2015 Kia Forte Technical Service Bulletins

146 technical service bulletins (TSBs) are on record for the 2015 Kia Forte. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10109812Jan 18, 2017Equipment. TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners, which are designed to lock into place once fully attached, are utilized in various Kia models and are strictly intended for ?one time use.? Some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking…
• 10109769Nov 30, 2016Visibility (wipers, defrost, mirrors). TSB: COMBINED TSB / SERVICE ACTION: REAR DOOR WINDOW MOTOR REPLACEMENT (SA260) - This bulletin describes the procedure to replace both rear door power window motors on some 2014-15MY Forte (YD) vehicles, produced from February 1, 2013 through January 5, 2015, which may exhibit an inoperable rear door power window(s).
• 10109777Nov 4, 2016Equipment, Latches, locks and linkages. TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners utilized in various Kia models are strictly intended for ?one time use?. Though not limited to the following, some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking adhesives.?
• 10109788Oct 31, 2016Equipment, Electrical system. TSB: INHIBITOR SWITCH DIAGNOSIS INFORMATION - This bulletin gives information regarding the steps to take regarding the diagnosis of the Inhibitor Switch.
• 10090945Sep 30, 2016Equipment. Pitstop: hvac receiver/dryer - desiccant replacement - in the event of a hvac system concern in which metal particles or shards have contaminated the system, the desiccant or the entire a/c receiver/dryer assembly may need to be replaced. This is due to the fact that it may be impossible to remove all metal contaminants from the receiver/dryer during the a/c flushing procedure. Refer to the included table for…
• 10089389Sep 21, 2016Engine. Tsb: engine vibration at idle - this bulletin provides the procedure to replace the alternator pulley. Some 2014-16my forte (yd) vehicles with 1.8l and 2.0l nu engines may experience an unusual engine vibration at idle that is sometimes more prevalent under certain electrical loads. To correct this concern, replace the existing alternator pulley with a new one following the service procedure in this bulletin.
• 10090965Sep 2, 2016Suspension. Pitstop: clicking noise from front suspension - some 2014-2016my forte (yd) vehicles may exhibit a clicking type noise from the front suspension when carrying a full load of passengers and turning the wheel in either direction at low speeds; such as in a parking lot situation or when pulling into steeply inclined driveway.
• 10089302Jun 29, 2016Electrical system, Engine. Tsb: combined tsb /service action: mil on with dtc c1212 logic improvement (sa216) - this bulletin provides information related to the ecm software upgrade of some 2014~2015my forte (yd), produced from december 7, 2013 to april 16, 2015, and some 2014my sportage (sl) vehicles, produced from april 4, 2013 through june 18, 2014, which may exhibit a malfunction indicator light (mil) on with dtc c1212.
• 10089303Jun 23, 2016Electrical system. Tsb: uvo software upgrade - media button inoperative - this bulletin provides the procedure for upgrading the uvo system of some 2014~2015my sportage (sl), forte (yd), optima (tf/qf), optima hybrid (tf hev) and sorento (xma) vehicles, which may exhibit an inoperative uvo media button.
• 10089312Jun 8, 2016Electrical system. Combination tsb / service action: uvo system upgrade (sa222) - this bulletin provides the procedure for upgrading the uvo system on some 2014~2016my soul (ps), sorento (xma)/(uma), optima (tf hev), forte (yd), sportage (sl) 2015~2016my sedona (yp), and 2014-2015(my) optima (qt/tf) vehicles to address “incoming ring volume too loud” complaints when using certain smartphones (non-iphone).
• 10079900Apr 28, 2016Equipment, Body and structure. Pitstop: frameless window short drop feature inoperative - some forte koup (yd) vehicles, produced before october 1, 2014, may experience difficulty when opening/closing the doors in freezing temperatures, due to the operation of the short drop feature as a result of frost/ice build-up between the window glass and outside belt molding.
