2015 Jeep Renegade Technical Service Bulletins

402 technical service bulletins (TSBs) are on record for the 2015 Jeep Renegade. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10121754Sep 27, 2017Engine cooling. 3.2L - 3.6L Cylinder Head Assy Multiple cylinder head replacement. If a cylinder head is replaced on a vehicle more than 1 time for any reason, please call any of the following people. First: Joe Lovell - Cell (734) 309-6467 [email protected] Second: Kevin Refalo - Cell (248) 260-0738 [email protected] If no response in 15 minutes, proceed with repair.
• 10121794Sep 14, 2017Transmission and drivetrain, Electrical system. Flash: Transmission Diagnostic and Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one of the following DTCs have been set:P0887 - TCM Power Control Circuit High. P061B - Internal Control Module Torque…
• 10224767Aug 30, 2017Seat belts, Exterior lighting, Brakes, Air bags, Wheels, Electrical system. Flash: Radio Frequency Hub Module (RFHM) Enhancements This bulletin involves reprogramming the RFHM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following DTC has been set:B1053-64 RFHM (Keyless Ignition Node (KIN) Communication) - Signal Plausibility Failure (Software has been updated to…
• 10223720Jul 26, 2017Engine cooling. Cover Kit Please note that if you are attempting to get the cover kit and it is not available the gasket is available as a separate part number in the kit which is 04753095AB.
• 10219831Jun 14, 2017Vehicle speed control. Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. P2122 and P2127 will set if accelerator pedal connector is disconnected during diagnosis. Make sure codes are active before replacing pedal. DTC P2299 is usually caused by a two footed driver and accelerator pedal should not be replaced for this fault.
• 10138856Jun 14, 2017Vehicle speed control. Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. P2122 and P2127 will set if accelerator pedal connector is disconnected during diagnosis. Make sure codes are active before replacing pedal. DTC P2299 is usually caused by a two footed driver and accelerator pedal should not be replaced for this fault.
• 10219830Jun 7, 2017Visibility (wipers, defrost, mirrors). Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the bottle anti-rotation features that surround the SENSOR. Check to determine if the issue has been resolved. Continue with repair if necessary. Please contact Chris Koch at cell (248)…
• 10217524Mar 29, 2017Body and structure. Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Replacing it unnecessary and is an over-repair.
• 10139992Mar 29, 2017Body and structure. Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Replacing it unnecessary and is an over-repair.
• 10217574Mar 22, 2017Electrical system. Flash: Powertrain Diagnostic And System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software.
• 10140042Mar 22, 2017Electrical system, Transmission and drivetrain. Flash: Powertrain Diagnostic And System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software.
• 10217521Mar 15, 2017Fuel system. Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 [email protected], or Joe Lovell (734) 309-6467 [email protected] before proceeding. If unable to reach after 15 minutes record the following information and proceed with oil pump…
• 10139989Mar 15, 2017Engine cooling. Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 [email protected], or Joe Lovell (734) 309-6467 [email protected] before proceeding. If unable to reach after 15 minutes record the following information and proceed with oil pump…
• 10217556Mar 10, 2017Back-over prevention (rear camera). Noise In Front Of Vehicle When Accelerating Or Decelerating This bulletin involves replacing both front half shafts. The customer may describe a ?clunk type? noise in front of the vehicle while accelerating or decelerating.
• 10140024Mar 10, 2017Vehicle speed control. Noise In Front Of Vehicle When Accelerating Or Decelerating This bulletin involves replacing both front half shafts. The customer may describe a clunk type noise in front of the vehicle while accelerating or decelerating.
• 10139978Mar 8, 2017Seat belts. Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
• 10139985Mar 1, 2017Seat belts. Restraints Information Sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
• 10121876Nov 18, 2016Electrical system. Flash: BCM Diagnostic And System Improvements This bulletin involves reprogramming the Body Control Module (BCM) with the latest available software. The customer may describe one or more of the following: When ParkSense is turned off, the LED on the switch will turn on indicating the system is disabled. On the next key cycle the system is still disabled, but the LED on the switch will not turn on.
• 10121872Nov 16, 2016Electrical system. Flash: Engine Does Not Start at The First Attempt This bulletin involves upgrading the software in the Electronic Steering Lock (ESL) Module. The customer may experience malfunction on first attempt to start the vehicle. Initial cranking is inhibited but should start/crank on the second attempt. Upon further inspection the technician may find Diagnostic Trouble Code (DTC) B1000-01 - Electronic Control Unit…
• 10121866Nov 15, 2016Electrical system. Flash: Park Assist Module (PAM) Enhancements This bulletin involves reprogramming the PAM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination.
• 10218055Nov 4, 2016Electrical system. This bulletin involves reprogramming the Amplifier (AMP) with the latest available software.
• 10215089Nov 4, 2016Electrical system, Equipment. This bulletin involves reprogramming the Amplifier (AMP) with the latest available software.
