2016 Mazda MAZDA6 Technical Service Bulletins

670 technical service bulletins (TSBs) are on record for the 2016 Mazda MAZDA6. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10099302Jun 10, 2015Electrical system. Some vehicles may experience the symptoms mentioned below, which can be fixed with the latest software update (version 55.00.650a or later). For all vehicles: • navigation or other screen freezes or reboots. • system does not recognize usb/sd card. • some menu of music source selection is grayed out. • when using the call button on the cell phone to make a call, the call sound is short. • navigation turns to a…
• 10105432May 27, 2015Equipment. Some vehicles may experience the check engine light and automatic transaxle warning light on with one or more of these dtcs stored in the tcm memory (p0842, p0847, p0872, p0877, p0780). • p0842:00 - oil pressure switch no. 1 (oil pressure switch b) stuck on • p0847:00 - oil pressure switch no. 2 (oil pressure switch a) stuck on • p0872:00 - oil pressure switch no. 3 (oil pressure switch a) stuck on • p0877:00 - oil…
• 10105445May 18, 2015Body and structure. Some vehicles may experience a rattle noise from the front door glass when driving with the window open approx. 1/2 to 4 inches (1 - 10 cm). The rattle noise may be caused by insufficient holding force of the glass run channel. To increase the holding force, the shape of glass run channel has been changed and non-woven pads have been attached to the glass run channel.
• 10105447May 15, 2015Equipment. Some vehicles may exhibit the check engine light on with dtc p0456 stored in the pcm memory. • p0456: evap system leak detected (very small leak) the concern is most likely the result of the customer not getting the fuel cap completely closed after fueling the vehicle. This causes a small fuel vapor leak and turns dtc p0456 on.
• 10105449May 13, 2015Tires. After performing recall campaign 8014j, or the vehicle vin is not applicable to 8014j, some vehicles may expe-rience tire pressure monitoring system (tpms) warning light on even if the tpms system has been properly initialized at the specified tire air pressure. This may be caused by improper tire air pressure detection by the tpms system on certain types of road surfaces.
• 10099801Apr 24, 2015Equipment. Some vehicles may experience the check engine light and automatic transaxle warning light on with one or more of these dtcs stored in the tcm memory (p0842, p0847, p0872, p0877, p0780). • p0842:00 - oil pressure switch no. 1 (oil pressure switch b) stuck on • p0847:00 - oil pressure switch no. 2 (oil pressure switch a) stuck on • p0872:00 - oil pressure switch no. 3 (oil pressure switch a) stuck on • p0877:00 - oil…
• 10099684Mar 30, 2015Equipment. Some vehicles may experience the check engine light and automatic transaxle warning light on with one or more of these dtcs stored in the tcm memory (p0842, p0847, p0872, p0877, p0780). • p0842:00 - oil pressure switch no. 1 (oil pressure switch b) stuck on • p0847:00 - oil pressure switch no. 2 (oil pressure switch a) stuck on • p0872:00 - oil pressure switch no. 3 (oil pressure switch a) stuck on • p0877:00 - oil…
• 10099685Mar 26, 2015Equipment. Some vehicles may experience the check engine light and automatic transaxle warning light on with one or more of these dtcs stored in the tcm memory (p0842, p0847, p0872, p0877, p0780). • p0842:00 - oil pressure switch no. 1 (oil pressure switch b) stuck on • p0847:00 - oil pressure switch no. 2 (oil pressure switch a) stuck on • p0872:00 - oil pressure switch no. 3 (oil pressure switch a) stuck on • p0877:00 - oil…
• 10099692Mar 10, 2015Equipment. Some vehicles may experience the check engine light and automatic transaxle warning light on with one or more of these dtcs stored in the tcm memory (p0842, p0847, p0872, p0877, p0780). • p0842:00 - oil pressure switch no. 1 (oil pressure switch b) stuck on • p0847:00 - oil pressure switch no. 2 (oil pressure switch a) stuck on • p0872:00 - oil pressure switch no. 3 (oil pressure switch a) stuck on • p0877:00 - oil…
• 10099696Mar 6, 2015Tires. After performing recall campaign 8014j, or the vehicle vin is not applicable to 8014j, some vehicles may experience tire pressure monitoring system (tpms) warning light on even if the tpms system has been properly initialized at the specified tire air pressure. This may be caused by improper tire air pressure detection by the tpms system on certain types of road surfaces.
• 10100708Feb 27, 2015Equipment. Use the following repair procedure to minimize the need to replace the catalyst converter/exhaust pipe when removing oxygen sensors and/or air fuel ratio sensors.
• 10100706Feb 27, 2015Equipment. Some vehicles may experience stains appearing on the hood, roof and/or trunk of the vehicle. This concern is most likely to be found in a cold weather areas just after the rapgard is removed at pdi. This may be caused by moisture which has been trapped and condensed between the paint and the rapgard. These types of stains can be removed with a heat gun or an infrared drier.
• 10100735Feb 4, 2015Equipment. Some vehicles may exhibit a knocking / squeaking noise from the front strut bearing (a) when driving on rough roads and/or when turning the steering wheel while the vehicle is stopped. The noise may be due to upper front strut bearing damage or it may be due to stick/slip between the front strut bearing and coil spring. To eliminate the noise, the following mass-production changes have been made: 1. The material…
• 10098885Nov 24, 2014Exterior lighting. When dealing with customer complaints of excessive condensation and/or water within the headlamp unit, first determine if all the bulb sockets are present and correctly installed. In most cases you will find that the bulb seal no. 1 (a) or hid bulb seal no. 1 (b) and bulb seal no.
• 10098895Nov 4, 2014Steering. Some customers may complain that the steering wheel is off center more than 3° even when driving straight on a flat road. Follow steering wheel alignment procedure.
• 10059471Nov 4, 2014Steering. Summary to be provided on a future date.
• 10098863Oct 17, 2014Equipment. Some vehicles may experience mil illumination with dtc p2610 (instrument cluster internal engine off timer performance problem) stored in memory after engine start and room fuse 15a (a) removed. Note:the odometer will display “f0-002” during transport mode (room fuse 15a removed). Transport mode is canceled when room fuse 15a is installed or the vehicle odometer is more than 12.4mi (20km).
• 10059444Oct 17, 2014Engine. Summary to be provided on a future date.
• 10098522Sep 26, 2014Electrical system. This service information provides basic q-85/t-110 battery handling procedures. Complete service information can be found in ms3 online or workshop manual (section 01-17).
• 10059424Sep 26, 2014Electrical system, Engine. Summary to be provided on a future date.

← All problems reported for the 2016 Mazda MAZDA6