2016 Jeep Renegade Technical Service Bulletins

355 technical service bulletins (TSBs) are on record for the 2016 Jeep Renegade. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10220078Nov 2, 2019Equipment, Electrical system. RA3 and RA4 GPS Radio Update This bulletin involves updating the radio software. 18.01.35 (BU Vehicles)
• 10169226Nov 2, 2019Equipment. RA3 and RA4 GPS Radio Update This bulletin involves updating the radio software. 18.01.35 (BU Vehicles)
• 10220071Nov 1, 2019Engine cooling. wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK
• 10169219Nov 1, 2019Engine, Fuel system. wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK
• 10168489Oct 26, 2019Electrical system, Transmission and drivetrain. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following Diagnostic Trouble Codes (DTCs) have been set:P0300-00 - Multiple Cylinder Misfire. P0301-00 - Cylinder 1 Misfire. P0302-00…
• 10168429Oct 18, 2019Engine cooling. Revised Customer Satisfaction Notification V54 Engine Cooling Fan
• 10166598Aug 28, 2019Equipment, Electrical system. Flash Over The Air (FOTA) Software Update RA3 and RA4 Radio This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update.
• 10166537Aug 7, 2019Equipment. RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Please verify that the radio part number and/or serial number is not "FFFF". If either field shows "FFFF", please contact Mike Wielgat at 248-576-6696 or Rohan Negandhi at 248-421-9608 If no response in 15 minutes, proceed with repair.
• 10162532May 3, 2019Transmission and drivetrain. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Some customers may experience the following condition:When pressing the SPORT button on the console, the SPORT mode is not activated. Hard to start condition at low temperatures 10-15°C (50-60°F) and filled with 70~80% ethanol fuel (DF7 Transmission Sales Code only). Engine experiencing a…
• 10217505Nov 29, 2017Suspension, Electrical system. Creak/Rattle Noise Heard From Front Suspension This bulletin involves installing a protective sleeve in the front coil springs suspension. The customer may notice a creaking or rattle noise from the front of the vehicle while driving over bumps or rough roads.
• 10216324Nov 29, 2017Equipment, Suspension. Creak/Rattle Noise Heard From Front Suspension This bulletin involves installing a protective sleeve in the front coil springs suspension. The customer may notice a creaking or rattle noise from the front of the vehicle while driving over bumps or rough roads.
• 10217502Nov 22, 2017Transmission and drivetrain, Electrical system. Flash: Drivetrain Control Module (DTCM) Diagnostic and System Improvements This bulletin involves reprogramming the DTCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following DTCs:C2502-64 - Signal Plausibility Failure. C2210-92 - ETM Hall Sensor Performance Or Incorrect Operation…
• 10216321Nov 22, 2017Electrical system, Exterior lighting, Equipment. Flash: Drivetrain Control Module (DTCM) Diagnostic and System Improvements This bulletin involves reprogramming the DTCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following DTCs:C2502-64 - Signal Plausibility Failure. C2210-92 - ETM Hall Sensor Performance Or Incorrect Operation…
• 10217496Nov 9, 2017Transmission and drivetrain. Flash: Transmission Diagnostic and Shift Enhancements AN-BQ-21-20171106 Refer to China Joint Venture (JV) released document AN-BQ-21-20171106, for details on this service action.
• 10216315Nov 9, 2017Transmission and drivetrain, Equipment. Flash: Transmission Diagnostic and Shift Enhancements AN-BQ-21-20171106 Refer to China Joint Venture (JV) released document AN-BQ-21-20171106, for details on this service action.
• 10217443Nov 1, 2017Transmission and drivetrain. Fan Module, Radiator Cooling Before replacing the fan engine cooling fan replacement 68360299A$ for vehicles built after Oct. 20, 2016 please call Josh Langmesser @ cell (248) 821-5946. If a response is not received within 15 minutes, proceed with the necessary repair.
• 10216102Nov 1, 2017Equipment, Engine cooling. Fan Module, Radiator Cooling Before replacing the fan engine cooling fan replacement 68360299A$ for vehicles built after Oct. 20, 2016 please call Josh Langmesser @ cell (248) 821-5946. If a response is not received within 15 minutes, proceed with the necessary repair.