• 10121858Nov 4, 2016Transmission and drivetrain. Transmission Shift And Drivability Enhancements For P0901-00. This bulletin involves performing transmission harness replacement per S55 recall.Both the PCM and TCM must be up to date for these changes to be effective after the transmission harness repair. Customers may experience a Malfunction Indicator Lamp (MIL) illumination after S55 recall TCM flash has been performed.
• 10223850Sep 28, 2016Brakes, Electrical system. Flash: ABS Module Electronic Parking Brake Enhancements This bulletin involves reprogramming the Anti-lock Brake System (ABS) module with the latest available software. The customer may describe: The Electronic Parking Brake (EPB) does not disengage when accelerating while the "Auto Apply" feature is selected. The EPB does not engage with the ?Auto Apply? feature selected. The key may get stuck in the ignition key…
• 10223846Sep 27, 2016Electrical system, Transmission and drivetrain. Flash: Transmission Shift And Drivability Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. A small number of customers may experience the vehicle doesn?t pass back into drive mode when choosing to change gears using the paddle shifters.
• 10223841Sep 24, 2016Visibility (wipers, defrost, mirrors). Creaks, Rattles, Squeaks Or Seal Gaps From My Sky Roof Panels This bulletin involves performing various repair procedures to the My Sky roof panels. Some customers may describe various noises coming from the My Sky roof panels, handle, or latch, as well as seal gaps between the panels.
• 10223837Sep 21, 2016Transmission and drivetrain. Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following DTCs set in the TCM memory: P061B - Internal Control Module Torque Calculation Performance…
• 10223835Sep 17, 2016Visibility (wipers, defrost, mirrors). Water Leak On Right Front Floorboard This bulletin involves securing the condensation drain tube to the HVAC housing. Customers may experience a water leak on the right front floorboard inside the vehicle while using the climate controls or Heating Ventilation Air Conditioning (HVAC).
• 10223855Sep 7, 2016Visibility (wipers, defrost, mirrors). Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform the this inspection. Inspect the sensor for a fluid coating on the sensor pins. Orange colored rain repellant can cause this fluid build-up. Clean the pins, drain the reservoir, and fill with Mopar approved washer fluid. Check to determine if the issue has…
• 10121740Aug 31, 2016Visibility (wipers, defrost, mirrors). Windshield For Jeep Renegade (BU) windshields that exhibit imperfections such as stress cracking, inclusions/bubbles, scratches, or distortions, please contact: Chuck Hood at cell (248) 613-7591 If no response in 15 minutes, proceed with repair.
• 10121723Aug 31, 2016Transmission and drivetrain, Equipment. 948TE 9 Speed Transmission Quick Learn Procedure This bulletin provides information on how to perform the new scan tool based transmission Quick Learn procedure. This procedure is required after certain transmission repairs or to improve a customer?s concern of poor shift quality. Customers may indicate that their transmission shift quality may be erratic.
• 10224873Aug 24, 2016Transmission and drivetrain, Electrical system. RF Hub Module DTC, U1765-87 "RFHM (Radio Frequency Hub Module) - Missing Message" may appear in a stored state on a ignition power cycle. No troubleshooting or parts replacement is necessary if this code is stored as the system is functioning to design.
• 10224863Aug 24, 2016Vehicle speed control, Electrical system, Air bags, Seat belts, Body and…. Flash: BCM Diagnostic And System Improvements This bulletin involves reprogramming the Body Control Module (BCM) with the latest available software. The customer may describe one or more of the following: · **Rear interior overhead lamps remain illuminated after exiting vehicle and locking from the driver's or passenger's door lock buttons. This is causing the vehicle battery to go dead.** · The door locks are…
• 10194278Aug 24, 2016Equipment, Transmission and drivetrain. Powertrain diagnostic and system improvements.
• 10130086Aug 24, 2016Equipment. RF Hub Module DTC, U1765-87 "RFHM (Radio Frequency Hub Module) - Missing Message" may appear in a stored state on a ignition power cycle. No troubleshooting or parts replacement is necessary if this code is stored as the system is functioning to design.
• 10130076Aug 24, 2016Latches, locks and linkages, Electrical system, Interior lighting, Equipment. Flash: BCM Diagnostic And System Improvements This bulletin involves reprogramming the Body Control Module (BCM) with the latest available software. The customer may describe one or more of the following: · **Rear interior overhead lamps remain illuminated after exiting vehicle and locking from the driver's or passenger's door lock buttons. This is causing the vehicle battery to go dead.** · The door locks are…
• 10228154Aug 10, 2016Engine cooling. Multi-Air Actuator Assembly For 2.4 Tigershark Engine ONLY: When attempting to diagnose P Codes related to the MultiAir Unit, please note that there are multiple causes listed for each in the diagnostic procedure. This procedure must be followed to ensure the correct condition is being addressed.
