2017 Lexus GX460 Technical Service Bulletins

114 technical service bulletins (TSBs) are on record for the 2017 Lexus GX460. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10235234Feb 17, 2023Transmission and drivetrain. TSB: Some 2016 ? 2022 model year GX 460 vehicles may exhibit a thump sound or a bump feeling when accelerating from or decelerating to a stop. The condition does not set any Diagnostic Trouble Codes (DTCs) or illuminate any warning messages on the dash and is typically more noticeable in below freezing temperatures. Please follow the Repair Procedure in this bulletin to address this condition.
• 10235219Feb 9, 2023Fuel system. DL: On December 20, 2022, a settlement of claims for certain low pressure fuel pumps was approved by the federal court. The settlement includes Lexus?s agreement to provide a Customer Support Program for certain 2013-2020 model year (MY) vehicles originally equipped with low pressure fuel pumps repaired under Safety Recall 20LA01 or Special Service Campaign 21LC01.
• 10235215Feb 9, 2023Fuel system, Electrical system. TSB: Some 2013 ? 2020 model year Lexus vehicles may exhibit a hard start and/or MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs): ?DTC P0171 and/or P0174 (System Too Lean Bank 1/Bank 2) ?DTC P0087 Fuel Rail / System Pressure ? Too Low Techstream data list analysis may reveal positive fuel trims including a no pressure condition verified by a manual fuel pressure gauge. Follow the…
• 10230353Dec 1, 2022Equipment. TI: 19LE05 Expired December 1, 2022
• 10230352Dec 1, 2022Equipment. DP: Limited Service Campaign KLG expired December 01, 2022
• 10230351Dec 1, 2022Equipment. TI: 19LE05 Expired December 1, 2022
• 10230350Dec 1, 2022Equipment. DP: Customer Support Program 19LE05 expired December 1, 2022.
• 10220210Aug 31, 2022Suspension. TSB: Some 2010 ? 2023 model year GX 460 (KDSS-equipped) vehicles may exhibit a condition where the vehicle leans more than 20 mm (0.79 in.) from left to right when viewed from the rear of the vehicle. Follow the Repair Procedure in this bulletin to address this condition
• 10217806Jul 28, 2022Air bags. CSP: Takata CSP Coverage Job Aid - published 7.28.2022
• 10217805Jul 28, 2022Air bags. CSP: On July 30, 2018, a settlement of claims for Economic Loss related to Takata airbag inflators was approved for full implementation. The settlement includes Lexus?s agreement to provide a Customer Support Program (?CSP?) for 2002-2019 model year (MY) vehicles originally equipped with certain Takata airbag inflators or repaired under a recall with Takata airbag inflators to provide coverage for repairs of the…
• 10214355Apr 13, 2022Equipment. Lexus Safety Recall and Service Campaign - Technician Certification Requirements 4.13.2022
• 10209023Feb 24, 2022Air bags. TSB: Some 2005 ? 2022 model year Lexus vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this service bulletin is to provide general guidelines and procedures for odor remediation.
• 10207962Jan 28, 2022Electrical system. TSB: This Service Bulletin includes guidelines meant to help determine whether to repair or replace a wire harness assembly based on damage type. This Service Bulletin should be used in conjunction with the applicable model and model year Electronic Wiring Diagram (EWD) and/or Repair Manual.
• 10207945Jan 12, 2022Equipment, Tires, Wheels. POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Lexus. This information must be kept near the point of vehicle sale and be available to any customer that requests it. Customers can find this information on the Owner?s section of Lexus.com. Dealers can locate a copy of this guide on the Claims Processing & Resource Center in…
• 10204556Nov 10, 2021Back-over prevention (rear camera), Forward collision avoidance, Lane departure. TSB: For proper calibration of the millimeter wave radar sensor, the vehicle and radar target must be on a level surface with a consistent plane. If a level surface with a consistent plane is not available, use the Floor Slope Compensation Procedure in this service bulletin in conjunction with the appropriate model and model year Repair Manual instructions when adjusting the millimeter wave radar sensor.
• 10201403Jul 26, 2021Equipment. OBSOLETE NOTICE July 26, 2021: This bulletin is now obsolete. Please see L-SB-0024-21.
• 10201401Jul 26, 2021Equipment. TSB: Some 2007 ? 2022 model year Lexus vehicles in particular geographic areas may exhibit a condition where the HVAC evaporator drain hose has become obstructed with an insect nest. An insect repellent drain hose tip (ARINIX® Tip) is available to help minimize future occurrences of this environmental condition. For some models, a new drain hose is required to properly fit the ARINIX® Tip. Follow the procedures in…
• 10201350Jul 2, 2021Suspension, Equipment. OBSOLETE NOTICE July 2, 2021: This bulletin is now obsolete. Please see L-SB-0015-21.
