2015 Kia Optima Technical Service Bulletins

200 technical service bulletins (TSBs) are on record for the 2015 Kia Optima. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10145157Aug 29, 2018Engine. PRODUCT IMPROVEMENT CAMPAIGN (PI1802) - WARRANTY BULLETIN - KMA launched Product Improvement Campaign PI1802A on July 25, 2018 to perform a software update on certain vehicles with 2.4L GDI engines to alert vehicle drivers at an early stage of bearing wear to prevent severe engine damage.
• 10144240Aug 27, 2018Engine cooling. TSB: PRODUCT IMPROVEMENT CAMPAIGN: KNOCK SENSOR DETECTION SYSTEM - ECU LOGIC IMPROVEMENT (PI1802) - This bulletin provides information related to a software update to the Engine Control Unit (ECU) to install the Knock Sensor Detection System (KSDS) in order to protect the engine from excessive connecting rod bearing damage.
• 10144238Aug 27, 2018Electrical system, Engine cooling. PRODUCT IMPROVEMENT CAMPAIGN: Dear Kia Optima Owner: Kia Motors America, Inc. is conducting an important Product Improvement Campaign to perform a software update on some 2014 MY Optima vehicles equipped with 2.4L Gasoline Direct Injection (?GDI?) engines, and all 2015 MY Optima vehicles equipped with 2.4L GDI and 2.0L Turbocharged GDI (?T-GDI?) engines to protect the engine from excessive connecting rod bearing…
• 10143404Jul 30, 2018Visibility (wipers, defrost, mirrors), Lane departure. PITSTOP - NO COMMUNICATION WITH BLIND SPOT DETECTION AFTER COLLISION REPAIRS - This Pitstop provides information relating to the vehicles listed below with Blind Spot Detection (BSD), which may exhibit a ?Check BSD System? message and no communication with the BSD system after collision repairs.
• 10143474Jul 25, 2018Equipment, Electrical system, Transmission and drivetrain, Engine. Q & A - This document is the Q & A for the new Product Improvement Campaign to provide information regarding a software update to the Engine Control Unit (ECU) to protect the engine from excessive connecting rod bearing damage.
• 10143472Jul 16, 2018Electrical system, Transmission and drivetrain, Engine. DEALER SERVICE MANAGER NOTICE - This notice advised the dealer service manager of the new Product Improvement Campaign to perform a software update to the Engine Control Unit (ECU) to protect the engine from excessive connecting rod bearing damage.
• 10143471Jul 16, 2018Electrical system, Engine. DEALER PRINCIPAL NOTICE - This notice advised the dealer principal of the new Product Improvement Campaign to perform a software update to the Engine Control Unit (ECU) to protect the engine from excessive connecting rod bearing damage.
• 10133178Mar 7, 2018Equipment. TSB - UVO SOFTWARE UPGRADE - This bulletin has been revised and is no longer a Service Action. This bulletin provides the procedure to upgrade the UVO software on some 2015MY Soul (PS), Sportage (SL), Optima (TF, QF), Forte (YD), and Sorento (XMa) vehicles to incorporate Bluetooth and Voice Recognition improvements.
• 10133177Mar 7, 2018Equipment. TSB - AUDIO SOFTWARE UPGRADE - This bulletin has been revised and is no longer a Service Action. This bulletin provides the procedure to upgrade the audio software on some 2015MY Soul (PS), Sportage (SL), Optima (TF, QF), Forte (YD), and Sorento (XMa) vehicles to incorporate Bluetooth and Voice Recognition improvements.
• 10133170Mar 2, 2018Engine cooling. PITSTOP - ENGINE COMPONENT RE-USE GUIDELINES - In general, parts and components removed during engine repairs should be considered serviceable, and should be thoroughly cleaned and transferred to the new engine.
• 10130104Feb 16, 2018Transmission and drivetrain. TSB - DRIVESHAFT SERVICEABILITY - This bulletin has been revised most recently to include additional information. This bulletin provides information regarding axle shaft serviceability for Kia vehicles equipped with a six-speed automatic transmission.
• 10127029Dec 13, 2017Fuel system, Transmission and drivetrain. TSB - SERVICE ACTION: TURBO OIL FEED LINE REPLACEMENT (SA300) - This bulletin provides the procedure to replace the turbo oil feed line on some 2011-2015MY Optima (TF), produced from November 1, 2010 through August 30, 2011, 2012-2015MY Optima (QF), produced from August 31, 2011 through October 2, 2015, and 2011-2015MY Sportage (SL) vehicles, produced from December 30, 2010 through November 6, 2015, equipped with…
• 10126423Nov 20, 2017Electrical system. TSB - IDENTIFYING HEAD UNIT SOFTWARE VERSION FOR DIRECT EXCHANGE - This bulletin provides the procedure on how to identify and record the head unit software level on various head unit platforms and generations.
