2015 Kia RIO Technical Service Bulletins

100 technical service bulletins (TSBs) are on record for the 2015 Kia RIO. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10179255Aug 25, 2020Equipment, Brakes. PITSTOP - BRAKE CALIPER LEAK INSPECTION - This PITSTOP provides information related to a brake caliper fluid/oil substance found on some Kia vehicles, due to possible excess assembly oil applied during assembly.
• 10177046Jun 17, 2020Latches, locks and linkages. TSB - This bulletin provides the procedure to perform a partial repair on the trunk latch base sub assembly on the certain Forte, Rio and Optima vehicles, which may exhibit a difficult-to-close/latch concern with the trunk lid.
• 10174520Apr 24, 2020Transmission and drivetrain. TECHNICAL SERVICE BULLETIN: - TRANSMISSION FLUID APPLICATION GUIDE - This bulletin has been revised to include additional information. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles on page 2. Refer to the shop manual on KGIS for the specific…
• 10170778Jan 21, 2020Exterior lighting. TECHNICAL SERVICE BULLETIN: HALOGEN HEAD LAMP LOW BEAM BULB CONNECTOR REPLACEMENT - This bulletin provides information regarding the procedure to repair the bulb connector on some 2010MY~ vehicles listed on the table below, which may exhibit a bulb connector concern. To correct this concern, replace the connector with a new and improved part.
• 10169713Dec 20, 2019Fuel system, Engine cooling, Equipment. TECHNICAL SERVICE BULLETIN: FUEL SMELL ECU LOGIC IMPROVEMENT AND CHARCOAL CANISTER REPLACEMENT - This bulletin provides the procedure to improve the logic of the Engine Control Unit (ECU) and replace the evaporative system charcoal canister on some 2014-2017MY Rio (UB) vehicles with Gamma 1.6 GDI engines, produced from September 17, 2013 through March 31, 2017, which may exhibit fuel smell due to insufficient fuel…
• 10168850Nov 26, 2019Equipment, Steering, Engine cooling. TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information.This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU) or Steering Column Housing on some 2010MY~ Kia models listed on page 5 equipped with a Column Motor Driven Power…
• 10167301Oct 15, 2019Steering. TECHNICAL SERVICE BULLETIN TSB084_R3: PARTIAL REPAIR OF C-MDPS MOTOR, ECU AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information.This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU) or Steering Column Housing on some 2010MY~ Kia models listed on page 5 equipped with a Column Motor…
• 10162048Jun 11, 2019Fuel system. TSB: AIR DRAIN CASE REPLACEMENT - This bulletin has been revised to include additional information. This bulletin provides the procedure to replace the Air Drain Case on some 2014-2018MY Soul (PS), produced from July 21, 2013 through June 1, 2017, some 2012-2017MY Rio (UB), produced from June 21, 2011 through March 31, 2017, some 2014-2017MY Forte (YD), produced from February 18, 2013 through March 2, 2017, and…
• 10152915Jan 18, 2019Fuel system. TSB: SPECIAL SERVICE INFORMATION & SPECIFICATIONS FOR GDI HIGH PRESSURE FUEL SYSTEM - This bulletin has been revised to include additional information. This bulletin provides information relating to all Kia vehicles equipped with Gasoline Direct Injection (GDI) engines. In these engines highly pressurized gasoline is injected via a common fuel rail and injectors that deliver fuel directly into the combustion…
• 10143468Jul 3, 2018Engine, Electrical system. TSB - ECU UPGRADE ? DTC P0441 LOGIC IMPROVEMENT - This bulletin has been revised and is no longer a Service Action. bulletin provides information related to the Engine Control Unit (ECU) software upgrade for some 2012-2016MY Rio (UB), 2014-2016MY Soul (PS), and 2012-2013MY Soul (AM) vehicles, which may have a malfunction indicator light (MIL) ON with DTC P0441: Evaporative Emissions System Incorrect Purge Flow.
• 10142242May 17, 2018Equipment, Engine cooling. TSB - A/C FAN CONTROL LOGIC IMPROVEMENT AND COOLING FAN/COOLING FAN RESISTOR INSPECTION OR REPLACEMENT - This bulletin provides the procedure to inspect, and if necessary, replace the cooling fan resistor and/or the cooling fan motor, and to upgrade the cooling fan control logic on certain Manual Temperature Control (MTC) equipped 2012-2015MY Rio (UB) vehicles, produced from August 7, 2011 through October 22, 2014.
