2015 Lincoln MKS Technical Service Bulletins

49 technical service bulletins (TSBs) are on record for the 2015 Lincoln MKS. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11030282Mar 25, 2026Back-over prevention (rear camera), Lane departure, Other or unknown. Advance Notice – Customer Satisfaction Program 25N17 Certain 2015-2025 Model Year Multiple Vehicle Lines Rear View Camera Replacement If Required After Dealer Evaluation
• 11025611Nov 12, 2025Transmission and drivetrain, Electrical system. Some 2015-2021 Ford and Lincoln vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0011, P0012, P0014, P0015, P0016, P0017, P0018, P0019, P0021, P0022, P0024 and/or P0025. Pinpoint test HK in the Powertrain Control and Emissions Diagnosis (PC/ED) or in Section 303-14 of the Workshop Manual (WSM) has been updated to address this concern.
• 11008948Oct 10, 2024Other or unknown. While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions. While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions.
• 10251934Mar 1, 2024Transmission and drivetrain. During service and repair requiring removal and replacement of a crankshaft bolt and/or crankshaft damper, achieving proper torque of the crankshaft pulley bolt is critical. Incorrect torque may allow the bolt to loosen resulting in the timing gear breaking and engine damage. Replacement of the bolt is critical to the repair and accurately following the installation procedure in the Workshop Manual (WSM) Section…
• 10235153Apr 4, 2023Body and structure. For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist.
• 10214492Jun 16, 2022Transmission and drivetrain. Some 2015-2016 vehicles equipped with 6F50/6F55 transmission and built on 2-Nov-2015 and through 1-Feb-2016 may exhibit no reverse, 3rd and 5th gear with diagnostic trouble codes (DTCs) P0715,P0717,P0756 and/or P2701. This may be caused by the direct clutch cylinder/tone wheel (7F283) inadvertently forcing the snap ring out of position resulting in damage to the direct clutch hub (7G384). Service part (7J250)…
• 10201050Aug 27, 2021Electrical system. Some 2015-2021 Ford and Lincoln vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTC) P0011, P0012, P0014, P0015, P0016, P0017, P0018, P0019, P0021, P0022, P0024 and/or P0025. This may be due to small debris causing the VCT solenoid to stick. Before attempting any component diagnosis or replacement of the VCT solenoid, refer to Powertrain Control and Emissions Diagnosis (PC/ED) pinpoint test…
• 10194428May 24, 2021Engine cooling, Transmission and drivetrain. Some 2015-2021 Ford and Lincoln vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTC) P0011, P0012, P0014, P0015, P0016, P0017, P0018, P0019, P0021, P0022, P0024 and/or P0025. This may be due to small debris causing the VCT solenoid to stick. Before attempting any component diagnosis or replacement of the VCT solenoid, refer to Powertrain Control and Emissions Diagnosis (PC/ED) pinpoint test…
• 10180428Sep 25, 2020Engine cooling. Some 2009-2020 Ford and Lincoln vehicles equipped with turbochargers may exhibit an oil leak from the turbocharger oil supply or return tubes, O-rings or 6.7L pedestal gasket. Although oil may collect on the turbocharger, it is very rare for a turbocharger to leak oil. To isolate the source of the leak, refer to Workshop Manual (WSM), Section 303-00 General Information > Diagnosis and Testing > Engine > Engine Oil…
• 10172972Mar 9, 2020Electrical system, Other or unknown. SSM 48619 - Various Vehicles - Perimeter Alarm Armed And Original Vehicle Keys Cannot Be Accessed to Enter Vehicle - CAN Protection Strategy Some 2013-2016 Model Year Vehicles may exhibit a concern in which the Perimeter Alarm is active and the original keys cannot be accessed to disable the perimeter alarm. This concern would most often occur when a customer loses keys and the dealership is attempting to program…
• 10169986Dec 20, 2019Transmission and drivetrain. Some 2015-2020 Ford and Lincoln vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0011, P0012, P0014, P0015, P0016, P0017, P0018, P0019, P0021, P0022, P0024 and/or P0025. This may be due to small debris causing the VCT solenoid to stick. Before attempting any component diagnosis or replacement of the VCT solenoid, refer to Powertrain Control and Emissions Diagnosis (PC/ED) pinpoint test…
• 10164596Aug 14, 2019Equipment. Some 2013-2020 vehicles equipped with an EVDC air conditioning (A/C) compressor may exhibit poor A/C performance/improper climate function. To support the proper diagnosis of this compressor, the EVDC control valve tester has been provided to each U.S. dealership (339-EVDC100). Ensure the A/C system has a full charge prior to any compressor diagnostics.
