1997 Mercury Mountaineer Recalls
NHTSA lists 6 recall campaigns for the 1997 Mercury Mountaineer. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.
- Vehicle speed controlCovers: Mercury Mountaineer 1997, 2002, Ford E-150 1992–2003, E-350 1992–2003 +12 more
Reported issue: Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 f53 vehicles equipped with the texas instruments speed control deactivation switch (scds). The scds may leak internally and then overheat, smoke, or burn.
Possible consequence: A vehicle fire could occur with or without the engine running.
Remedy: Ford will notify owners that dealers will install a fused wiring harness in line with the scds. On 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the abs control module connector and repair as necessary. Repairs will be completed free of charge. The safety recall began on october 27, 2009…
- Vehicle speed controlCovers: Mercury Mountaineer 1997–1998, Ford Explorer 1997–1998
Reported issue: Vehicle description: sport utility vehicles equipped with 4.0l sohc engines and still retain the original throttle body (part numbers 97jf-9e926ab or 97jf-9e926-ac). Some of the original throttle bodies installed allowed a gap between the plate and bore to be built too narrow. This reduced clearance allowed the engine deposits normally present in the throttle body to contact or bridge the gap. If the engine…
Possible consequence: This could result in engine surge when the accelerator pedal breaks free.
Remedy: Dealers will replace the original throttle bodies.
- SuspensionCovers: Mercury Mountaineer 1997, Ford Explorer 1995–1997
Reported issue: Vehicle description: sport utility vehicles. Under certain conditions, a front sway bar link can fracture.
Possible consequence: Vehicle handling could be affected, increasing the risk of a crash.
Remedy: Dealers will replace both the left and right front sway bar links.
- Fuel system, gasoline › Delivery › Hoses, lines/piping, and fittingsCovers: Mercury Mountaineer 1997–1998, Ford Explorer 1997–1998
Reported issue: Vehicle description: multi-purpose passenger vehicles equipped with 4.0l single overhead cam engines. The engine fuel lines can be damaged if the vehicle is jump started and the ground cable is attached to the fuel line bracket that is located near the battery. Since the bracket is not grounded, the stainless steel fuel line braid could act as a ground potentially overheating the ptfe inner liner of the fuel line…
Possible consequence: The fuel lines can leak, and in the presence of an ignition source, a fire could potentially result.
Remedy: Dealers will install a warning label on the fuel line bracket advising owners not to use it for a jump start ground. Also a revised bolt will be installed in the alternator bracket to provide a convenient jump start ground location.
- Structure › Body › Hatchback/liftgate › Support device/strutCovers: Mercury Mountaineer 1997, Ford Explorer 1996
Reported issue: Vehicle description: multi-purpose passenger vehicles. The liftgate assist gas cylinder bracket on the right hand bodyside outer panel was incorrectly welded.
Possible consequence: The gas cylinder bracket may not properly support the liftgate increasing the risk of personal injury.
Remedy: Dealers will reinforce the bracket attachment with two pop rivets.
- Vehicle speed controlCovers: Mercury Mountaineer 1996–1997, Ford Explorer 1996–1997
Reported issue: Vehicle description: multi-purpose passenger vehicles equipped with 5.0l engines originally sold or currently registered in the states of alaska, idaho, iowa, maine, michigan (upper peninsula only), minnesota, montana, nebraska, new hampshire, new york, north dakota, south dakota, vermont, wisconsin, and wyoming. These vehicles, when operated for extended periods of time at highway speeds and temperatures below -20…
Possible consequence: Although the vehicle can be controlled by either applying the service brakes or shifting the transmission to neutral, increased brake pedal efforts or some increase in stopping distance can result.
Remedy: Dealers will install a revised pcv system with water heated vacuum source.
← All problems reported for the 1997 Mercury Mountaineer
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.