• 10136503Apr 27, 2018Engine cooling. TSB - CANISTER CLOSE VALVE INSPECTION AND AIR DRAIN CASE REPLACEMENT - This bulletin provides the procedure to inspect and if necessary, replace the Air Drain Case on some 2014-18MY Soul (PS), produced from July 21, 2013 through June 1, 2017, some 2012-2017MY Rio (UB), produced from June 21, 2011 through March 31, 2017, some 2014-2017MY Forte (YD) vehicles, produced from February 18, 2013 through March 2, 2017, and…
• 10136504Apr 18, 2018Engine cooling. TSB - CANISTER CLOSE VALVE (CCV) REPLACEMENT - This bulletin provides the procedure to replace the Canister Close Valve (CCV) on some 2012-2017MY Rio (UB) vehicles, produced from June 21, 2011 through March 28, 2016, which may exhibit the engine warning lamp DTCs P0455 and P0456 for an evaporative emission system leak due to the Canister Close Valve (CCV) stuck open.
• 10133170Mar 2, 2018Engine cooling. PITSTOP - ENGINE COMPONENT RE-USE GUIDELINES - In general, parts and components removed during engine repairs should be considered serviceable, and should be thoroughly cleaned and transferred to the new engine.
• 10130104Feb 16, 2018Transmission and drivetrain. TSB - DRIVESHAFT SERVICEABILITY - This bulletin has been revised most recently to include additional information. This bulletin provides information regarding axle shaft serviceability for Kia vehicles equipped with a six-speed automatic transmission.
• 10130100Feb 2, 2018Electrical system. TSB - BLOWER MOTOR AND RESISTOR REPLACEMENT - This bulletin provides the procedure to replace the blower motor and resistor on some 2014-2015MY Rio (UB) vehicles, produced from April 1, 2014 through August 31, 2014, which may experience an inoperative blower motor except at the highest speed.
• 10126423Nov 20, 2017Electrical system. TSB - IDENTIFYING HEAD UNIT SOFTWARE VERSION FOR DIRECT EXCHANGE - This bulletin provides the procedure on how to identify and record the head unit software level on various head unit platforms and generations.
• 10119114Sep 20, 2017Transmission and drivetrain. PITSTOP - SHIFT LOCK INTERMITTENTLY INOPERATIVE - Some 2012-2017MY Rio (UB) vehicles may exhibit a shifter that will intermittently not shift out of Park. This bulletin gives information on how to troubleshoot the issue.
• 10116101Jun 27, 2017Electrical system. PITSTOP: TPMS SENSOR POSITION - When diagnosing TPMS-related DTCs, make sure you are investigating the correct sensor. The TPMS positioning from the manufacturer may be different from the positioning shown on a KDS.
• 10109851Mar 16, 2017Engine, Electrical system. TSB: SERVICE ACTION: ECU UPGRADE - DTC P0441 LOGIC IMPROVEMENT (SA280) - This bulletin provides information related to the Engine Control Unit (ECU) software upgrade for some 2012-2016MY Rio (UB), 2014-2016 Soul (PS), and 2012-2013MY Soul (AM) vehicles, which may have a MIL on with DTC P0441: Evaporative Emissions System Incorrect Purge Flow.
• 10109888Feb 16, 2017Electrical system. COMBINATION TSB / SERVICE ACTION: ECU UPGRADE ? DTC P0441 LOGIC IMPROVEMENT (SA280) - This bulletin provides information related to the Engine Control Unit (ECU) software upgrade for some 2012-2016MY Rio (UB), 2014-2016 Soul (PS), and 2012-2013MY Soul (AM) vehicles, which may have a MIL on with DTC P0441: Evaporative Emissions System Incorrect Purge Flow. To correct this condition, the ECU should be reprogrammed…
• 10109813Jan 18, 2017Engine cooling. PITSTOP: MANUAL EVAPORATIVE EMISSIONS TEST FOR HARD TO FIND/SMALL LEAKS - If the malfunction indicator lamp (MIL) is illuminated with DTC(s) P0442, P0455, P0456, or P0457 (Evaporative Emissions System-Leak detected) and the evaporative (EVAP) leak self-test resulted in NTF, a manual EVAP test is recommended.
• 10109812Jan 18, 2017Equipment. TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners, which are designed to lock into place once fully attached, are utilized in various Kia models and are strictly intended for ?one time use.? Some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking…
• 10109770Nov 22, 2016Equipment. TSB: PASSENGER FLOOR WET DURING A/C OPERATION - This bulletin provides information relating to the possible presence of moisture on the passenger side floor during A/C operation on some Rio (UB) vehicles, produced from June 21, 2011 to March 10, 2016.
