2020 Lincoln Corsair Technical Service Bulletins

203 technical service bulletins (TSBs) are on record for the 2020 Lincoln Corsair. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10189581Mar 25, 2021Electrical system. For 2018-2021 EcoSport/Expedition/Navigator, 2019-2021 Ranger/Transit Connect, 2020-2021 Escape/Explorer/SuperDuty/Transit/Aviator/Corsair, 2021 Bronco Sport/F-150/Mustang/Mach-E the Workshop Manual (WSM) diagnostics may direct to replace a module on vehicles that use Ford Diagnosis and Repair System (FDRS). First, an FDRS session must be created on the vehicle prior to removing the faulted module.
• 10189769Mar 17, 2021Transmission and drivetrain. Some 2020 Escape/Corsair vehicles equipped with all-wheel drive (AWD) may exhibit a grinding noise during low speed turns from the left rear half shaft area. This may be due to internal contact within the seal. To correct the condition, follow the Service Procedure to replace the left rear half shaft seal.
• 10189556Mar 4, 2021Transmission and drivetrain. Some 2020-2021 Escape and 2021 Corsair vehicles equipped with a HF45 transmission may exhibit a rattle noise on cold start up when only when engine is running. This noise may be more prevalent in cold weather conditions, typically at or below 0’C (32’F). Engineering is currently working to resolve this issue. Inform customers that Ford is working on a calibration release for end of April 2021.
• 10187981Feb 15, 2021Transmission and drivetrain. Some 2019-2021 Edge/Nautilus, 2020-2021 Escape/Corsair, 2021 Bronco Sport vehicles equipped with all wheel drive (AWD) may exhibit chatter/shudder during low speed turning events due to fluid contamination. Drain and refill the rear drive unit (RDU), refer to Workshop Manual Section (WSM) 205-02. Drive for 8 km (5 miles) in stop and go conditions with right and left turns and re-evaluate. If the issue is still…
• 10187723Feb 15, 2021Brakes, Equipment, Electrical system. In some of the affected vehicles, the Electric Brake Booster (EBB) may contain a cracked solenoid valve plunger that may break and move out of position.
• 10187935Feb 4, 2021Equipment. Some 2020 Escape, 2020-2021 Corsair, 2021 Bronco Sport and 2021 Mustang Mach-E vehicles may exhibit DTC C1B00:62 present in the PSCM with any of the following messages displayed: Service Advance Trac, Hill Start Assist Not Available, Lane Keeping Sys. Malfunction Service Required, or Pre-Collision Assist Not Available. This may be due to a disconnected or discharged battery, recent PSCM or anti-lock brake system…
• 10187930Feb 3, 2021Equipment. Some 2018-2020 Ford and Lincoln vehicles equipped with TCU and WiFi Hotspot, May display Vehicle Hotspot feature not enabled on this vehicle when attempting to enter the Hotspot menu. When using the FordPass/Lincoln Way application, the customer may receive a message saying Wi-Fi has been disabled from this vehicle. Check the vehicle specifications or vehicle build information for the mfal code on the PTS website…
• 10186564Jan 5, 2021Electrical system. Some 2019-2020 Edge/Nautilus/Ranger, 2020 Escape and 2020-2021 Corsair/Explorer vehicles equipped with a 2.0L/2.3L EcoBoost may exhibit a lack of power with an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P02AB, P0243, P0299, P1464, P25B3, P25B4, P2AB7, P2AB8 and/or P2AB9. This may be due to a missing wastegate actuator e-clip.
• 10186563Jan 5, 2021Equipment. Some 2020 Ford and Lincoln vehicles may exhibit the vehicle locator feature display the vehicle location incorrectly when using the Ford Pass/Lincoln Way mobile app. Customers may report that the vehicle location that is displayed is the Ford manufacturing facility were the vehicle was assembled, yet all other features work as intended. This may be due to the vehicle location not updating since assembly.