• 10201347Jul 1, 2021Equipment, Suspension, Body and structure. TSB: Some 2010 ? 2021 model year GX 460 (KDSS-equipped) vehicles may exhibit a condition where the vehicle leans more than 20 mm (0.79 in.) from left to right when viewed from the rear of the vehicle. Follow the Repair Procedure in this bulletin to address this condition.
• 10198149May 24, 2021Equipment. Pol: updates to the 2014-2021 lexus universal flat rate manual
• 10190468Mar 31, 2021Air bags. Lexus Safety Recall and Service Campaign - Technician Certification Requirements
• 10190455Mar 16, 2021Steering, Wheels. TT: Some customers may encounter Bluetooth® connectivity concerns such as: ?Difficulty to pair the phone. ?Intermittent Bluetooth® failure to connect to the vehicle when first turning on the vehicle. ?Various Bluetooth® Audio functions are no longer functioning with customer?s phone such as ability to change the track using the steering wheel controls. These concerns can be caused by changes made on the customer?s…
• 10182961Oct 30, 2020Visibility (wipers, defrost, mirrors), Equipment. TT: HVAC drain tube is found to blocked/clogged.
• 10183269Oct 16, 2020Fuel system. TSB: This Service Bulletin provides updated non-electric water pump leak inspection and diagnostic tips for some 2008 ? 2021 model year Lexus vehicles.
• 10179782Aug 24, 2020Equipment, Electrical system. Ti: technical instructions for limited service campaign klg customer support program 19le05 safety connect system ? Vehicle location inaccurate
• 10179697Aug 5, 2020Transmission and drivetrain. TSB: Vehicles may display evidence of a fluid leak or fluid seep from powertrain components. This bulletin explains how to determine the differences between a fluid leak versus a fluid seep. Cases that are determined to be a ?leak? should be repaired accordingly and will be covered under warranty if applicable. Cases that are determined to be a ?seep? should be documented on the repair order and inspected at the…
• 10179694Aug 5, 2020Equipment. TT: HVAC drain tube is found to blocked/clogged.
• 10179601Aug 5, 2020Transmission and drivetrain, Engine. TSB: Vehicles may display evidence of a fluid leak or fluid seep from powertrain components. This bulletin explains how to determine the differences between a fluid leak versus a fluid seep. Cases that are determined to be a ?leak? should be repaired accordingly and will be covered under warranty if applicable. Cases that are determined to be a ?seep? should be documented on the repair order and inspected at the…
• 10179598Aug 5, 2020Equipment. TT: HVAC drain tube is found to blocked/clogged.
• 10178788Jul 20, 2020Engine, Electrical system. TT: The new DCA-8000 Diagnostic Charger may cause your facility?s Ground Fault Circuit Interrupter (GFCI) breaker to trip. A GFCI breaker can be tripped for various reasons, one of the reasons may be related to the DCA-8000. We are investigating this issue to determine the root cause. Other reasons the GFCI breaker may trip ?Circuit demand is too high for GFCI rating ?Worn out GFCI internal contacts ?Improper…
• 10177780Jun 23, 2020Wheels. TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. ST004-01, SU001-08, and L-SB-0174-08. The aforementioned bulletins are obsolete, and any printed versions should be discarded. Be sure to review the entire content of this service bulletin before proceeding. This Service Bulletin provides best practice procedures for vehicle pulling complaint, diagnosis, and repair…
• 10176283May 1, 2020Equipment. Safety Recall and Service Campaign - Technician Certification Requirements
• 10174926Apr 27, 2020Body and structure. TSB: Some 2010 ? 2020 model year GX 460 (KDSS-equipped) vehicles may exhibit a condition where the vehicle leans more than 20 mm (0.79 in.) from left to right when viewed from the rear of the vehicle. Follow the Repair Procedure in this bulletin to address this condition.
• 10174889Apr 6, 2020Equipment. TSB: OBSOLETE NOTICE April 06, 2020: This bulletin is now obsolete. Please see L-SB-0008-20. Replacement Certification Labels and VIN Plates
• 10174888Apr 6, 2020Equipment. TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. L-SB-0048-08, PG007-07, PG016-01, PG015-01, PG004-97, PG003-97, PG003-93, PG002-90, L-SB-0048-08, PG007-07, PG016-01, PG015-01, PG004-97, PG003-97, PG003 93, and PG002-90. The aforementioned bulletins are obsolete, and any printed versions should be discarded.
• 10173987Mar 26, 2020Equipment. TT: For proper calibration of the millimeter wave radar sensor, the vehicle must be on a level surface. If a level surface is not available, this tech tip should be used in conjunction with the repair manual to set the angle of the front millimeter wave radar sensor and reflector height before performing beam axis adjustment.
• 10173986Mar 26, 2020Equipment. TT: In certain cases of leaking air conditioning systems, the root cause of the leak is inadvertently overlooked, causing a repeat repair. To improve customer satisfaction and repair A/C system leaks in one dealer visit, Toyota has developed a set of guidelines for evaluating A/C system components.