• 10183433Apr 21, 2016Electrical system, Equipment. TSB - COMBINATION TSB / SERVICE ACTION: UVO SYSTEM UPGRADE (SA222) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure for upgrading the UVO system on some 2014~2016MY Soul (PS), Sorento (XMa), Optima (TF/QF), Forte (YD) and Sportage (SL) vehicles to address "Incoming ring…
• 10079901Apr 21, 2016Equipment, Electrical system. Combination tsb / service action: uvo system upgrade (sa222) - this bulletin provides the procedure for upgrading the uvo system on some 2014~2016my soul (ps), sorento (xma), optima (tf/qf), forte (yd) and sportage (sl) vehicles to address “incoming ring volume too loud” complaints when using certain smartphones (non-iphone). Additionally, in 2014my vehicles the upgrade will also improve bluetooth connectivity and…
• 10183431Apr 4, 2016Equipment, Electrical system. TSB - USE OF AFTERMARKET USB CHARGING CABLES IN USB/12V PORTS - This article provides information regarding the use of USB ports and 12V power outlets to connect/charge mobile phones.
• 10091942Mar 2, 2016Exterior lighting, Equipment. On some 2014-2015 my forte vehicles, customers may complain about water droplets forming inside the rear tail lamp lenses following a rainstorm or after washing their vehicle. These water droplets are more visible at night and the quantity of water present is more than just a thin film of condensation which may not easily evaporate. This concern is caused by a gap between the tail lamp housing gasket and vehicle…
• 10089463Mar 2, 2016Body and structure, Equipment, Exterior lighting. Tsb: water leak/condensation in rear combination tail lamp(s) - on some 2014~2015my forte (yd) vehicles, customers may complain about water droplets forming inside the rear tail lamp lenses following a rainstorm or after washing their vehicle. These water droplets are more visible at night and the quantity of water present is more than just a thin film of condensation which may not easily evaporate.
• 10079963Feb 12, 2016Electrical system. Combined tsb/service action: mil on with dtc c1212 - logic improvement (sa216) - this bulletin provides information related to the ecm software upgrade of some 2014~2015my forte (yd), produced from december 7, 2013 to april 16, 2015, and some 2014my sportage (sl) vehicles, produced from april 4, 2013 through june 18, 2014, which may exhibit a malfunction indicator light (mil) on with dtc c1212.
• 10080084Jan 29, 2016Back-over prevention (rear camera). Tsb: rear view camera diagnosis/replacement - this bulletin provides information to diagnose and/or replace the rear view camera of some kia vehicles (see table on pg. 6 for specific models and production dates) which may exhibit inadequate image quality from the rear view camera. Diagnose the concerns using the information in this bulletin and, if necessary, replace the rear view camera with an improved part by…
• 10088983Oct 19, 2015Electrical system. Tsb: kds - audio update module (aum) - the gds audio update module (aum) was introduced in fourth quarter of 2013. This special service tool (sst) was developed to improve the efficiency and effectiveness of updating 2010my, and later, kia audio head units using a gds, and now, the same functionality is available on kds. Some technicians may not be aware of the benefits the aum tool has to offer.
• 10089047Oct 9, 2015Equipment. Simplified uvo e-services activation procedure - this article outlines the simplified activation procedure for vehicles equipped with uvo e-services. (excluding 2016 k900 and soul ev)
• 10089022Oct 6, 2015Equipment. Pre-delivery inspection (pdi) and owner delivery folder program - all models excluding k900 and soul ev -kia motors america, inc. Is pleased to announce the launch of an all-new pre-delivery inspection (pdi) and owner delivery folder program which has been redesigned to improve initial vehicle quality during pdi and also during delivery to your customer
• 10089051Sep 29, 2015Engine. Tsb: proper oil grade / viscosity selection for turbo equipped vehicles - this bulletin provides information related to the proper engine oil grade / viscosity to be used when servicing vehicles equipped with a turbocharger.
• 10116821Aug 12, 2015Equipment, Electrical system. TSB: IDENTIFYING HEAD UNIT SOFTWARE VERSION FOR DIRECT EXCHANGE - Identifying Head Unit Software Version For Direct Exchange (ELE091) (Rev 1) - This bulletin provides the procedure on how to identify and record the head unit software level on various head unit platforms and generations. This procedure will now be required when ordering head units through the Direct Exchange Program (see Parts Bulletin 91-961-0005).