• 10184625Dec 2, 2020Equipment, Electrical system. Some 2020 Escape and 2020-2021 Corsair vehicles may exhibit DTC C1B00:62 present in the PSCM with any of the following messages displayed: Service Advance Trac, Hill Start Assist Not Available, Lane Keeping Sys. Malfunction Service Required, or Pre-Collision Assist Not Available. This may be due to a disconnected or discharged battery, recent PSCM or anti-lock brake system (ABS) module reprogram or configuration…
• 10183392Nov 18, 2020Equipment, Transmission and drivetrain. Some 2020 Edge/Nautilus/Escape/Corsair/Transit Connect vehicles with and 8F35/8F40 transmission built on or before 30-Sep-2020 may exhibit an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble codes (DTCs) P0741 and/or P1744 present or stored in the powertrain control module (PCM). This may be due to the torque converter and a pump stator bushing leak. Replacement of only the torque…
• 10183569Nov 11, 2020Fuel system, Engine cooling, Equipment. Some 2019 MKC, 2019-2020 Edge/Nautilus/Escape/Ranger, 2020 Corsair, 2019-2021 Explorer vehicles equipped with 2.0L and 2.3L EcoBoost engines may exhibit a light to moderate ticking type noise at idle (600-700 RPM). The noise is usually more prominent in the area of the high-pressure fuel pump, located on the top of the engine just behind the number 4 ignition coil. This noise is not detrimental to engine function…
• 10183563Nov 6, 2020Equipment, Fuel system. Some 2020 Escape/Corsair vehicles may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P0442, P0455, P0456, and/or P0457. This may be due to damage to the carbon canister which may have occurred during vehicle transportation. This condition may not occur for a few hundred miles/km or equivalent key cycles. Inspect the left side underbody air deflector for damage.
• 10183415Nov 3, 2020Visibility (wipers, defrost, mirrors), Body and structure. Some 2020 Escape/Corsair vehicles equipped with a roof opening panel may exhibit a bounce back when closing. This may be more noticeable when the engine is running. This may be due to the glass panel adjustment. To correct the condition, follow the Service Procedure steps to adjust the roof opening panel glass.
• 10181931Oct 29, 2020Electrical system, Transmission and drivetrain. Some 2018-2020 Ford and Lincoln vehicles may exhibit inoperative remote features via the Ford Pass/Lincoln Way mobile app, incomplete user authorization, no modem electronic serial number (ESN) displayed or DTCs U2100 and/or B156D in the telematics control unit (TCU). These symptoms may persist even after performing a TCU software update and/or replacement. To correct this condition, start a new session with the…
• 10181913Oct 26, 2020Equipment, Electrical system. Some 2018-2020 Ford and Lincoln vehicles equipped with TCU and WiFi Hotspot, May display Vehicle Hotspot feature not enabled on this vehicle when attempting to enter the Hotspot menu. When using the FordPass/Lincoln Way application, the customer may receive a message saying Wi-Fi has been disabled from this vehicle. Check the vehicle specifications or vehicle build information for the mfal code.
• 10181912Oct 26, 2020Electrical system, Equipment. Some 2017-2020 Ford and Lincoln vehicles equipped with a telematics control unit (TCU) may exhibit incomplete user authorization, inoperative remote features and/or a message stating the system cannot access the Lincoln/FordPass Connect feature in the application due to being a fleet vehicle. Replacing the TCU will not resolve this condition. Engineering is currently investigating this condition. Inform customers…
• 10181924Oct 20, 2020Electrical system. Some 2019 MKZ, 2019-2020 EcoSport/Mustang/Continental/Fusion/F-150/Transit Connect/Ranger/Edge/Nautilus and 2020 Escape/Corsair/Aviator/Explorer/Expedition/Navigator/F-Super Duty vehicles with SYNC 3 may experience various SYNC performance related concerns. To correct the condition, follow the Service Procedure.
• 10181922Oct 13, 2020Equipment. Some 2020 Escape/Corsair vehicles may exhibit water dripping on or near the driver's foot while driving with the air conditioning (A/C) on. This maybe due to the climate control housing. To correct the condition, follow the Service Procedure to install a drain extension.