• 10224947Oct 24, 2017Engine cooling, Transmission and drivetrain. Flash: Powertrain Diagnostic and System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following DTCs have been set:P1523-00 - VVA Low Oil Pressure. P1524-00 - Oil Pressure Out Of Range - Camshaft Advance/Retard…
• 10224889Oct 11, 2017Equipment. A/C Plumbing Line, TXV, A/C Condenser For BU models ONLY: A/C components leaking. Before replacing any of the A/C part numbers listed, call: Viraj Vartak at cell phone: (248) 512-3859. If no response in 15 minutes, please proceed with repair.
• 10224932Oct 6, 2017Back-over prevention (rear camera). RA2 RJ2 RG2 RL2 and RM2 Radio Enhancements This bulletin involves updating the radio with the latest available software. The customer may notice one of the following:The parking sensor (warning chime) is still audible after the key is in the off position(EMEA and APAC Only). The radio re-boots if more than five favorite presets are set for each category (i.e. Sport or Rock)(RA2 Sales Code Only). Emergency number…
• 10224931Oct 5, 2017Back-over prevention (rear camera). Flash: Powertrain Diagnostic and System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with thelatest available software. Customers may experience a ticking noise coming from the top of the engine area. The ticking noise is heard particularly at idle.
• 10224928Oct 4, 2017Visibility (wipers, defrost, mirrors), Body and structure. Front My Sky Panel Unable To Be Manually Removed From Vehicle This bulletin involves applying weather strip lubricant to the front My Sky roof panel seal. Some customers may describe that the My Sky opens and vents without issue. When the My Sky front panel is unlatched it does not release - panel is stuck in placeFig. 1.Panel That May Be Stuck1 - Panel That May Be Stuck
• 10121794Sep 14, 2017Electrical system, Transmission and drivetrain. Flash: Transmission Diagnostic and Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one of the following DTCs have been set:P0887 - TCM Power Control Circuit High. P061B - Internal Control Module Torque…
• 10223681Jul 27, 2017Body and structure. Paint Delamination On Front Door Panel Pull Cups (Door Pulls). The customer may describe paint peeling on the left, right, or both front door panel pull cups.
• 10223720Jul 26, 2017Engine cooling. Cover Kit Please note that if you are attempting to get the cover kit and it is not available the gasket is available as a separate part number in the kit which is 04753095AB.
• 10223676Jul 26, 2017Transmission and drivetrain. Flash: Transmission Diagnostic and Shift Enhancements AN-BQ-21-20170724.
• 10223678Jul 20, 2017Visibility (wipers, defrost, mirrors). Front My Sky Panel Unable To Be Manually Removed From Vehicle This bulletin involves applying weather strip lubricant to the front My Sky roof panel seal. Some customers may describe that the My Sky opens and vents without issue. When the My Sky front panel is unlatched it does not release - panel is stuck in placeFig. 1.Panel That May Be Stuck1 - Panel That May Be Stuck
• 10223667Jul 12, 2017Transmission and drivetrain. Flash: Transmission Diagnostic and Shift Enhancements AN-BQ-21-20170709.
• 10138863Jun 21, 2017Engine cooling. Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter Adapter (OFA) due to a leak detected between OFA and block, an O-ring kit (68191356AA) is now available to repair OFA/Block Interface leaks. Using dye will assist in determining source of leak. Ensure OFA Cap Oring is seated in the proper groove in the cap and not damaged or cut. Engineering is seeking…
• 10219831Jun 14, 2017Vehicle speed control. Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. P2122 and P2127 will set if accelerator pedal connector is disconnected during diagnosis. Make sure codes are active before replacing pedal. DTC P2299 is usually caused by a two footed driver and accelerator pedal should not be replaced for this fault.
• 10138856Jun 14, 2017Vehicle speed control. Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. P2122 and P2127 will set if accelerator pedal connector is disconnected during diagnosis. Make sure codes are active before replacing pedal. DTC P2299 is usually caused by a two footed driver and accelerator pedal should not be replaced for this fault.