• 10089354Aug 12, 2015Electrical system. Tsb: identifying head unit software version for direct exchange - this bulletin provides the procedure on how to identify and record the head unit software level on various head unit platforms and generations. This procedure will now be required when ordering head units through the direct exchange program.
• 10089382Aug 3, 2015Transmission and drivetrain. Tsb: 6-spd. A/t adaptive value reset /relearn - this bulletin provides the procedures necessary to reset and relearn the adaptive values after transmission replacement or reprogramming/replacement of the pcm/tcm. After the adaptive values are reset, the transmission computer adaptive values must be relearned by driving in a precise manner to “teach” the computer the proper solenoid duty and line pressure for the…
• 10089615Jul 14, 2015Electrical system. Tsb: “c” state error message on version 8.5 map update - this bulletin describes an sd card replacement procedure for customers that have a specific error displayed on the navigation head unit (shown below) after purchasing and installing a version 8.5 map update sd card. A total of 129 affected sd cards were purchased by customers through kia dealers, from january 1st to may 11th, 2015.
• 10089617Jul 1, 2015Engine, Electrical system. Tsb: data collection: extract california emissions data from ecu (dc1501) - this bulletin provides information related to extracting “in use performance tracking” emissions data from the engine control unit (ecu) of certain vehicles sold in california. The california air resources board (carb) requires the emissions data from vehicles with a minimum of 3,000 accumulated miles without reprogramming or resetting.
• 10058534Jul 1, 2015Engine. Kia: crankshaft position sensor (ckp) variation has not learned causing misfire of engine and malfunction indicator light (mil) to come in dash. Model all. No years listed.
• 10092132Jun 26, 2015Electrical system, Equipment. Tsb: navigation head unit sd card replacement - this bulletin describes the sd card exchange/replacement procedure related to error messages that may be displayed on the navigation screen when the incorrect sd card is inserted. Note: only new models (during pdi inspection or at the point of purchase) or compatibility mismatches that occur after head unit replacement will be considered for this program.
• 10089742Jun 26, 2015Equipment, Electrical system. Tsb: navigation head unit sd card replacement - this bulletin describes the sd card exchange/replacement procedure related to error messages that may be displayed on the navigation screen when the incorrect sd card is inserted. Note: only new models (during pdi inspection or at the point of purchase) or compatibility mismatches that occur after head unit replacement will be considered for this program.
• 10092147Jun 1, 2015Transmission and drivetrain. Tsb: 6 spd a/t solenoid replacement – multiple dtcs - this bulletin provides information relating to the replacement of various shift solenoids on 6-speed automatic transaxles with dtcs p0741, p0743, p0748, p0753, p0758, p0763, p0768, p0773, p1778 and p2709. Replace the solenoids if current or history codes are present; do not replace the transaxle. To reduce vehicle repair time, this procedure can be performed…
• 10089761Jun 1, 2015Transmission and drivetrain. Tsb: 6 spd a/t solenoid replacement – multiple dtcs - this bulletin provides information relating to the replacement of various shift solenoids on 6-speed automatic transaxles with dtcs p0741, p0743, p0748, p0753, p0758, p0763, p0768, p0773, p1778 and p2709. Replace the solenoids if current or history codes are present; do not replace the transaxle. To reduce vehicle repair time, this procedure can be performed…
• 10089821May 26, 2015Equipment, Electrical system. Tsb: service action: uvo system upgrade (sa193) - this bulletin provides the procedure for upgrading the uvo system on some 2014my forte (yd) vehicles, produced from june 1, 2013 through december 31, 2013, as part of a kia /j.d. Power pilot improvement project for acen (audio communication entertainment and navigation). The purpose of the software upgrade in this pilot is to validate the effectiveness of changes to…
• 10089825May 13, 2015Equipment, Electrical system. Tsb: uvo software upgrade – media button inoperative - this bulletin provides the procedure for upgrading the uvo system of some 2014~2015my sportage (sl), forte (yd), optima (tf/qf), optima hybrid (tf hev) and sorento (xma) vehicles, which may exhibit an inoperative uvo media button.
