2016 Kia Optima Technical Service Bulletins

226 technical service bulletins (TSBs) are on record for the 2016 Kia Optima. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10130102Feb 19, 2018Exterior lighting. TSB - SERVICE ACTION: OUTSIDE REAR COMBINATION LAMP HARNESS REPLACEMENT (SA334) - This bulletin provides the procedure to replace the outside rear combination lamp harness on some 2016-2017MY Optima (JFa) vehicles, produced from September 25, 2016 through March 16, 2017, which may exhibit an intermittent inoperative brake light with the possibility of a ?Check brake light? warning on the instrument cluster display.
• 10130104Feb 16, 2018Transmission and drivetrain. TSB - DRIVESHAFT SERVICEABILITY - This bulletin has been revised most recently to include additional information. This bulletin provides information regarding axle shaft serviceability for Kia vehicles equipped with a six-speed automatic transmission.
• 10130105Feb 12, 2018Transmission and drivetrain, Electrical system. TSB - SERVICE ACTION: INHIBITOR SWITCH - REPLACEMENT (SA317A) - This bulletin has been revised to include additional information. - This bulletin provides the procedure to replace the inhibitor switch on some 2017MY Optima (JFa), Sorento (UMa), Optima Hybrid (HEV), Optima Plug-in Hybrid (PHEV), Sportage (QL), Forte (YD), and Sedona (YP), and some 2016-2017MY Optima (JF) vehicles, equipped with a front wheel drive…
• 10130103Feb 2, 2018Equipment. TSB - SERVICE ACTION: E-CVVT COVER INSPECTION AND MOTOR PLUG REPLACEMENT (SA305) - This bulletin has been revised to include additional information.
• 10127023Dec 11, 2017Equipment. TSB - SERVICE ACTION: PANORAMIC SUNROOF INSPECTION AND REPAIR (SA270) REV 1 - This bulletin provides information on some 2016MY Optima (JFa) vehicles, produced from September 28, 2015 to September 26, 2016, which may exhibit a buzzing noise that may increase with intensity in conjunction with the HVAC fan speed, a popping or clicking noise when driving over bumps or turning, and/or a loose folding cover, depending…
• 10123321Oct 23, 2017Electrical system. PITSTOP - OPTIMA TRUNK TORSION BAR ADJUSTMENT - On some 2016-2018MY Optima (JFa) vehicles, there may be a concern with the trunk not opening as designed when using transmitter key fob or Smart Trunk feature. This may be caused by improper assembly of the trunk torsion bar (A) and trunk lid hinge. Follow the procedure in this publication to correct this concern.
• 10123329Oct 16, 2017Fuel system. TSB - SERVICE ACTION: AIR INTAKE HOSE REPLACEMENT & ECU UPGRADE (SA303) - This bulletin provides the procedure to replace the air intake hose and/or improve the logic of the Electronic Control Unit (ECU) on some 2016-2017MY Optima (JFa), produced from September 4, 2015 through April 14, 2017, and some 2016-2017MY Sorento (UMa) vehicles, produced from November 19, 2014 through May 1, 2017, equipped with a 2.0T…
• 10119124Sep 20, 2017Equipment. TSB - SERVICE ACTION: E-CVVT COVER INSPECTION AND MOTOR PLUG REPLACEMENT (SA305) - REVISED - This bulletin provides information regarding the inspection and/or replacement of the E-CVVT cover or O-ring and replacement of the motor plug on some 2016-2017MY Optima (JF, JFa), 2016-2017MY Sorento (UMa), and 2017MY Sportage (QL) vehicles, equipped with 2.4L GDI or 2.0T-GDI, which may exhibit a malfunction indicator…
• 10119123Sep 9, 2017Equipment. TSB - SERVICE ACTION: E-CVVT COVER INSPECTION AND MOTOR PLUG REPLACEMENT (SA305) - This bulletin provides information regarding the inspection and/or replacement of the E-CVVT cover or O-ring and replacement of the motor plug on some 2016-2017MY Optima (JF, JFa), 2016-2017MY Sorento (UMa), and 2017MY Sportage (QL) vehicles, equipped with 2.4L GDI or 2.0T-GDI, which may exhibit a malfunction indicator light (MIL) ON…
• 10119120Sep 8, 2017Equipment. TSB - E-CVVT COVER AND MOTOR PLUG REPLACEMENT - REVISED - This bulletin provides information about the replacement of the E-CVVT cover and motor plug on some 2016MY Optima (JFa), produced from August 29, 2015 to June 14, 2016, and 2016-2017MY Sorento (UMa) vehicles, produced from October 27, 2014 to June 14, 2016, which may exhibit a MIL ON with DTC P001000 and/or oil leakage in the E-CVVT motor plug of applicable…
• 10119121Sep 7, 2017Equipment. TSB - DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS DATA FROM ECU (DC16) - REVISED - This bulletin provides information related to extracting ?in use performance tracking? emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California.