• 10123322Oct 31, 2017Exterior lighting. TSB - OUTSIDE REAR COMBINATION LAMP WATER INTRUSION - This bulletin provides the procedure to replace the outside rear combination lamp pads on some 2011-2015MY Optima (TF), produced from August 12, 2010 through July 23, 2015, and some 2011-2016MY Optima (TF HEV) vehicles, produced from February 15, 2011 through July 22, 2015, which may exhibit evidence of water intrusion in the outside rear combination lamps.
• 10116101Jun 27, 2017Electrical system. PITSTOP: TPMS SENSOR POSITION - When diagnosing TPMS-related DTCs, make sure you are investigating the correct sensor. The TPMS positioning from the manufacturer may be different from the positioning shown on a KDS.
• 10116106Jun 21, 2017Electrical system. PITSTOP: UNABLE TO CONNECT TO UVO ESERVICES - This Pitstop provides information about customer complaints regarding: * ?Unable to connect to UVO eServices using an iPhone?, * ?Connection Error and unable to sync with the UVO App with my iPhone 7?
• 10109857May 1, 2017Lane departure, Forward collision avoidance. PITSTOP: NO COMMUNICATION WITH BLIND SPOT - This Pitstop provides information relating to 2014-2015MY Optima (QF) vehicles with Blind Spot Detection (BSD), which may exhibit a ?Check BSD System? message and no communication with the BSD system after collision repairs. This concern is commonly caused by the rear bumper harness installed backwards.
• 10109836Apr 17, 2017Equipment. TSB: UVO SYSTEM UPGRADE - This bulletin provides the procedure for upgrading the UVO system on some 2014-2016MY Soul (PS), Sorento (XMa)/(UMa), Optima (TF HEV), Forte (YD), Sportage (SL), 2015-2016MY Sedona (YP), and 2014-2015(MY) Optima (QF/TF) vehicles to address ?Incoming ring volume too loud? complaints when using certain smartphones (non-iPhone). Additionally, in 2014MY vehicles the upgrade will also improve…
• 10109833Apr 10, 2017Equipment. TSB: EXTERIOR EMBLEM REPLACEMENT - This bulletin provides the procedure to replace the front and rear Kia emblems on some 2014-2015MY Optima (QF) and replace the front and if necessary, the rear emblems on some 2014-2015MY Sorento (XMa) vehicles, which may exhibit peeling or delamination of the emblem coating. Follow the procedures outlined in this bulletin to correct the concern of peeling or delaminating emblems.
• 10109829Mar 24, 2017Electrical system. TSB: SERVICE ACTION: UVO SOFTWARE UPGRADE (SA277) - This bulletin provides the procedure to upgrade the UVO software on some 2015MY Soul (PS), Sportage (SL), Optima (TF, QF), Forte (YD), and Sorento (XMa) vehicles to incorporate Bluetooth and Voice Recognition improvements.
• 10109828Mar 24, 2017Electrical system. TSB: SERVICE ACTION: AUDIO SOFTWARE UPGRADE (SA276) - This bulletin provides the procedure to upgrade the audio software on some 2015MY Soul (PS), Sportage (SL), Optima (TF, QF), Forte (YD), and Sorento (XMa) vehicles to incorporate Bluetooth and Voice Recognition improvements.
• 10109855Mar 21, 2017Visibility (wipers, defrost, mirrors), Equipment. TSB: DEFOGGING LOGIC ? NORMAL OPERATION, DISABLING, AND ENABLING - Starting with 2010MY, all Kia vehicles, except Rio (JB), incorporate a defogging logic to prevent the interior windows from becoming excessively fogged. Depending on the specific model, the HVAC control head monitors ambient temperature and/or cabin humidity to determine which settings will best prevent the windows from fogging.
• 10109813Jan 18, 2017Engine cooling. PITSTOP: MANUAL EVAPORATIVE EMISSIONS TEST FOR HARD TO FIND/SMALL LEAKS - If the malfunction indicator lamp (MIL) is illuminated with DTC(s) P0442, P0455, P0456, or P0457 (Evaporative Emissions System-Leak detected) and the evaporative (EVAP) leak self-test resulted in NTF, a manual EVAP test is recommended.
• 10109812Jan 18, 2017Equipment. TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners, which are designed to lock into place once fully attached, are utilized in various Kia models and are strictly intended for ?one time use.? Some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking…
• 10109774Nov 15, 2016Engine, Electrical system. TSB: ECU UPGRADE ? MIL ON WITH DTC(s) P0420/P0171 - This bulletin provides information related to the ECU software upgrade for some 2012~2015MY Optima (QF) vehicles, produced from August 12, 2011 to October 2, 2015, some 2012~2015MY Sorento (XMa) vehicles, produced from April 19, 2011 to December 11, 2014, some 2011~2015MY Optima (TF) vehicles, produced from August 12, 2010 to July 23, 2015, and some 2014~2016MY…
• 10109777Nov 4, 2016Equipment, Latches, locks and linkages. TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners utilized in various Kia models are strictly intended for ?one time use?. Though not limited to the following, some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking adhesives.?