• 10180428Sep 25, 2020Engine cooling. Some 2009-2020 Ford and Lincoln vehicles equipped with turbochargers may exhibit an oil leak from the turbocharger oil supply or return tubes, O-rings or 6.7L pedestal gasket. Although oil may collect on the turbocharger, it is very rare for a turbocharger to leak oil. To isolate the source of the leak, refer to Workshop Manual (WSM), Section 303-00 General Information > Diagnosis and Testing > Engine > Engine Oil…
• 10180536Sep 21, 2020Electronic stability control, Brakes, Electrical system. Some 2020 Escape/Corsair vehicles built on or before 2-Sep-2020 may exhibit an illuminated anti-lock brake system (ABS) and/or stability-traction control lamp with diagnostic trouble codes (DTCs) C0031, C0034 and/or C0051. This may be due to the ABS wheel speed sensor harness rubbing on the front wheels. To correct the condition, follow the Service Procedure steps to inspect the ABS wheel speed sensor harness and…
• 10180341Sep 15, 2020Transmission and drivetrain, Equipment. Some 2020 Escape/Corsair vehicles equipped with an 8F24, 8F35 or 8F40 transmission may exhibit an unable to engage park condition with an illuminated powertrain malfunction (wrench) lamp and diagnostic trouble code (DTC) P07E4 stored in the powertrain control module (PCM) memory. There will also be a shift system fault warning message displayed and the electronic parking brake will be automatically applied when…
• 10180340Sep 9, 2020Electrical system, Back-over prevention (rear camera). Some 2019 MKZ, 2019-2020 Mustang/Continental/Fusion/F-150/Transit Connect/ Ranger/Edge/Nautilus and 2020 Escape/Corsair/Aviator/Explorer/Expedition/ Navigator/F-Super Duty vehicles with SYNC 3 may experience various SYNC performance related concerns. To correct the condition, follow the Service Procedure.
• 10180337Sep 4, 2020Electrical system, Brakes. Some 2020 Escape/Corsair vehicle may exhibit an illuminated ABS and/or stability-traction control lamp with diagnostic trouble codes (DTCs) C0031, C0034, and/or C0051. This may be due to the ABS wheel speed sensor harness rubbing on the front wheels. To correct the condition, follow the Service Procedure steps to inspect the ABS wheel speed sensor harness and install the pigtail service kit.
• 10179156Aug 31, 2020Brakes. This article supersedes TSB 20-2135 to correct the Service Procedure. Some 2020 Explorer/Aviator/Corsair vehicles built on or before 23-Jul-2020 may inadvertently activate the reverse braking assist system while backing up. This may be perceived as the system is too sensitive to surrounding objects. This may be due to the software in the image processing module B (IPMB).
• 10179153Aug 27, 2020Electrical system. Some 2020 Escape vehicles equipped with a 1.5L EcoBoost engine and built on or before 11-Jan-2020 or 2020 Escape/Corsair vehicles equipped with 2.0L/2.3L EcoBoost engine and built on or before 18-Mar-2020 may exhibit a slow fuel fill and/or spit back during refueling. This may be due to the software in the powertrain control module (PCM). To correct the condition, follow the Service Procedure to reprogram the PCM.
• 10179182Aug 21, 2020Body and structure. Some 2020 Escape/Corsair vehicles equipped with a roof opening panel may exhibit a flutter, hum, and/or wind noise while driving. This may be due to an incorrectly adjusted roof opening panel. Components should not be replaced for this condition. Adjust the roof opening panel so that the front edge of the sliding glass panel is contacting the margin seal. Refer to Workshop Manual (WSM), Section 501-17. After…
• 10179359Aug 13, 2020Visibility (wipers, defrost, mirrors), Equipment. Some 2020 Escape/Corsair vehicles equipped with a roof opening panel may exhibit a flutter, drone, hum, and/or vibration noise while driving. This may be due to an incorrectly adjusted roof opening panel. Components should not be replaced for this condition. Adjust the roof opening panel so that the front edge of the sliding glass panel is contacting the margin seal. Refer to Workshop Manual (WSM), Section 501-17…
• 10179344Aug 12, 2020Electrical system, Engine, Equipment. Some 2020 Ford and Lincoln vehicles equipped with a TCU may exhibit incomplete user authorization, no authorization pop-up on the SYNC infotainment system, vehicle connectivity concerns, vehicle location disabled message and/or various FordPass/LincolnWay App command/control concerns. To correct these conditions, ensure that customer connectivity settings (CCS) are turned on in the SYNC system.