• 10116101Jun 27, 2017Electrical system. PITSTOP: TPMS SENSOR POSITION - When diagnosing TPMS-related DTCs, make sure you are investigating the correct sensor. The TPMS positioning from the manufacturer may be different from the positioning shown on a KDS.
• 10116115Jun 12, 2017Electrical system. TSB: SERVICE ACTION: REAR PERSONAL LAMP REPAIR (SA273) - This bulletin provides information related to the rear personal lamp on some 2016MY Optima (JFa) vehicles, produced from September 11, 2015 to August 13, 2016, which may experience a blown Interior Lamp 10A fuse resulting in inoperative interior lamps.
• 10116122Jun 9, 2017Transmission and drivetrain. TSB: COMBINATION TSB / SERVICE ACTION: SHIFT QUALITY IMPROVEMENT (SA292A) - This bulletin provides the procedure to improve the logic of the Transmission Control Unit (TCU) on some 2016MY Optima (JFa) 2.0T, produced from September 11, 2015 through October 6, 2016, 2016MY Sorento (UMa) 2.0T, produced from October 23, 2014 through April 18, 2016, Sorento (UMa) 2.4L, produced from November 18, 2014 through January 19…
• 10116119Jun 9, 2017Electronic stability control, Brakes. TSB: COMBINATION TSB / SERVICE ACTION: IDLE STABILITY & SHIFT QUALITY IMPROVEMENT (SA294A) - This bulletin provides the procedure to improve the logic of the Electronic Control Unit (ECU) and the Transmission Control Unit (TCU) on some 2016MY Optima (JFa) vehicles, produced from September 3, 2015 through October 6, 2016, which may experience a vibration and/or hesitation when releasing the brake pedal after coming…
• 10116104Jun 8, 2017Transmission and drivetrain, Equipment. PITSTOP: CUSTOMER TIP: ACCELERATOR PEDAL FUNCTION/DESCRIPTION - On all K900 (KH), Cadenza (VG, YG), and Optima (JF, JFa, JF-HEV, JF-PHEV) vehicles, the accelerator pedal features a small detent with a spring to provide increased resistance to help avoid unnecessary fuel consumption when applying full throttle. When the driver depresses the pedal beyond the resistance where the detent is felt (above 85% WOT), the…
• 10109868May 24, 2017Transmission and drivetrain. TSB: COMBINATION TSB / SERVICE ACTION: SHIFT QUALITY IMPROVEMENT (SA292) - This bulletin provides the procedure to improve the logic of the Transmission Control Unit (TCU) on some 2016MY Optima (JFa) 2.0T, produced from August 28, 2015 through October 7, 2016, Sorento (UMa) 2.0T, produced from October 29, 2014 through December 9, 2016, and Sorento (UMa) 3.3L vehicles, produced from October 27, 2014 through December…
• 10109865May 24, 2017Brakes, Transmission and drivetrain, Electrical system. TSB: COMBINATION TSB/SERVICE ACTION: IDLE STABILITY & SHIFT QUALITY IMPROVEMENT (SA294) - This bulletin provides the procedure to improve the logic of the Electronic Control Unit (ECU) and the Transmission Control Unit (TCU) on some 2016MY Optima (JFa) vehicles, produced from September 3, 2015 through November 22, 2016, which may experience a vibration and/or hesitation when releasing the brake pedal after coming…
• 10109864May 23, 2017Equipment. TSB: HVAC CONTROL UNIT LOGIC IMPROVEMENT - This bulletin provides the procedure to apply a HVAC control unit logic improvement on some 2016MY Optima (JFa) vehicles, produced from August 28, 2015 through September 30, 2016, and some 2016MY Optima (JF) vehicles, produced from February 2, 2016 through November 23, 2016, equipped with Fully Automatic (FATC) or Manual Temperature (MTC) Controls, which may experience a…
• 10109850Mar 23, 2017Engine cooling. TSB: E-CVVT COVER AND MOTOR PLUG REPLACEMENT - This bulletin provides information about the replacement of the E-CVVT cover and motor plug on some 2016MY Optima (JF/JFa), produced from August 29, 2015 to June 14, 2016, 2017MY Sportage (QL) vehicles, produced from December 10, 2015 to June 15, 2016, and 2016-2017MY Sorento (UMa), produced from October 27, 2014 to June 14, 2016, which may exhibit a MIL ON with DTC…
• 10109855Mar 21, 2017Visibility (wipers, defrost, mirrors), Equipment. TSB: DEFOGGING LOGIC ? NORMAL OPERATION, DISABLING, AND ENABLING - Starting with 2010MY, all Kia vehicles, except Rio (JB), incorporate a defogging logic to prevent the interior windows from becoming excessively fogged. Depending on the specific model, the HVAC control head monitors ambient temperature and/or cabin humidity to determine which settings will best prevent the windows from fogging.
