2021 Lincoln Corsair Technical Service Bulletins

176 technical service bulletins (TSBs) are on record for the 2021 Lincoln Corsair. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10199514Jul 26, 2021Electrical system. Some 2020-2021 Explorer/Aviator/Corsair vehicles may exhibit an intermittent blue screen on the center infotainment display for one or more cameras when the 360 degree camera view is activated. To correct the condition, reprogram the image processing module B (IPMB) using the latest software level of the appropriate Ford diagnostic scan tool. Once complete, perform the 360 degree camera alignment procedure. Refer…
• 10199511Jul 21, 2021Electrical system. Some 2020-2021 Corsair/Nautilus/Navigator/Aviator, 2021 F-150/Mustang Mach-E vehicles equipped with Phone-as-a-Key may have diagnostic trouble code(s) (DTC) U200D:15, U200E:15, U200F:15, B15**:31, B15**:49 and/or B15A5:56 stored in the remote function actuator (RFA) module. If any of these DTCs are detected during normal diagnostics, clear the DTCs, reflash RFA to the latest software level and start a new Ford…
• 10199519Jul 19, 2021Seats. Some 2020-2021 Explorer/Aviator/Corsair vehicles may experience seat pan looseness, lateral movement and/or clunk/thump noise on turns. To correct the condition, follow the Service Procedure steps to reinforce the cushion hook.
• 10199497Jul 1, 2021Fuel system, Engine cooling. Some 2019 MKC, 2019-2021 Edge/Nautilus/Escape/Ranger/Explorer, 2020-2021 Corsair, and 2021 Bronco Sport vehicles equipped with 2.0L and 2.3L EcoBoost engines may exhibit a light to moderate ticking type noise at idle (600-700 RPM). The noise is usually more prominent in the area of the high-pressure fuel pump, located on the top of the engine just behind the number 4 ignition coil. This noise is not detrimental to…
• 10198658Jun 28, 2021Equipment, Electrical system. Some 2015-2021 Edge, 2016-2018 MKX, 2019-2021 Nautilus, 2018-2021 Expedition/Navigator, and 2020-2021 Escape/Corsair/Explorer/Aviator vehicles may exhibit an inoperative power liftgate. This may be due to the rear gate trunk module (RGTM) software. To correct the condition, reprogram the RGTM using the latest software level of the appropriate Ford diagnostic scan tool.
• 10198656Jun 28, 2021Equipment. Some 2021 Escape/Corsair vehicles may exhibit a concern where the climate control temperature setting is no longer displayed on the SYNC touchscreen. To correct this condition, run the APIM configuration application on the Ford Diagnostic and Repair System (FDRS) scan tool. Refer to the Workshop Manual, Section 415-00. For claiming, use causal part number 14G371 and applicable labor times from Section 10 of the…
• 10198640Jun 14, 2021Equipment. Some 2019-2021 Ford and Lincoln vehicles may exhibit an intermittent audio echo/robotic voice heard during a bluetooth phone call by the person that is not in the vehicle. Using Apple CarPlay and Android Auto instead of Bluetooth can help alleviate the concern. Also turning on, then off, the privacy setting in the SYNC touchscreen can temporarily alleviate the concern. Engineering is currently investigating this…
• 10194425May 24, 2021Electrical system, Equipment. Some 2017-2021 Ford and Lincoln vehicle owners may experience a condition of missing Authorization, Command and Control, Battery Charging Details or Phone-as-a-Key setup buttons/selections in their FordPass or LincolnWay App. This condition is due to an error within the FordPass or LincolnWay App and not due to a concern on the vehicle. Verify that the customers FordPass or LincolnWay App is at the latest version.
• 10194422May 20, 2021Equipment, Visibility (wipers, defrost, mirrors). Some 2020-2021 Corsair vehicles may exhibit a distorted view when looking at the exterior mirror glass. This may be due to the mirror glass not being fully seated into all retaining tabs and not the glass itself. Verify that the exterior mirror glass is fully seated into all of the retaining tabs before attempting any further repairs. Refer to Workshop Manual (WSM), Section 501-09.
• 10194433May 13, 2021Electrical system, Equipment. Some 2019-2020 Edge/F-150/Fusion/Continental/MKZ/Nautilus, 2019-2021 Mustang/Ranger/Transit Connect, 2020-2021 EcoSport/Escape/Expedition/Explorer/F-Super Duty/Aviator/Corsair/Navigator and 2021 Bronco Sport vehicles with SYNC 3 may experience various SYNC performance related concerns. To correct the condition, follow the Service Procedure.
• 10194413May 12, 2021Electrical system, Other or unknown. Some 2018-2021 Ford and Lincoln vehicles may not be able to perform remote commands via the FordPass/LincolnWay App due to an erroneous deep sleep message. If the vehicle has been driven within 14 days and the battery state of charge is above 9.5 volts when the deep sleep message set, this is an erroneous message. Starting and running the vehicle will clear the message and allow the remote commands to function again.
• 10194411May 6, 2021Electrical system, Equipment. Some 2020-2021 Corsair/Aviator/Navigator and 2021 Nautilus/Mach-E customers may be unable to activate Phone-as-a-key, have intermittent Phone-as-a-key connectivity, missing Phone-as-a-key button in the App, receiving Pairing Failed, Key Download Error or Connection Trouble message during Phone-as-a-key setup, Bluetooth Disconnected, Unable To Start, Backup Code Needed And/or Key Not Detected.