• 10164508Aug 9, 2019Visibility (wipers, defrost, mirrors). Some 2010-2020 vehicles may exhibit distorted glass with a subtle orange peel pattern or streaking etched into the surface. This is caused by hydrofluoric acid which is used in some car wash solutions as a cleaning agent. Hydrofluoric acid can attack the glass and cause visual distortion and/or discoloration on the outer surface which cannot be removed by further cleaning. If this type of distortion is found…
• 10164497Aug 7, 2019Electrical system. For Ford and Lincoln vehicles that require positive or negative battery terminal replacement, it is not necessary to replace the complete battery cable harness (14300 and 14301) for this concern. Positive battery cable clamp BT4Z-14450-AA and negative battery cable clamp BT4Z-14450-BA are available for this type of repair. Do not cut or shorten the battery cable, instead carefully remove the affected battery cable…
• 10160936May 20, 2019Transmission and drivetrain. 2015-2016 Edge/MKX/Flex/MKT/MKZ/MKS/Taurus/Taurus Police/Explorer/Explorer Police vehicles built on or before 10-Jun-2016 and equipped with a 3.5L or 3.7L engine, all wheel drive (AWD) and a power transfer unit (PTU) may exhibit a PTU venting, an odor originating from the PTU, or noise originating from the PTU. These vehicles may be a candidate for rebuild using PTU Idler Gear/Shaft/Bearing Kit (GB5Z-7P258-A)…
• 10160931May 10, 2019Transmission and drivetrain. On vehicles equipped with an automatic transmission it is imperative that the converter pilot hub be greased with Motorcraft Multi-Purpose Grease Spray XL-5-A even if grease was not applied from the factory. Also verify that the engine/transmission alignment dowel pins are present as well as the engine crankshaft dowel pin, if equipped, when installing the transmission. Failure to adequately lubricate the converter…
• 10160880May 6, 2019Equipment. Some 2013-2019 vehicles equipped with a EVDC air conditioning (A/C) compressor may exhibit poor A/C performance/improper climate function and/or a diagnostic trouble code (DTC) P06A0 in the powertrain control module (PCM). To support the proper diagnosis of this compressor, the EVDC control valve tester has been developed and is available from Rotunda (339-EVDC100). A tester has been provided to each U.S.
• 10159494Apr 26, 2019Engine. SSM 47948 - 2010-2019 Various Vehicles - Turbocharged Engines - Oil Supply Filter Replacement When Replacing The Turbocharger Or The Turbocharger Oil Supply Tube For 2010-2019 vehicles equipped with turbocharged engines, when diagnosing and/or replacing turbo related concerns, all steps within the Workshop Manual (WSM) procedure must be followed including replacement of all mandatory discarded parts.
• 10159489Apr 26, 2019Electrical system, Equipment. Some 2013-2019 vehicles equipped with a EVDC air conditioning (A/C) compressor may exhibit poor A/C performance/improper climate function and/or a diagnostic trouble code (DTC) P06A0 in the powertrain control module (PCM). To support the proper diagnosis of this compressor, the EVDC control valve tester has been developed and is available from Rotunda (339-EVDC100). A tester has been provided to each U.S.
• 10156887Feb 22, 2019Electrical system. Some 2015-2017 vehicles may experience a no crank concern due to a security access key table error. When attempting to program keys or perform a parameter reset, the procedure may fail and the Integrated Diagnostic System (IDS) scan tool may display an error 232: Key Table Not Allocated. If this error message is encountered, the Body Control Module (BCM) is internally faulted and requires replacement.
• 10155575Feb 22, 2019Electrical system. Some 2015-2017 vehicles may experience a no crank concern due to a security access key table error. When attempting to program keys or perform a parameter reset, the procedure may fail and the Integrated Diagnostic System (IDS) scan tool may display an error 232: Key Table Not Allocated. If this error message is encountered, the Body Control Module (BCM) is internally faulted and requires replacement.