• 10109854Mar 20, 2017Transmission and drivetrain, Engine. PS481: DUAL CLUTCH TRANSMISSION (DCT) CHARACTERISTICS - All models with a 1.6L Turbo engine may come equipped with a 7-speed Dual Clutch Transmission (DCT), except the 2017MY~ Niro (DE) with a 1.6L Atkinson engine comes equipped with a 6-speed Dual Clutch Transmission (DCT). This automatic transmission is unlike the conventional automatic transmission found in the complete line up of Kia vehicles. The new DCT…
• 10109830Mar 2, 2017Equipment. TSB: SERVICE ACTION: ANTENNA INSPECTION AND/OR REPLACEMENT (SA272) - This bulletin provides the procedure to inspect and/or replace the antenna assembly on some 2016MY Optima (JFa) vehicles, produced from September 28, 2015 to June 1, 2016, which may experience an antenna cover separation/loss or looseness.
• 10109881Feb 21, 2017Visibility (wipers, defrost, mirrors), Engine cooling. TSB: SERVICE ACTION: PANORAMIC SUNROOF INSPECTION AND REPAIR (SA270) - This bulletin provides information on some 2016MY Optima (JFa) vehicles, produced from September 28, 2015 to August 8, 2016, which may exhibit a buzzing noise that may increase with intensity in conjunction with the HVAC fan speed, a popping or clicking noise when driving over bumps or turning, and/or a loose folding cover, depending on the…
• 10109810Jan 23, 2017Electrical system. TSB: SERVICE ACTION: REAR PERSONAL LAMP REPAIR (SA273) - This bulletin provides information related to the rear personal lamp on some 2016MY Optima (JFa) vehicles, produced from September 11, 2015 to August 13, 2016, which may experience a blown Interior Lamp 10A fuse resulting in inoperative interior lamps.
• 10109813Jan 18, 2017Engine cooling. PITSTOP: MANUAL EVAPORATIVE EMISSIONS TEST FOR HARD TO FIND/SMALL LEAKS - If the malfunction indicator lamp (MIL) is illuminated with DTC(s) P0442, P0455, P0456, or P0457 (Evaporative Emissions System-Leak detected) and the evaporative (EVAP) leak self-test resulted in NTF, a manual EVAP test is recommended.