• 10191526Apr 29, 2021Steering. Some 2020-2021 Escape/Corsair, 2021 Bronco Sport vehicles may exhibit a lack of power steering assist with DTC U3000 in the PSCM. This DTC is set when a battery charger is installed on the vehicle and the ignition is cycled ON. For vehicles that set this DTC due to the use of a battery charger, the DTC can be cleared and power steering assist restored without replacement of the PSCM. Using the FDRS, select and run…
• 10191521Apr 28, 2021Back-over prevention (rear camera). Some 2018-2021 vehicles supported by FDRS may not list a software update for a module under the SW Updates tab although an SSM or TSB is published for a software update. This may be due to the module already being at the latest software level. A later software level may have been programmed at the assembly plant, during a previous dealer visit or by an over the air (OTA) update for vehicles that have automatic…
• 10191101Apr 26, 2021Latches, locks and linkages. 2020-2021 Corsair vehicles have a child safety lock that is located inside the opening of the rear door latch. The child safety locking switch may be difficult to see unless viewed at eye-level with the rear door latch and looking into the rear door latch opening. Verify that the child safety lock is in the correct position prior to condemning the latch assembly. The digital version of the 2020 and 2021 Corsair…
• 10191184Apr 9, 2021Electrical system. In all of the affected vehicles, the AWD module was assembled with an incorrect transistor that controls the transition between AWD and 2WD. When this transistor fails the vehicle will remain in either AWD or 2WD and not transition between the drive states. This can cause the wrench light to illuminate in the instrument cluster.
• 10191066Apr 7, 2021Seats. Some 2021 Corsair vehicles built on 4-Jan-2021 and through 19-Mar-2021 equipped with perfect position seats may exhibit the massage feature operating incorrectly on the passenger seat. Inform the customer engineering is aware of the concern and is working on a fix. Schedule a follow-up appointment for the 3rd quarter of 2021. Monitor OASIS for updates.
• 10189581Mar 25, 2021Electrical system. For 2018-2021 EcoSport/Expedition/Navigator, 2019-2021 Ranger/Transit Connect, 2020-2021 Escape/Explorer/SuperDuty/Transit/Aviator/Corsair, 2021 Bronco Sport/F-150/Mustang/Mach-E the Workshop Manual (WSM) diagnostics may direct to replace a module on vehicles that use Ford Diagnosis and Repair System (FDRS). First, an FDRS session must be created on the vehicle prior to removing the faulted module.
• 10189556Mar 4, 2021Transmission and drivetrain. Some 2020-2021 Escape and 2021 Corsair vehicles equipped with a HF45 transmission may exhibit a rattle noise on cold start up when only when engine is running. This noise may be more prevalent in cold weather conditions, typically at or below 0’C (32’F). Engineering is currently working to resolve this issue. Inform customers that Ford is working on a calibration release for end of April 2021.
• 10187981Feb 15, 2021Transmission and drivetrain. Some 2019-2021 Edge/Nautilus, 2020-2021 Escape/Corsair, 2021 Bronco Sport vehicles equipped with all wheel drive (AWD) may exhibit chatter/shudder during low speed turning events due to fluid contamination. Drain and refill the rear drive unit (RDU), refer to Workshop Manual Section (WSM) 205-02. Drive for 8 km (5 miles) in stop and go conditions with right and left turns and re-evaluate. If the issue is still…
• 10187723Feb 15, 2021Brakes, Equipment, Electrical system. In some of the affected vehicles, the Electric Brake Booster (EBB) may contain a cracked solenoid valve plunger that may break and move out of position.
• 10187935Feb 4, 2021Equipment. Some 2020 Escape, 2020-2021 Corsair, 2021 Bronco Sport and 2021 Mustang Mach-E vehicles may exhibit DTC C1B00:62 present in the PSCM with any of the following messages displayed: Service Advance Trac, Hill Start Assist Not Available, Lane Keeping Sys. Malfunction Service Required, or Pre-Collision Assist Not Available. This may be due to a disconnected or discharged battery, recent PSCM or anti-lock brake system…
• 10186564Jan 5, 2021Electrical system. Some 2019-2020 Edge/Nautilus/Ranger, 2020 Escape and 2020-2021 Corsair/Explorer vehicles equipped with a 2.0L/2.3L EcoBoost may exhibit a lack of power with an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P02AB, P0243, P0299, P1464, P25B3, P25B4, P2AB7, P2AB8 and/or P2AB9. This may be due to a missing wastegate actuator e-clip.
• 10184637Dec 16, 2020Electrical system, Equipment. Some 2020-2021 Aviator and 2021 Corsair hybrid vehicles may exhibit various concerns with the Lincoln Dual TurboCord. For diagnostic assistance, contact Webasto Charging Systems, Inc. directly at 888-219-6747 or at [email protected].
• 10184625Dec 2, 2020Equipment, Electrical system. Some 2020 Escape and 2020-2021 Corsair vehicles may exhibit DTC C1B00:62 present in the PSCM with any of the following messages displayed: Service Advance Trac, Hill Start Assist Not Available, Lane Keeping Sys. Malfunction Service Required, or Pre-Collision Assist Not Available. This may be due to a disconnected or discharged battery, recent PSCM or anti-lock brake system (ABS) module reprogram or configuration…
• 10183563Nov 6, 2020Equipment, Fuel system. Some 2020 Escape/Corsair vehicles may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P0442, P0455, P0456, and/or P0457. This may be due to damage to the carbon canister which may have occurred during vehicle transportation. This condition may not occur for a few hundred miles/km or equivalent key cycles. Inspect the left side underbody air deflector for damage.

← All problems reported for the 2021 Lincoln Corsair