• 10153969Jan 17, 2019Equipment. Some 2012-2019 Vehicles may require repairs to the Smartlink system. Smartlink is a Ford Licensed Accessory which has a warranty provided by the accessory manufacturer. Warranty replacement parts for Smartlink that are ordered through Ford are not reimbursable through the Ford Motor Company warranty system. Please see the Warranty and Policy Manual for further information on Ford Licensed Accessories.
• 10152473Nov 14, 2018Engine cooling. For 2010-2019 vehicles equipped with turbocharged engines, when diagnosing and/or replacing turbo related concerns, all steps within the Workshop Manual (WSM) procedure must be followed including replacement of all mandatory discarded parts. For all turbocharged engine applications, the turbocharger oil supply filter (6C683 gas engine/6L625 connector style or 6A968 diesel engine) must be replaced whenever the…
• 10137131Apr 11, 2018Engine cooling, Equipment. Some 2007-2016 Edge/MKX/Flex/MKT/MKZ/MKS/Taurus/Police Interceptor Sedan/Explorer/Police Interceptor Utility vehicles equipped with AWD and built on or before 30-Jun-2016 may exhibit a propane or natural gas odor during idle or low speed driving. This may be due to break down of the power transfer unit (PTU) fluid caused by excessive heat. If the source of the odor is identified as originating from the PTU, an…
• 10137113Mar 30, 2018Equipment. Replacing the original equipment SYNC/Navigation system with either an aftermarket SYNC/Navigation kit or modifying original SYNC/Navigation parts to provide additional features is not recommended nor supported on any Ford, Mercury or Lincoln vehicle. Only approved Genuine Ford accessories or originally installed systems are supported and certified to function correctly with other vehicle systems.
• 10136597Feb 14, 2018Equipment. 2010-2018 various vehicles equipped with SYNC or SYNC 3 may not function when attempting to find or use the Spotify app via AppLink. As of an update released on 1/15/2018 Spotify will no longer be supporting their AppLink integration. No repair attempts should be attempted to correct this concern.
• 10119686Sep 19, 2017Equipment. Certain 2015 Model Year Flex and Taurus, 2015-2016 Model Year C-MAX, and MKS, and 2016 Model Year Edge, Fusion, MKZ, and Transit Connect Vehicles - Electronic Throttle Body Replacement
• 10109012Apr 12, 2017Equipment, Engine cooling. 2013-2017 Edge/MKX/Flex/MKT/MKZ/MKS/Taurus/Taurus Police/Explorer/Explorer Police/Continental vehicles equipped with a 3.5L or 3.7L engine, all wheel drive (AWD) and a power transfer unit (PTU) that is being repaired or replaced for an internal failure must also have the vent hose replaced due to contamination in the hose.
• 10095858Feb 27, 2017Equipment, Transmission and drivetrain. Some 2007-2016 edge/mkx/flex/mkt/mkz/mks/taurus/taurus police/explorer/explorer police equipped with all wheel drive (awd) and built on or before 30-jun-2016 may exhibit a ticking and/or knocking noise coming from the driveline area. To identify this noise, refer to workshop manual (wsm), section 100-04, and follow the symptom chart. If the source of the noise is identified as the ptu and/or internal to the ptu…
• 10095184Jan 24, 2017Equipment. Replacing the original equipment sync/navigation system with either an aftermarket sync/navigation kit or modifying original sync/navigation parts to provide additional features is not recommended nor supported on any ford, mercury or lincoln vehicle. Only approved genuine ford accessories or originally installed systems are supported and certified to function correctly with other vehicle systems.
• 10095154Jan 10, 2017Engine. To help differentiate engine oil leaks from other possible sources, a new white-colored fluorescent engine oil dye is available. Workshop manual (wsm), section 303-00 has been revised to reference the new white-colored dye. The new white fluorescent dye provides a distinct white glow to identify engine oil leaks. The new white fluorescent dye requires a pure uv diagnostic inspection lamp. The white-colored…
• 10095995Nov 17, 2016Steering. Some 2010-2016 epas equipped vehicles may exhibit steering related noises. The workshop manual (wsm) diagnostic procedures have been updated in section 211-02. When diagnosing and repairing epas steering noises use the updated procedures.