• 10109812Jan 18, 2017Equipment. TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners, which are designed to lock into place once fully attached, are utilized in various Kia models and are strictly intended for ?one time use.? Some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking…
• 10116817Dec 2, 2016Equipment. TSB - LUGGAGE SIDE TRIM REPLACEMENT - This bulletin provides the procedure to replace the luggage side trims on 2016MY Optima (JFa) vehicles, produced from September 28, 2015 to August 16, 2016, which may experience a concern with high cabin pressure. This concern is caused by the isolation pads of the luggage side trim assemblies blocking the extractor vents. Follow the procedure outlined in this bulletin to…
• 10109773Nov 18, 2016Engine cooling, Electrical system. TSB: VCM LOGIC IMPROVEMENT - DTC P200A00 (SA240A) - This bulletin provides information related to the ECM software upgrade and inspection of the VCM motor (Actuation Test) of some 2016MY Optima (JFa) vehicles, produced from August 28, 2015 through February 15, 2016, and some 2016MY Sorento (UMa) vehicles, produced from November 17, 2014 through February 3, 2016, which may experience a malfunction indicator lamp…
• 10109781Nov 15, 2016Equipment, Electrical system. PITSTOP: HVAC VENTILATION LOGIC OPERATION - Starting with 14MY Soul (PS) (with the exception of PSEV) and complete new models such as K900 (KH), Sedona (YP), Sorento (UMa), Optima (JFa), Sportage (QL), and 17MY Forte (YD, YDm), etc., equipped with a sunroof, a ventilation logic has been applied in order to prevent exhaust gases flowing into the vehicle due to the pressure difference (inside vs outside) that is…
• 10109779Nov 15, 2016Transmission and drivetrain. TSB: SERVICE ACTION: AXLE DRIVESHAFT REPLACEMENT (SA241) - This bulletin provides information on some 2016MY Optima (JF) vehicles, produced in South Korea from March 24, 2016 to April 8, 2016, which may exhibit a noise originating from the axle driveshaft during acceleration.
• 10109765Nov 15, 2016Visibility (wipers, defrost, mirrors), Equipment. TSB: SUNROOF BUZZING NOISE - This bulletin provides information on some 2016MY Optima (JFa) vehicles, produced from September 28, 2015 to June 20, 2016, which may exhibit a buzzing noise that may increase with intensity in conjunction with the HVAC fan speed. This concern is caused by a loose sunroof weather strip vibration due to air leakage past the sunroof seal. To correct this concern, follow the procedure…
• 10109775Nov 9, 2016Engine cooling. TSB: DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS DATA FROM ECU (DC16) - This bulletin provides information related to extracting ?in use performance tracking? emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California. The California Air Resources Board (CARB) requires the emissions data from vehicles with a minimum of 3,000 accumulated miles without reprogramming or resetting.
• 10109777Nov 4, 2016Equipment, Latches, locks and linkages. TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners utilized in various Kia models are strictly intended for ?one time use?. Though not limited to the following, some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking adhesives.?
• 10109688Oct 21, 2016Equipment. PITSTOP: AUTONOMOUS EMERGENCY BRAKING (AEB) OPERATION - An increasing number of Kia?s latest models are now equipped with Autonomous Emergency Braking (AEB). Some customers may have interest and/or questions regarding this new technology, including what type of feedback they can expect from this system. The information provided below is a brief reference. The service information found on KGIS including the Owner?s…
• 10090945Sep 30, 2016Equipment. Pitstop: hvac receiver/dryer - desiccant replacement - in the event of a hvac system concern in which metal particles or shards have contaminated the system, the desiccant or the entire a/c receiver/dryer assembly may need to be replaced. This is due to the fact that it may be impossible to remove all metal contaminants from the receiver/dryer during the a/c flushing procedure. Refer to the included table for…
• 10090944Sep 30, 2016Equipment, Brakes. Pitstop: variant coding integrated brake actuation units (ibau) - when replacing the integrated brake actuation unit, it is necessary to perform variant coding of the new module. For additional information related to variant coding click the variant codes link on the kgis home page. (see page 2 for sample screen shot.)