• 10228146Aug 10, 2016Visibility (wipers, defrost, mirrors). Creaks, Rattles, Squeaks Or Seal Gaps From My Sky Roof Panels This bulletin involves performing various repair procedures to the My Sky roof panels. Some customers may describe various noises coming from the My Sky roof panels, handle, or latch, as well as seal gaps between the panels.
• 10220270Aug 10, 2016Engine cooling. Multi-Air Actuator Assembly For 2.4 Tigershark Engine ONLY: When attempting to diagnose P Codes related to the MultiAir Unit, please note that there are multiple causes listed for each in the diagnostic procedure. This procedure must be followed to ensure the correct condition is being addressed.
• 10220262Aug 10, 2016Visibility (wipers, defrost, mirrors). Creaks, Rattles, Squeaks Or Seal Gaps From My Sky Roof Panels This bulletin involves performing various repair procedures to the My Sky roof panels. Some customers may describe various noises coming from the My Sky roof panels, handle, or latch, as well as seal gaps between the panels.
• 10140198Aug 10, 2016Engine cooling. Multi-Air Actuator Assembly For 2.4 Tigershark Engine ONLY: When attempting to diagnose P Codes related to the MultiAir Unit, please note that there are multiple causes listed for each in the diagnostic procedure. This procedure must be followed to ensure the correct condition is being addressed.
• 10140190Aug 10, 2016Visibility (wipers, defrost, mirrors). Creaks, Rattles, Squeaks Or Seal Gaps From My Sky Roof Panels This bulletin involves performing various repair procedures to the My Sky roof panels. Some customers may describe various noises coming from the My Sky roof panels, handle, or latch, as well as seal gaps between the panels.
• 10119600Aug 3, 2016Visibility (wipers, defrost, mirrors). Windshield Please contact Chuck Hood at cell (248) 613-7591 regarding BU & FB windshields that exhibit imperfections such as stress cracking, inclusions/bubbles, scratches, or distortions. If no response in 15 minutes, proceed with repair.
• 10119608Aug 1, 2016Wheels. Customer Satisfaction Notification R73 Wheel Stud Wrench The wheel stud wrench on about 11,700 of the above vehicles may break during use due to a non-compliant heat treatment process causing the material hardness to be out of specification. The wheel stud wrench must be replaced on the affected vehicles.
• 10221557Jul 27, 2016Electrical system, Transmission and drivetrain, Body and structure, Vehicle…. Seat Relay For a Jeep Renegade or Fiat 500X ONLY, if the driver's power seat will not move in any axis and the key is in the on position with the door open: 1. Please take a Vehicle Scan Report, taking note of any active or stored DTC's, especially in the Body Control Module (BCM). 2. Before replacing the relay, call Rick Gordon at cell (248) 630-6281. If no answer leave a message and if after 15 minutes, there is…
• 10136539Jul 27, 2016Seats. Seat Relay For a Jeep Renegade or Fiat 500X ONLY, if the driver's power seat will not move in any axis and the key is in the on position with the door open: 1. Please take a Vehicle Scan Report, taking note of any active or stored DTC's, especially in the Body Control Module (BCM). 2. Before replacing the relay, call Rick Gordon at cell (248) 630-6281. If no answer leave a message and if after 15 minutes, there is…
• 10121697Jul 20, 2016Electrical system, Equipment. Flash: Amplifier Audio Enhancement This bulletin involves updating the amplifier (AMP) software. The customer may notice a poor audio quality. This condition may happen when the audio volume is at a mid to high output.
• 10121683Jul 20, 2016Engine cooling. 3.2L - 3.6L Cylinder Head Assy Multiple cylinder head replacement. If cylinder head is replaced on a vehicle more than 1 time for any reason, please call any of the following people.~ First: Ron Dallison ? Cell (248) 292-9510 [email protected] ~ Second: Joe Lovell - Cell (734) 309-6467 [email protected]~ If a response is not received within 15 mins, then proceed with the necessary repair.
• 10121682Jul 16, 2016Equipment, Electrical system. RA4 RG4 RJ4 Radio Enhancements This bulletin involves updating the radio software. Customers may experience one or more of the following: · **Uconnect Apps are missing (16 MY BU, RRT portion, US market only). · Unable to register Uconnect (16 MY BU, RRT portion, US market only). · Assist button on App is missing (16 MY BU, RRT portion, US market only).** · Character missing on the keyboard with Cyrillic alphabet…
• 10080521Jun 30, 2016Equipment, Electrical system. "ra4 rg4 rj4 radio enhancements this bulletin involves updating the radio software. Customers may experience one or more of the following: · **character missing on the keyboard with cyrillic alphabet (for eu market only). · time of arrival nav settings not saved over key-cycle (for eu market only). · audio off delayed when pressing on/off button (for eu market only). · digital audio broadcast (dab) button missing…

← All problems reported for the 2015 Jeep Renegade