• 10109788Oct 31, 2016Equipment, Electrical system. TSB: INHIBITOR SWITCH DIAGNOSIS INFORMATION - This bulletin gives information regarding the steps to take regarding the diagnosis of the Inhibitor Switch.
• 10109686Oct 14, 2016Engine cooling, Equipment. TSB: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: EVAPORATIVE CANISTER INSPECTION AND/OR REPLACEMENT (SC135) - This bulletin provides information to inspect and/or replace the evaporative canister assembly on some Optima (TF) vehicles, produced from September 2, 2010 through November 29, 2014, some Optima Hybrid (TF HEV) vehicles, produced from February 15, 2011 through November 29, 2014, some Rondo (UN) vehicles…
• 10109683Oct 11, 2016Engine, Electrical system. TSB: ECU UPGRADE ? MIL ON WITH DTC(s) P0420/P0171 - This bulletin provides information related to the ECU software upgrade for some 2012~2015MY Optima (QF) vehicles, produced from August 12, 2011 to October 2, 2015, some 2012~2015MY Sorento (XMa) vehicles, produced from April 19, 2011 to December 11, 2014, some 2011~2015MY Optima (TF) vehicles, produced from August 12, 2010 to July 23, 2015, and some 2014~2016MY…
• 10090945Sep 30, 2016Equipment. Pitstop: hvac receiver/dryer - desiccant replacement - in the event of a hvac system concern in which metal particles or shards have contaminated the system, the desiccant or the entire a/c receiver/dryer assembly may need to be replaced. This is due to the fact that it may be impossible to remove all metal contaminants from the receiver/dryer during the a/c flushing procedure. Refer to the included table for…
• 10090944Sep 30, 2016Equipment, Brakes. Pitstop: variant coding integrated brake actuation units (ibau) - when replacing the integrated brake actuation unit, it is necessary to perform variant coding of the new module. For additional information related to variant coding click the variant codes link on the kgis home page. (see page 2 for sample screen shot.)
• 10090972Sep 19, 2016Engine. Owner notification letter (sc135) - dear kia owner, kia motors america, inc. Is conducting a voluntary emissions service campaign / warranty extension program regarding the evaporative canister in your vehicle.
• 10090974Sep 15, 2016Engine cooling. Q and a (sc135/wty009) - evaporative canister voluntary emissions service campaign / warranty extension program
• 10090970Sep 15, 2016Equipment, Engine. Dealer parts & service manager memo (sc135) - attention: all dealer parts and service managers, kia motors america, inc. Is conducting a voluntary emissions service campaign / warranty extension program to inspect the evaporative canister. Kia has determined that the following kia vehicles originally sold or currently registered in states where heavy amounts of road salt are used, may exhibit an evaporative…
• 10090969Sep 15, 2016Equipment, Engine. Dealer principal memo (sc135) - attention: all dealer principals, kia motors america, inc. Is conducting a voluntary emissions service campaign / warranty extension program to inspect the evaporative canister. Kia has determined that the following kia vehicles originally sold or currently registered in states where heavy amounts of road salt are used, may exhibit an evaporative canister leak due to prolonged…
• 10090943Sep 15, 2016Engine, Equipment. Tsb: voluntary emissions service campaign: evaporative canister inspection and/or replacement (sc135) - this bulletin provides information to inspect and/or replace the evaporative canister assembly on some optima (tf) vehicles, produced from september 2, 2010 through november 29, 2014, some optima hybrid (tf hev) vehicles, produced from february 15, 2011 through november 29, 2014, some rondo (un) vehicles…
• 10090968Sep 1, 2016Electrical system, Lane departure. Pitstop: no communication with blind spot detection after collision repairs - this pitstop provides information relating to 2014-2015my optima (qf) vehicles with blind spot detection (bsd), which may exhibit a “check bsd system” message and no communication with the bsd system after collision repairs. This concern is commonly caused by the rear bumper harness installed backwards.
• 10090966Sep 1, 2016Lane departure, Equipment, Electrical system. Pitstop: recalibration of blind spot detection after collision repairs - this pitstop provides information relating to some vehicles equipped with blind spot detection (bsd), which may exhibit a “check bsd system” message with dtcs: c270254 and c270354: c270254: control module master missing calibration / c270354: control module slave missing calibration
• 10109752Aug 28, 2016Steering. PITSTOP: OILY SUBSTANCE DRIPPING FROM MDPS STEERING COLUMN - On some Optima (QF/TF/TF HEV) vehicles, the customer may complain of an oily substance dripping onto the driver?s side floorboard area, especially in areas with high ambient temperatures. This article provides the process to resolve by cleaning excessive amounts of grease applied applied to the steering column tilt adjustment area.