• 10173793Mar 9, 2020Equipment, Electrical system. TT: Some customers may encounter Bluetooth® connectivity concerns such as: ?Difficulty to pair the phone. ?Intermittent Bluetooth® failure to connect to the vehicle when first turning on the vehicle. ?Various Bluetooth® Audio functions are no longer functioning with customer?s phone such as ability to change the track using the steering wheel controls. These concerns can be caused by changes made on the customer?s…
• 10172827Feb 6, 2020Equipment. TSB: February 06, 2020: This bulletin is now obsolete. Please see L-SB-0003-20.
• 10172825Feb 6, 2020Equipment. TSB: Some 2006 ? 2020 model year Lexus vehicles may exhibit odors that naturally occur from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bulletin to minimize the odors experienced.
• 10170747Dec 10, 2019Equipment, Electrical system. Dealer Package: December 10, 2019 Vehicle total has decreased by approximately 6,260 vehicles. Vehicles were moved from Customer Support Program 19LE05 and added to Limited Service Campaign KLG.
• 10170746Dec 10, 2019Electrical system, Equipment. TSB: REVISION NOTICE December 10, 2019 Rev2: ? The Parts Information and Required Tools & Equipment sections have been updated. November 14, 2018 Rev1: ? The Parts Information and Required Tools & Equipment sections have been updated. Any previous printed versions of this bulletin should be discarded. SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. L-SB-0074-14. ?
• 10170745Dec 10, 2019Equipment, Electrical system. Dealer Package: 12/10/2019 Vehicle total has increased by approximately 6,260 vehicles. Vehicles were moved from Customer Support Program 19LE05 and added to Limited Service Campaign KLG. The Data Communication Module (DCM) in the subject vehicles are equipped with software to identify the location of the vehicle using the Global Positioning System (GPS) to support features of the Safety Connect system.
• 10169439Nov 27, 2019Suspension. TSB: Some 2014 ? 2020 model year GX460 vehicles may exhibit a leak from the front shock absorbers that has been identified by the customer. Improved front shock absorbers have been made available. Please follow the Repair Procedure in this bulletin to address this condition. NOTE The improved shock absorbers may change the ride characteristics of the vehicle and make suspension stiffness more noticeable. Ensure the…
• 10169332Nov 18, 2019Equipment. TT: HVAC drain tube is found to blocked/clogged.
• 10169323Nov 13, 2019Equipment, Electrical system. Dealer Package: The Data Communication Module (DCM) in the subject vehicles is equipped with software to identify the location of the vehicle using the Global Positioning System (GPS) to support features of the Safety Connect system. Due to incorrect programming in the DCM software, after November 2nd, 2019, the GPS coordinates for this system will be calculated incorrectly. This will cause the system to use…
• 10168534Oct 17, 2019Equipment. Technical Instructions: TECHNICAL INSTRUCTIONS FOR LIMITED SERVICE CAMPAIGN KLG CUSTOMER SUPPORT PROGRAM 19LE05 SAFETY CONNECT SYSTEM ? VEHICLE LOCATION INACCURATE CERTAIN 2011 ? 2017 MODEL YEAR LS, 2013 ? 2016 MODEL YEAR LS Hybrid, 2011 ? 2017 MODEL YEAR GS, 2016 ? 2017 MODEL YEAR GS-F, 2013 ? 2017 MODEL YEAR GS Hybrid, 2010 ? 2017 MODEL YEAR IS, 2011 ? 2015 MODEL YEAR IS-C, 2013 ? 2014 MODEL YEAR IS-F, 2015 ?…
• 10168533Oct 17, 2019Equipment. Dealer Package: The Data Communication Module (DCM) in the subject vehicles is equipped with software to identify the location of the vehicle using the Global Positioning System (GPS) to support features of the Safety Connect system. Due to incorrect programming in the DCM software, after November 2nd, 2019, the GPS coordinates for this system will be calculated incorrectly. This will cause the system to use…
• 10168532Oct 17, 2019Equipment. Area Letter: The Data Communication Module (DCM) in the subject vehicles is equipped with software to identify the location of the vehicle using the Global Positioning System (GPS) to support features of the Safety Connect system. Due to incorrect programming in the DCM software, after November 2nd, 2019, the GPS coordinates for this system will be calculated incorrectly. This will cause the system to use incorrect…
• 10168531Oct 17, 2019Equipment. Region Email: The Data Communication Module (DCM) in the subject vehicles is equipped with software to identify the location of the vehicle using the Global Positioning System (GPS) to support features of the Safety Connect system. Due to incorrect programming in the DCM software, after November 2nd, 2019, the GPS coordinates for this system will be calculated incorrectly. This will cause the system to use…

← All problems reported for the 2017 Lexus GX460