• 10179334Aug 12, 2020Electrical system. Some 2017-2020 Ford and Lincoln vehicles equipped with a TCU may exhibit inoperative remote features via Ford Pass/Lincoln Way mobile app , incomplete user authorization and/or no modem electronic serial number (ESN) displayed. To correct this condition prior to programming, remove the TCU fuse for 5 minutes then reinstall. Delete all previous session files for the vehicle. Verify that the electronic serial number…
• 10179121Aug 12, 2020Equipment, Electrical system. Some 2019 MKZ, 2019-2020 Mustang/Continental/Fusion/F-150/Transit Connect/ Ranger/Edge/Nautilus and 2020 Escape/Corsair/Aviator/Explorer/Expedition/ Navigator/F-Super Duty vehicles with SYNC 3 may experience various SYNC performance related concerns. To correct the condition, follow the Service Procedure
• 10179330Aug 11, 2020Equipment, Electrical system. Some 2020 Ford and Lincoln vehicles equipped with SYNC 3 may not be able to properly disable remote start through the SYNC interface. This may be due to the current level SYNC software installed. To correct this condition, program the SYNC module. Refer to Workshop Manual (WSM), Section 415-00. If no update is available or the condition persists after programming, refer to WSM, Section 303-06 for further diagnosis.
• 10179345Aug 7, 2020Equipment. Some 2020 Escape/Corsair vehicles equipped with a roof opening panel may exhibit a flutter, drone, hum, and/or vibration noise while driving. This may be due to an incorrectly adjusted roof opening panel. Adjust the roof opening panel so that the front edge of the sliding glass panel is contacting the margin seal. Refer to Workshop Manual (WSM), Section 501-17. After adjustment perform a power roof opening panel…
• 10179314Aug 5, 2020Seats, Steering. Some 2020 Corsair/Aviator vehicles may exhibit inoperative heated/cooled seat and/or steering wheel functionality when starting the vehicle using remote start. The heated/cooled seats and/or heated steering wheel may not turn on when previously set to on/auto. This may be due to software in the heating, ventilation, and air conditioning (HVAC) control module. To correct this condition, reprogram the HVAC control…
• 10177876Jul 29, 2020Back-over prevention (rear camera), Electrical system, Equipment. Some 2020 Corsair/Explorer/Super Duty vehicles built on or before 27-May-2020 and not equipped with a 360-camera system may exhibit various rear parking aid camera concerns such as poor image quality, flickering and/or completely inoperative. If a vehicle exhibits any of these conditions, replace the rear parking aid camera. Refer to Workshop Manual (WSM), Section 413-13.
• 10177863Jul 13, 2020Body and structure. This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended.
• 10177704Jul 10, 2020Steering. Some 2020 Escape/Corsair vehicles built on or before 26-Jun-2020 may exhibit a lack of power steering assist with DTC U3000 in the PSCM. This DTC is set when a battery charger is installed on the vehicle and the ignition is cycled ON. For vehicles that set this DTC due to the use of a battery charger, the DTC can be cleared and power steering assist restored without replacement of the PSCM.
• 10176989Jun 23, 2020Electrical system. Some 2020 Navigator and 2020 Corsair vehicles may have diagnostic trouble codes (DTCs) P1269, B1A56, B1D55, B1589, and/or B1590 through B1598 stored in the RFA module with no reported customer symptoms. If these DTCs are detected during pre-delivery inspection (PDI) or while diagnosing unrelated conditions, they should be disregarded.
• 10177033Jun 22, 2020Electrical system. Some 2020 Escape/Corsair/Explorer/Aviator vehicles may have diagnostic trouble code (DTC) U0100 stored in the audio front control module (ACM). This DTC will not cause observable conditions or warning indicators for the customer. If this DTC is detected during pre-delivery inspection (PDI) or while diagnosing unrelated conditions, it should be disregarded.
• 10177042Jun 17, 2020Electrical system, Equipment. Some 2016-2020 Ford and Lincoln vehicles equipped with a SYNC 3 Touchscreen may experience the volume control unresponsive from the Front Control Interface Module (FCIM) and steering volume controls when using Apple Car Play. When the Apple device is removed, volume control is restored. This is due to a concern with the Waze Navigation App software and Apple iOS version.