• 10109777Nov 4, 2016Equipment, Latches, locks and linkages. TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners utilized in various Kia models are strictly intended for ?one time use?. Though not limited to the following, some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking adhesives.?
• 10109788Oct 31, 2016Equipment, Electrical system. TSB: INHIBITOR SWITCH DIAGNOSIS INFORMATION - This bulletin gives information regarding the steps to take regarding the diagnosis of the Inhibitor Switch.
• 10090945Sep 30, 2016Equipment. Pitstop: hvac receiver/dryer - desiccant replacement - in the event of a hvac system concern in which metal particles or shards have contaminated the system, the desiccant or the entire a/c receiver/dryer assembly may need to be replaced. This is due to the fact that it may be impossible to remove all metal contaminants from the receiver/dryer during the a/c flushing procedure. Refer to the included table for…
• 10183431Apr 4, 2016Equipment, Electrical system. TSB - USE OF AFTERMARKET USB CHARGING CABLES IN USB/12V PORTS - This article provides information regarding the use of USB ports and 12V power outlets to connect/charge mobile phones.
• 10080084Jan 29, 2016Back-over prevention (rear camera). Tsb: rear view camera diagnosis/replacement - this bulletin provides information to diagnose and/or replace the rear view camera of some kia vehicles (see table on pg. 6 for specific models and production dates) which may exhibit inadequate image quality from the rear view camera. Diagnose the concerns using the information in this bulletin and, if necessary, replace the rear view camera with an improved part by…
• 10088983Oct 19, 2015Electrical system. Tsb: kds - audio update module (aum) - the gds audio update module (aum) was introduced in fourth quarter of 2013. This special service tool (sst) was developed to improve the efficiency and effectiveness of updating 2010my, and later, kia audio head units using a gds, and now, the same functionality is available on kds. Some technicians may not be aware of the benefits the aum tool has to offer.
• 10089047Oct 9, 2015Equipment. Simplified uvo e-services activation procedure - this article outlines the simplified activation procedure for vehicles equipped with uvo e-services. (excluding 2016 k900 and soul ev)
• 10089022Oct 6, 2015Equipment. Pre-delivery inspection (pdi) and owner delivery folder program - all models excluding k900 and soul ev -kia motors america, inc. Is pleased to announce the launch of an all-new pre-delivery inspection (pdi) and owner delivery folder program which has been redesigned to improve initial vehicle quality during pdi and also during delivery to your customer
• 10116821Aug 12, 2015Equipment, Electrical system. TSB: IDENTIFYING HEAD UNIT SOFTWARE VERSION FOR DIRECT EXCHANGE - Identifying Head Unit Software Version For Direct Exchange (ELE091) (Rev 1) - This bulletin provides the procedure on how to identify and record the head unit software level on various head unit platforms and generations. This procedure will now be required when ordering head units through the Direct Exchange Program (see Parts Bulletin 91-961-0005).
• 10089354Aug 12, 2015Electrical system. Tsb: identifying head unit software version for direct exchange - this bulletin provides the procedure on how to identify and record the head unit software level on various head unit platforms and generations. This procedure will now be required when ordering head units through the direct exchange program.
• 10089382Aug 3, 2015Transmission and drivetrain. Tsb: 6-spd. A/t adaptive value reset /relearn - this bulletin provides the procedures necessary to reset and relearn the adaptive values after transmission replacement or reprogramming/replacement of the pcm/tcm. After the adaptive values are reset, the transmission computer adaptive values must be relearned by driving in a precise manner to “teach” the computer the proper solenoid duty and line pressure for the…
• 10089617Jul 1, 2015Engine, Electrical system. Tsb: data collection: extract california emissions data from ecu (dc1501) - this bulletin provides information related to extracting “in use performance tracking” emissions data from the engine control unit (ecu) of certain vehicles sold in california. The california air resources board (carb) requires the emissions data from vehicles with a minimum of 3,000 accumulated miles without reprogramming or resetting.
• 10058534Jul 1, 2015Engine. Kia: crankshaft position sensor (ckp) variation has not learned causing misfire of engine and malfunction indicator light (mil) to come in dash. Model all. No years listed.
