2016 Kia Forte Technical Service Bulletins

122 technical service bulletins (TSBs) are on record for the 2016 Kia Forte. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10109813Jan 18, 2017Engine cooling. PITSTOP: MANUAL EVAPORATIVE EMISSIONS TEST FOR HARD TO FIND/SMALL LEAKS - If the malfunction indicator lamp (MIL) is illuminated with DTC(s) P0442, P0455, P0456, or P0457 (Evaporative Emissions System-Leak detected) and the evaporative (EVAP) leak self-test resulted in NTF, a manual EVAP test is recommended.
• 10109812Jan 18, 2017Equipment. TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners, which are designed to lock into place once fully attached, are utilized in various Kia models and are strictly intended for ?one time use.? Some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking…
• 10109775Nov 9, 2016Engine cooling. TSB: DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS DATA FROM ECU (DC16) - This bulletin provides information related to extracting ?in use performance tracking? emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California. The California Air Resources Board (CARB) requires the emissions data from vehicles with a minimum of 3,000 accumulated miles without reprogramming or resetting.
• 10109777Nov 4, 2016Equipment, Latches, locks and linkages. TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners utilized in various Kia models are strictly intended for ?one time use?. Though not limited to the following, some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking adhesives.?
• 10090945Sep 30, 2016Equipment. Pitstop: hvac receiver/dryer - desiccant replacement - in the event of a hvac system concern in which metal particles or shards have contaminated the system, the desiccant or the entire a/c receiver/dryer assembly may need to be replaced. This is due to the fact that it may be impossible to remove all metal contaminants from the receiver/dryer during the a/c flushing procedure. Refer to the included table for…
• 10089389Sep 21, 2016Engine. Tsb: engine vibration at idle - this bulletin provides the procedure to replace the alternator pulley. Some 2014-16my forte (yd) vehicles with 1.8l and 2.0l nu engines may experience an unusual engine vibration at idle that is sometimes more prevalent under certain electrical loads. To correct this concern, replace the existing alternator pulley with a new one following the service procedure in this bulletin.
• 10090965Sep 2, 2016Suspension. Pitstop: clicking noise from front suspension - some 2014-2016my forte (yd) vehicles may exhibit a clicking type noise from the front suspension when carrying a full load of passengers and turning the wheel in either direction at low speeds; such as in a parking lot situation or when pulling into steeply inclined driveway.
• 10089312Jun 8, 2016Electrical system. Combination tsb / service action: uvo system upgrade (sa222) - this bulletin provides the procedure for upgrading the uvo system on some 2014~2016my soul (ps), sorento (xma)/(uma), optima (tf hev), forte (yd), sportage (sl) 2015~2016my sedona (yp), and 2014-2015(my) optima (qt/tf) vehicles to address “incoming ring volume too loud” complaints when using certain smartphones (non-iphone).
• 10089311Jun 8, 2016Fuel system, Engine. Service action: hesitation, lack of power and/or check engine light on (sa227) - this bulletin provides the procedure to add a fuel additive to some 2016my forte (yd) vehicles, produced from april 1, 2015 through december 15, 2015, which may experience hesitation, lack of power and/or a check engine light on with possible mis-fire codes due to a temporary contamination in the fuel line.
• 10183433Apr 21, 2016Electrical system, Equipment. TSB - COMBINATION TSB / SERVICE ACTION: UVO SYSTEM UPGRADE (SA222) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure for upgrading the UVO system on some 2014~2016MY Soul (PS), Sorento (XMa), Optima (TF/QF), Forte (YD) and Sportage (SL) vehicles to address "Incoming ring…
• 10079901Apr 21, 2016Equipment, Electrical system. Combination tsb / service action: uvo system upgrade (sa222) - this bulletin provides the procedure for upgrading the uvo system on some 2014~2016my soul (ps), sorento (xma), optima (tf/qf), forte (yd) and sportage (sl) vehicles to address “incoming ring volume too loud” complaints when using certain smartphones (non-iphone). Additionally, in 2014my vehicles the upgrade will also improve bluetooth connectivity and…
• 10183431Apr 4, 2016Equipment, Electrical system. TSB - USE OF AFTERMARKET USB CHARGING CABLES IN USB/12V PORTS - This article provides information regarding the use of USB ports and 12V power outlets to connect/charge mobile phones.
• 10088983Oct 19, 2015Electrical system. Tsb: kds - audio update module (aum) - the gds audio update module (aum) was introduced in fourth quarter of 2013. This special service tool (sst) was developed to improve the efficiency and effectiveness of updating 2010my, and later, kia audio head units using a gds, and now, the same functionality is available on kds. Some technicians may not be aware of the benefits the aum tool has to offer.
• 10089047Oct 9, 2015Equipment. Simplified uvo e-services activation procedure - this article outlines the simplified activation procedure for vehicles equipped with uvo e-services. (excluding 2016 k900 and soul ev)
• 10089022Oct 6, 2015Equipment. Pre-delivery inspection (pdi) and owner delivery folder program - all models excluding k900 and soul ev -kia motors america, inc. Is pleased to announce the launch of an all-new pre-delivery inspection (pdi) and owner delivery folder program which has been redesigned to improve initial vehicle quality during pdi and also during delivery to your customer
• 10089051Sep 29, 2015Engine. Tsb: proper oil grade / viscosity selection for turbo equipped vehicles - this bulletin provides information related to the proper engine oil grade / viscosity to be used when servicing vehicles equipped with a turbocharger.
• 10116821Aug 12, 2015Equipment, Electrical system. TSB: IDENTIFYING HEAD UNIT SOFTWARE VERSION FOR DIRECT EXCHANGE - Identifying Head Unit Software Version For Direct Exchange (ELE091) (Rev 1) - This bulletin provides the procedure on how to identify and record the head unit software level on various head unit platforms and generations. This procedure will now be required when ordering head units through the Direct Exchange Program (see Parts Bulletin 91-961-0005).
• 10089354Aug 12, 2015Electrical system. Tsb: identifying head unit software version for direct exchange - this bulletin provides the procedure on how to identify and record the head unit software level on various head unit platforms and generations. This procedure will now be required when ordering head units through the direct exchange program.
• 10089382Aug 3, 2015Transmission and drivetrain. Tsb: 6-spd. A/t adaptive value reset /relearn - this bulletin provides the procedures necessary to reset and relearn the adaptive values after transmission replacement or reprogramming/replacement of the pcm/tcm. After the adaptive values are reset, the transmission computer adaptive values must be relearned by driving in a precise manner to “teach” the computer the proper solenoid duty and line pressure for the…
• 10092132Jun 26, 2015Electrical system, Equipment. Tsb: navigation head unit sd card replacement - this bulletin describes the sd card exchange/replacement procedure related to error messages that may be displayed on the navigation screen when the incorrect sd card is inserted. Note: only new models (during pdi inspection or at the point of purchase) or compatibility mismatches that occur after head unit replacement will be considered for this program.
• 10089742Jun 26, 2015Equipment, Electrical system. Tsb: navigation head unit sd card replacement - this bulletin describes the sd card exchange/replacement procedure related to error messages that may be displayed on the navigation screen when the incorrect sd card is inserted. Note: only new models (during pdi inspection or at the point of purchase) or compatibility mismatches that occur after head unit replacement will be considered for this program.
• 10089987Apr 24, 2015Engine, Vehicle speed control. Pitstop: smart pedal feature - the “smart pedal” is an integral part of the engine management system (ems) functionality which monitors and prevents the simultaneous activation of accelerator and brake pedals. When engaged, the feature reduces engine power to idle.

← All problems reported for the 2016 Kia Forte