• 10089609Aug 2, 2016Equipment, Exterior lighting. "tsb: combination lamp water intrusion - this bulletin provides the procedure to install additional foam gaskets in both rear tail lamps on 2014-2015my optima (qf) vehicles, when either of the lamp housings may indicate water inside. On some 2014-2015my optima (qf) vehicles, customers may complain about water droplets forming inside the rear tail lamp housing following a rainstorm or after washing their vehicle.
• 10089401Jul 20, 2016Electrical system, Equipment. Tsb: android auto™/apple carplay™ software download - this bulletin provides the procedure for upgrading avn 4.0 and uvo 3.0 audio system software to include android auto and apple carplay software.
• 10089301Jun 29, 2016Engine. Tsb: 2.4 gdi mil on with dtc(s) p0263/ p0266/ p0269/ p0272 - this bulletin provides information about the replacement of the fuel injectors in some sorento (xma) produced 12/17/2012~12/11/2014, optima (qf) produced 07/28/2013~10/02/2015, optima (tf) produced 09/09/2013~07/23/2015 2014~2015my, and sportage (sl) produced 09/01/2013~12/01/2014, which may exhibit a malfunction indicator lamp (mil) on along with dtcs…
• 10089303Jun 23, 2016Electrical system. Tsb: uvo software upgrade - media button inoperative - this bulletin provides the procedure for upgrading the uvo system of some 2014~2015my sportage (sl), forte (yd), optima (tf/qf), optima hybrid (tf hev) and sorento (xma) vehicles, which may exhibit an inoperative uvo media button.
• 10089312Jun 8, 2016Electrical system. Combination tsb / service action: uvo system upgrade (sa222) - this bulletin provides the procedure for upgrading the uvo system on some 2014~2016my soul (ps), sorento (xma)/(uma), optima (tf hev), forte (yd), sportage (sl) 2015~2016my sedona (yp), and 2014-2015(my) optima (qt/tf) vehicles to address “incoming ring volume too loud” complaints when using certain smartphones (non-iphone).
• 10183433Apr 21, 2016Electrical system, Equipment. TSB - COMBINATION TSB / SERVICE ACTION: UVO SYSTEM UPGRADE (SA222) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure for upgrading the UVO system on some 2014~2016MY Soul (PS), Sorento (XMa), Optima (TF/QF), Forte (YD) and Sportage (SL) vehicles to address "Incoming ring…
• 10079901Apr 21, 2016Equipment, Electrical system. Combination tsb / service action: uvo system upgrade (sa222) - this bulletin provides the procedure for upgrading the uvo system on some 2014~2016my soul (ps), sorento (xma), optima (tf/qf), forte (yd) and sportage (sl) vehicles to address “incoming ring volume too loud” complaints when using certain smartphones (non-iphone). Additionally, in 2014my vehicles the upgrade will also improve bluetooth connectivity and…
• 10183431Apr 4, 2016Equipment, Electrical system. TSB - USE OF AFTERMARKET USB CHARGING CABLES IN USB/12V PORTS - This article provides information regarding the use of USB ports and 12V power outlets to connect/charge mobile phones.
• 10080020Feb 29, 2016Equipment. Tsb / sirius audio mutes (drops out) intermittently in open spaces - this bulletin provides information about the replacement of the shark-fin style roof antenna of some 2014~2016my sportage (sl) vehicles, produced from august 1, 2014 through august 31, 2015, and some 2014~2015my optima (qf) vehicles, produced from august 1, 2013 through august 22, 2015, which may exhibit sirius audio reception concerns (see sample…
• 10080061Jan 29, 2016Body and structure, Visibility (wipers, defrost, mirrors). Service action: door module replacement (sa218) - this bulletin provides the procedure to replace right front door module assembly on certain 2014~2015my optima (qf) vehicles, produced from march 1, 2014 through july 31, 2014, which may exhibit an inoperative power window. Kia is requesting the completion of this service action on all affected vehicles, including dealer stock, prior to delivery. Before conducting…
• 10088983Oct 19, 2015Electrical system. Tsb: kds - audio update module (aum) - the gds audio update module (aum) was introduced in fourth quarter of 2013. This special service tool (sst) was developed to improve the efficiency and effectiveness of updating 2010my, and later, kia audio head units using a gds, and now, the same functionality is available on kds. Some technicians may not be aware of the benefits the aum tool has to offer.

← All problems reported for the 2015 Kia Optima