• 10219830Jun 7, 2017Visibility (wipers, defrost, mirrors). Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the bottle anti-rotation features that surround the SENSOR. Check to determine if the issue has been resolved. Continue with repair if necessary. Please contact Chris Koch at cell (248)…
• 10138855Jun 7, 2017Visibility (wipers, defrost, mirrors). Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the bottle anti-rotation features that surround the SENSOR. Check to determine if the issue has been resolved. Continue with repair if necessary. Please contact Chris Koch at cell (248)…
• 10219867Jun 1, 2017Electrical system. Flash: BCM Diagnostic and System Improvements This bulletin involves reprogramming the Body Control Module (BCM) with the latest available software. Some customers may experience the following condition:When activating the door locks by the remote control and then using the key to open the door directly, the theft warning light flashes on the cluster.
• 10138892Jun 1, 2017Electrical system. Flash: BCM Diagnostic and System Improvements This bulletin involves reprogramming the Body Control Module (BCM) with the latest available software. Some customers may experience the following condition:When activating the door locks by the remote control and then using the key to open the door directly, the theft warning light flashes on the cluster.
• 10217524Mar 29, 2017Body and structure. Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Replacing it unnecessary and is an over-repair.
• 10139992Mar 29, 2017Body and structure. Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Replacing it unnecessary and is an over-repair.
• 10217574Mar 22, 2017Electrical system. Flash: Powertrain Diagnostic And System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software.
• 10140042Mar 22, 2017Electrical system, Transmission and drivetrain. Flash: Powertrain Diagnostic And System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software.
• 10217571Mar 18, 2017Transmission and drivetrain, Exterior lighting, Electrical system. Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs): U1412-00 - Implausible Vehicle Speed Signal…
• 10217570Mar 18, 2017Lane departure, Electrical system. Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. The following improvements are included in this update: Catalyst protection improvement. Purge improvement to open purge solenoid more when purge concentration is low. Oil temperature warning limit change.
• 10140039Mar 18, 2017Transmission and drivetrain, Electrical system. Flash: Transmission Diagnostic And Shift Enhancements This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs): U1412-00 - Implausible Vehicle Speed Signal…
• 10140038Mar 18, 2017Electrical system, Transmission and drivetrain. Flash: Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. The following improvements are included in this update: Catalyst protection improvement. Purge improvement to open purge solenoid more when purge concentration is low. Oil temperature warning limit change.
• 10217567Mar 17, 2017Visibility (wipers, defrost, mirrors). Front My Sky Panel Unable To Be Manually Removed From Vehicle This bulletin involves applying weather strip lubricant to the front My Sky roof panel seal. .1 - Panel That May Be Stuck
• 10140035Mar 17, 2017Visibility (wipers, defrost, mirrors). Front My Sky Panel Unable To Be Manually Removed From Vehicle This bulletin involves applying weather strip lubricant to the front My Sky roof panel seal. .1 - Panel That May Be Stuck
• 10217521Mar 15, 2017Fuel system. Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 [email protected], or Joe Lovell (734) 309-6467 [email protected] before proceeding. If unable to reach after 15 minutes record the following information and proceed with oil pump…
• 10139989Mar 15, 2017Engine cooling. Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 [email protected], or Joe Lovell (734) 309-6467 [email protected] before proceeding. If unable to reach after 15 minutes record the following information and proceed with oil pump…
• 10217556Mar 10, 2017Back-over prevention (rear camera). Noise In Front Of Vehicle When Accelerating Or Decelerating This bulletin involves replacing both front half shafts. The customer may describe a ?clunk type? noise in front of the vehicle while accelerating or decelerating.
• 10140024Mar 10, 2017Vehicle speed control. Noise In Front Of Vehicle When Accelerating Or Decelerating This bulletin involves replacing both front half shafts. The customer may describe a clunk type noise in front of the vehicle while accelerating or decelerating.
• 10139978Mar 8, 2017Seat belts. Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.

← All problems reported for the 2016 Jeep Renegade