• 10176944Jun 15, 2020Equipment. Some 2020 Corsair vehicles may exhibit diagnostic trouble codes (DTCs) P1269, B1A56, B1D55, B1589, and/or B1590 through B1598 stored in the RFA module with no detectable customer symptoms. If these DTCs are detected during pre-delivery inspection (PDI) or while diagnosing unrelated conditions, they should be ignored.
• 10176933Jun 2, 2020Equipment. Some 2020 Ford and Lincoln vehicles equipped with SYNC 3 may exhibit the infotainment system stating in Michigan when trying to select a point of interest using the push to talk feature on the navigation system. Engineering is currently working on a solution for this condition, which is expected to be available in July. Please monitor OASIS for additional information and schedule service appointments for…
• 10176123May 29, 2020Electrical system. Some 2012-2020 Ford and Lincoln vehicles equipped with a TCU may exhibit an inoperative remote start with a 'Vehicle Failed To Start' message when using MyFord Mobile/Ford Pass/Lincoln Way mobile applications. The cellular cloud systems will only allow two remote start requests from the MyFord Mobile/Ford Pass/Lincoln Way apps without a vehicle drive event occurring. If a third remote start request is received, a…
• 10176119May 22, 2020Electrical system. Some 2020 Ford and Lincoln vehicles may exhibit a symptom of no ability to schedule a remote start event using the FordPass or Lincolnway app. If only the scheduling portion of the remote start system is not functioning, please ensure that the latest level of SYNC software has been installed.
• 10176118May 21, 2020Steering. Some 2020 Escape/Corsair vehicles may exhibit a lack of power steering assist with DTC U3000 in the PSCM. This DTC is set when a battery charger is installed on the vehicle and the ignition is cycled on. For vehicles that set this DTC due to the use of a battery charger, the DTC can be cleared and power steering assist restored without replacement of the PSCM. To clear this DTC using the FDRS scan tool, select and…
• 10175896May 18, 2020Fuel system. Some 2020 Escape/Corsair vehicles equipped with a 1.5L/2.0L/2.3L EcoBoost engine and built on or before 15-Nov-2019 may exhibit a fuel gauge that does not move and/or diagnostic trouble code (DTC) P144F in the powertrain control module (PCM). This may be due to the fuel tank assembly. To correct the condition, follow the Service Procedure steps to replace the fuel tank.
• 10171966Feb 24, 2020Transmission and drivetrain, Equipment. Some 2018-2020 vehicles equipped with the 8F24, 8F35, 8F40, or 8F57 transmissions may have a trace amount of transmission fluid in the main control electrical connector. This is due to the connector being submerged in transmission fluid during the main control manufacturing process. A trace amount should be considered normal and will not affect the function of the transmission. Do not attempt a repair for this…
• 10171034Jan 31, 2020Steering. In some of the affected vehicles, the power steering control module (PSCM) may exhibit a fault resulting in a lack of power steering assistance at start up. A steering assist fault message may also be displayed in the message center. A lack of power steering assistance may result in higher effort steering the vehicle.
• 10170929Jan 20, 2020Electrical system. Some 2020 Escape/Corsair, Edge, Explorer, Fusion, Ranger, Transit Connect Vehicles equipped with a TCU may exhibit a "Battery Backup Component Failure" message in the cluster. This may be accompanied by DTC 1477-09 - Backup Battery Component Failure. This may be due to the TCU experiencing a sudden temperature change. To correct this condition, reprogram the TCU using the appropriate Ford diagnostic scan tool.
• 10169898Dec 20, 2019Seats, Electrical system. Some 2015-2019 F-150, 2015-2020 Explorer, 2017-2019 F-Super Duty, 2017-2020 Continental, 2018-2020 Expedition/Navigator, 2016-2018 MKX, 2019-2020 Nautilus, 2020 Aviator/Corsair and 2013-2020 MKZ vehicles equipped with multi-contour seats may exhibit intermittent multi-contour seat operation and/or massage and lumbar adjust inoperative from the seat switch or SYNC screen with or without diagnostic trouble code (DTC)…

← All problems reported for the 2020 Lincoln Corsair