• 10089987Apr 24, 2015Engine, Vehicle speed control. Pitstop: smart pedal feature - the “smart pedal” is an integral part of the engine management system (ems) functionality which monitors and prevents the simultaneous activation of accelerator and brake pedals. When engaged, the feature reduces engine power to idle.
• 10089953Apr 10, 2015Tires, Equipment. Tsb: tpms sensor replacement - this bulletin provides the procedure to replace the tpms sensors on some 2014~2015my forte (yd) vehicles, produced from february 18, 2013 through march 31, 2015, which may exhibit a tpms light illuminated in the cluster, along with dtc c1212 – vehicle speed sensor. To correct this concern, replace all four (4) tpms sensors with the improved parts, by following the procedure outlined…
• 10092100Mar 27, 2015Equipment, Electrical system. Pitstop: bluetooth® issues after iphone® ios 8 software update - this article provides information related to possible bluetooth concerns when using an iphone® with ios 8.x (ios 8, 8.0.1, 8.0.2, 8.1, 8.1.2, 8.1.3, etc.) while paired to a head unit.
• 10089783Feb 13, 2015Electrical system. Tsb: service action: uvo head unit replacement (sa184) - this bulletin provides the procedure to replace the uvo head unit on some of 2015my soul (ps), sportage (sl) sedona (yp) and forte (yd) vehicles, which may exhibit a condition in which the uvo audio head unit will intermittently not power up. To prevent and/or correct this condition, replace the audio head unit with a new one following the service procedure…
• 10109790Oct 14, 2014Electrical system, Fuel system. PITSTOP: NO START OR HARD TO START CONCERNS - Some 2014~2015MY Forte Koup / 5 DR equipped with a 1.6L GDI Turbo and produced before July 14, 2014, may experience a hard to start concern or idle rpm fluctuations while stationary. If you encounter any of these concerns, check for white residue build up in the High Pressure Fuel Pump Inlet (see image below) which may cause a restriction and loss of fuel volume to the…
• 10109787Oct 7, 2014Equipment. TSB: GENERAL INFORMATION AND DIAGNOSIS FOR SMART KEY FOB SYSTEMS AND START/STOP BUTTONS - This bulletin provides information related to the Smart Key Systems on vehicles equipped with A/T (automatic transaxle) and Start/Stop Buttons (SSB).
• 10057100Oct 1, 2014Engine. Kia: my forte 2014-2015 some models may experience a hard or no start while stationary.
• 10109761Sep 4, 2014Electrical system. PITSTOP: REMOTE START SYSTEM DIAGNOSTIC HOTLINE - When diagnosing remote start systems, refer to the table shown in this article for detailed information on applicable models, model year and system supplier; along with the applicable Hotline contact information and business hours.
• 10109666Jun 20, 2014Equipment. TSB: TESTING A/C COMPRESSOR FUNCTION USING GDS - This bulletin provides information on a new procedure to test A/C compressor function using the GDS.
• 10109652May 22, 2014Equipment. TSB: 6 SPD A/T SOLENOID REPLACEMENT ? DTC P0741 - This bulletin provides information relating to the replacement of the Damper Clutch (D/C) Solenoid on 6-speed automatic transaxles with DTC P0741 (active or history), instead of replacing the transaxle. To reduce vehicle repair time, this procedure can be performed with the transaxle installed in the vehicle.
• 10109655May 19, 2014Fuel system. PIT STOP: GDI INJECTOR SPRAY TIP DEPOSITS - A design feature of vehicles equipped with a Gasoline Direct Injection (GDI) system is the placement of each fuel injector directly into the engine cylinder head assembly. Therefore, it is completely normal for the combustion process to create deposits on the injector spray tip surfaces.
• 10090431May 29, 2013Transmission and drivetrain. Tsb: 6-speed a/t transmission adaptive values reset/relearn - this bulletin provides the procedures necessary to reset and relearn the adaptive values after transmission replacement or reprogramming/replacement of the ecm/pcm.

← All problems reported for the 2015 Kia Forte