• 10092132Jun 26, 2015Electrical system, Equipment. Tsb: navigation head unit sd card replacement - this bulletin describes the sd card exchange/replacement procedure related to error messages that may be displayed on the navigation screen when the incorrect sd card is inserted. Note: only new models (during pdi inspection or at the point of purchase) or compatibility mismatches that occur after head unit replacement will be considered for this program.
• 10089742Jun 26, 2015Equipment, Electrical system. Tsb: navigation head unit sd card replacement - this bulletin describes the sd card exchange/replacement procedure related to error messages that may be displayed on the navigation screen when the incorrect sd card is inserted. Note: only new models (during pdi inspection or at the point of purchase) or compatibility mismatches that occur after head unit replacement will be considered for this program.
• 10092147Jun 1, 2015Transmission and drivetrain. Tsb: 6 spd a/t solenoid replacement – multiple dtcs - this bulletin provides information relating to the replacement of various shift solenoids on 6-speed automatic transaxles with dtcs p0741, p0743, p0748, p0753, p0758, p0763, p0768, p0773, p1778 and p2709. Replace the solenoids if current or history codes are present; do not replace the transaxle. To reduce vehicle repair time, this procedure can be performed…
• 10089761Jun 1, 2015Transmission and drivetrain. Tsb: 6 spd a/t solenoid replacement – multiple dtcs - this bulletin provides information relating to the replacement of various shift solenoids on 6-speed automatic transaxles with dtcs p0741, p0743, p0748, p0753, p0758, p0763, p0768, p0773, p1778 and p2709. Replace the solenoids if current or history codes are present; do not replace the transaxle. To reduce vehicle repair time, this procedure can be performed…
• 10089987Apr 24, 2015Engine, Vehicle speed control. Pitstop: smart pedal feature - the “smart pedal” is an integral part of the engine management system (ems) functionality which monitors and prevents the simultaneous activation of accelerator and brake pedals. When engaged, the feature reduces engine power to idle.
• 10092100Mar 27, 2015Equipment, Electrical system. Pitstop: bluetooth® issues after iphone® ios 8 software update - this article provides information related to possible bluetooth concerns when using an iphone® with ios 8.x (ios 8, 8.0.1, 8.0.2, 8.1, 8.1.2, 8.1.3, etc.) while paired to a head unit.
• 10092104Mar 6, 2015Electrical system, Equipment. Pitstop: navigation headunit and sd card compatibility - this article provides information in regards to possible compatibility issues between navigation head units and sd cards when replacing head units for multimedia issues. If after replacing a navigation head unit the original sd card does not operate correctly, follow the steps below to diagnose the issue:
• 10090201Dec 15, 2014Electrical system, Engine. Tsb: service action: ecm upgrade – mil on without dtc code (sa 175) - this bulletin provides information related to an ecm software upgrade for 2015my rio (ub) vehicles with 1.6l gdi engine and produced from may 21, 2014 through september 18, 2014, which may experience a malfunction indicator lamp (mil) illuminated without any accompanying dtc(s) stored in memory. To prevent and/or correct this condition, the ecm…
• 10109787Oct 7, 2014Equipment. TSB: GENERAL INFORMATION AND DIAGNOSIS FOR SMART KEY FOB SYSTEMS AND START/STOP BUTTONS - This bulletin provides information related to the Smart Key Systems on vehicles equipped with A/T (automatic transaxle) and Start/Stop Buttons (SSB).
• 10060170Aug 1, 2014Electrical system. Summary to be provided on a future date.
• 10109652May 22, 2014Equipment. TSB: 6 SPD A/T SOLENOID REPLACEMENT ? DTC P0741 - This bulletin provides information relating to the replacement of the Damper Clutch (D/C) Solenoid on 6-speed automatic transaxles with DTC P0741 (active or history), instead of replacing the transaxle. To reduce vehicle repair time, this procedure can be performed with the transaxle installed in the vehicle.
• 10109655May 19, 2014Fuel system. PIT STOP: GDI INJECTOR SPRAY TIP DEPOSITS - A design feature of vehicles equipped with a Gasoline Direct Injection (GDI) system is the placement of each fuel injector directly into the engine cylinder head assembly. Therefore, it is completely normal for the combustion process to create deposits on the injector spray tip surfaces.
• 10090431May 29, 2013Transmission and drivetrain. Tsb: 6-speed a/t transmission adaptive values reset/relearn - this bulletin provides the procedures necessary to reset and relearn the adaptive values after transmission replacement or reprogramming/replacement of the ecm/pcm.

← All problems reported for the 2015 Kia RIO