case, with new software, free of charge. The recall began on August 15, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N23.
- Power train › Automatic transmissionCovers: Jeep Grand Cherokee 2005
Reported issue: On certain sport utility vehicles equipped with 3.7l engines and nag1 automatic transmissions, the air conditioner evaporator condensate water may enter the transmission at the fill tube grommet seal. This can result in shudder during torque converter clutch engagement.
Possible consequence: It can lead to increased transmission operating temperatures, boiling of the water, and a subsequent purging of transmission fluid into the engine compartment potentially resulting in an underhood fire.
Remedy: Dealers will inspect the transmission for leakage at the fill tube grommet seal. If no leak is detected, a new fill tube grommet seal and water deflector shield will be installed, and proper alignment of the fill tube verified. If the presence of a leak is detected, the vehicle will be evaluated for shudder during…
NHTSA investigations
- PE14017Air Bag Non-deploymentClosed · Jun 16, 2014
- EA12005Crash Related Fuel Tank FiresClosed · Jun 12, 2012
← All problems reported for the 2005 Jeep Grand Cherokee
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.