• 10091003Oct 26, 2016Tires. Setting the correct tire inflation pressure is an important step in the pre-delivery process and during routine maintenance intervals. Recent customer clinics revealed that most every vehicle in the clinics had the tire pressures set incorrectly. Tire pressures from the factory are not set to the correct specification. Maintaining the correct tire pressure is key to the ride characteristics of the vehicle and…
• 10090671Oct 14, 2016Electrical system. Some 2013-2016 fusion/escape/mkt/flex/mks/taurus, 2015-2016 mkz/mkc/edge and 2016 mkx vehicles may exhibit various radio concerns including: speaker static with key-off, no audio after vehicle is first started with diagnostic trouble code (dtc) u0184, no volume control, or a stuck cd with no slot blockage. Prior to starting normal diagnosis for any of these conditions, verify the acm is at the latest calibration…
• 10109079Sep 30, 2016Seat belts. Some vehicles may have a concern where the safety belt retractor webbing does not extract from the stowed position or exhibits excessive pressure on the occupant during use. This may be due to a normal condition which happens when the seatbelt retracts at a high rate of speed. The Workshop Manual, Section 501-20A General Procedures has been updated with a locked seatbelt retractor releasing procedure.
• 10109070Sep 21, 2016Engine cooling, Engine. The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes…
• 10109063Sep 16, 2016Transmission and drivetrain. Some 2015-2016 vehicles equipped with 6F50/6F55 transmission Built On 11/2/2015 And Through 2/1/2016 may exhibit no reverse, 3rd and 5th gear and/or DTCs P0715, P0717, P0756 and/or P2701. This may be caused by the direct clutch snap ring out of position and/or damage to the direct clutch hub. The cause of the failure is the Tone Wheel surface putting uneven load on the snap ring.
• 10091140Jun 16, 2016Equipment, Engine. 2013-2017 explorer, taurus, mks exhaust studs not missing
• 10078990May 13, 2016Electrical system. Siri eyes free functional issues using bluetooth and apple ios 9.2 and 9.2.1
• 10078988May 11, 2016Transmission and drivetrain, Equipment. Air conditioning (a/c) inoperative - diagnostic trouble code (dtc) p0645
• 10205031Apr 20, 2016Equipment. Touchscreen navigation system - arabic language - blank screen
• 10183767Apr 20, 2016Electrical system. Some 2012-2016 vehicles equipped with a touchscreen navigation system and the language set to Arabic may exhibit a blank screen. This may be the result of the ribbon cables not being fully seated inside the front display interface module (FDIM) or an improper software configuration of the FDIM.
• 10204993Oct 14, 2015Equipment, Electrical system. Demonsftration/Delivery Hold - Customer Satisfaction Program 15B32 Certain 2015 Model Year F-150, MKS, and 2016 Explorer, F-Super Duty, and
• 10059062Jul 1, 2015Steering. Ford: some vehicles and trucks are experiencing a malfunction with the heated steering wheel becoming inoperative and on demand test failure. Model 2014-15 fusion, 2011-15 mkx, 2013-15 super duty, explorer, taurus, mks, mkt, 2015 f-150, mkz, mkc, 2011-15 mkx.
• 10058601Jul 1, 2015Steering. Lincoln/ford: once procedure for heated steering wheel module program completed, heated steering wheel fails to operate properly and passes network test but fails on demand self test. Model 2011-15 fusion f-150, explorer, taurus, super duty, mkz, mkc, mks, mkt, mkx.
• 10057834Jul 1, 2015Visibility (wipers, defrost, mirrors). Ford: no service action is recommended for this condition. Please use at your discretion. Various 2010-2015 vehicles may experience a turbulence noise, similar to an helicopter noise, at highway speeds when the rear door window(s) or sunroof are open.
• 10058265May 14, 2015Electrical system. Ford 2013-2015 lincoln mkt and mks: bulletin information regarding vehicles built on 05/04/2015 may experience an drive malfunction message in the instrument cluster.
• 10058061May 14, 2015Electrical system. Ford 2013-2015 lincoln mks, mkt: bulletin information regarding mkt, mks vehicles built before 5/04/2015 may exhibit adaptive drive malfunction message in the instrument cluster.
• 10057831Jan 9, 2015Vehicle speed control. Ford: certain 2013-2015 ford fusion and taurus, 2011-2015 ford explorer, 2013-2014 ford edge and flex, 2013-2015 lincoln mks, mkx, and 2013-2014 lincoln mkt vehicles may experience problems with the cruise control speed that doesn't match the speedometer speed.

← All problems reported for the 2015 Lincoln MKS