• 10090818Sep 29, 2016Engine. Tsb: e-cvvt cover and motor plug replacement - this bulletin provides information about the replacement of the e-cvvt cover and motor plug on some 2016my sorento (uma), produced from october 27, 2014 to june 14, 2016, 2016my optima (jf/jfa), produced from august 29, 2015 to june 14, 2016, and 2017my sportage (ql) vehicles, produced from december 10, 2015 to june 15, 2016, which may exhibit a mil on with dtc p001000…
• 10090966Sep 1, 2016Lane departure, Equipment, Electrical system. Pitstop: recalibration of blind spot detection after collision repairs - this pitstop provides information relating to some vehicles equipped with blind spot detection (bsd), which may exhibit a “check bsd system” message with dtcs: c270254 and c270354: c270254: control module master missing calibration / c270354: control module slave missing calibration
• 10089585Aug 25, 2016Equipment, Visibility (wipers, defrost, mirrors). Tsb: sunroof popping noise repair - this bulletin provides information on some 2016my optima (jfa) vehicles, produced from september 28, 2015 to february 23, 2016, which may experience a pop or click noise when driving over bumps or turning. This noise is caused by contact between the decorative trim and the sunroof frame as the chassis flexes and is more common as the vehicle heats up, causing thermal expansion of…
• 10089584Aug 25, 2016Visibility (wipers, defrost, mirrors), Equipment. Tsb: sunroof buzzing noise - this bulletin provides information on some 2016my optima (jfa) vehicles, produced from september 28, 2015 to june 20, 2016, which may exhibit a buzzing noise that may increase with intensity in conjunction with the hvac fan speed. This concern is caused by a loose sunroof weather strip vibration due to air leakage past the sunroof seal. To correct this concern, follow the procedure…
• 10089401Jul 20, 2016Electrical system, Equipment. Tsb: android auto™/apple carplay™ software download - this bulletin provides the procedure for upgrading avn 4.0 and uvo 3.0 audio system software to include android auto and apple carplay software.
• 10089312Jun 8, 2016Electrical system. Combination tsb / service action: uvo system upgrade (sa222) - this bulletin provides the procedure for upgrading the uvo system on some 2014~2016my soul (ps), sorento (xma)/(uma), optima (tf hev), forte (yd), sportage (sl) 2015~2016my sedona (yp), and 2014-2015(my) optima (qt/tf) vehicles to address “incoming ring volume too loud” complaints when using certain smartphones (non-iphone).
• 10089321Jun 2, 2016Electrical system. Tsb: apple carplay™ rollout and troubleshooting guide - this bulletin provides information related to the rollout of apple carplay and android auto on 2017my sorento (uma) and the launch of apple carplay on 2016my optima (jfa) and 2017my sportage (ql) vehicles, equipped with premium navigation (avn 4.0) or uvo eservices (uvo 3.0) systems.
• 10183600May 12, 2016Equipment, Electrical system. PITSTOP: ANDROID AUTO/UVO eSERVICES CONNECTIVITY ISSUES AFTER ANDROID 6.0 UPDATE - This article provides diagnostic information in regards to: ANDROID AUTO will not launch when a Samsung Android phone is connected to the vehicle. UVO eServices setup fails and the head unit displays a smartphone connection error.
• 10183434Apr 29, 2016Equipment, Electrical system. TSB - APPLE CARPLAY ROLLOUT AND TROUBLESHOOTING GUIDE - This bulletin provides information related to the rollout of Apple CarPlay and Android Auto on vehicles equipped with Premium Navigation (AVN 4.0) or UVO eServices (UVO 3.0) systems.
• 10079884Apr 29, 2016Equipment. Tsb: apple carplay™ rollout and troubleshooting guide - this bulletin provides information related to the rollout of apple carplay™ and android auto on vehicles equipped with premium navigation (avn 4.0) or uvo eservices (uvo 3.0) systems.
• 10183433Apr 21, 2016Electrical system, Equipment. TSB - COMBINATION TSB / SERVICE ACTION: UVO SYSTEM UPGRADE (SA222) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure for upgrading the UVO system on some 2014~2016MY Soul (PS), Sorento (XMa), Optima (TF/QF), Forte (YD) and Sportage (SL) vehicles to address "Incoming ring…
• 10079921Apr 21, 2016Air bags. "voluntary safety recall campaign: driver’s frontal airbag module replacement (sc131) - this bulletin provides the procedure to replace the driver’s frontal airbag module of seventeen (17) 2016 my optima vehicles, produced from november 10, 2015 through february 12, 2016. A secondary chemical enhancer required for the proper deployment of second-stage frontal airbag was not loaded during the airbag inflator build…
• 10079901Apr 21, 2016Equipment, Electrical system. Combination tsb / service action: uvo system upgrade (sa222) - this bulletin provides the procedure for upgrading the uvo system on some 2014~2016my soul (ps), sorento (xma), optima (tf/qf), forte (yd) and sportage (sl) vehicles to address “incoming ring volume too loud” complaints when using certain smartphones (non-iphone). Additionally, in 2014my vehicles the upgrade will also improve bluetooth connectivity and…

← All problems reported for the 2016 Kia Optima