2006 MINI Cooper S Technical Service Bulletins

49 technical service bulletins (TSBs) are on record for the 2006 MINI Cooper S. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10244507Oct 25, 2023Electrical system. MINI electrical systems have continued to develop over the past few years. As a result, the demand on the batteries has increased. Breakdowns due to an empty battery or problems in the vehicles electrical system can have various causes, most of which are not due to the battery itself. For this reason, a battery replacement will permanently eliminate the problem only in the rarest of cases. The energy diagnosis test…
• 10162443Jul 12, 2019Electrical system, Engine, Transmission and drivetrain. Programming a Replacement EGS Module with ISTA/P. Programming a replacement electronic transmission control module (EGS) with ISTA/P requires the manual entry of the correct target basic and programmed part numbers. Programming concept.
• 10145311Jun 1, 2018Equipment. NAVIGATION SYSTEM HAS MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for instance:
• 10143579May 1, 2018Equipment, Electrical system. NAVIGATION SYSTEM HAS MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for instance:
• 10134994Feb 1, 2018Transmission and drivetrain. Aisin automatic transmisison: right side output shaft seal replacement
• 10151228Mar 1, 2016Steering. This Service Information bulletin supersedes SI 32 02 14 dated August 2014. SUBJECT Installation of Right-Hand Drive Steering Spindle in Left-Hand Drive Vehicle is No Longer Required. Left-hand drive steering spindles are currently available.
• 10059112Jul 1, 2015Engine, Electrical system. Mini: because of the dme software, and a damaged clutch, the drivetrain malfunction check message appear.
• 10059098Jul 1, 2015Electrical system, Engine. Mini: different faults activates engine malfunction and oil warning.
• 10059113Jun 1, 2015Engine, Electrical system. Mini: faulty software causes the check control and engine power reduced light to appear.
• 10059111Jun 1, 2015Engine, Electrical system. Mini: due to faulty dme software, the service engine lights comes on, including the check control message for motor force decrease.
• 10059094Jun 1, 2015Engine. Mini: a mechanical failure and dme software error of the vanos actuators cause the engine to run rough which activates the malfunction warning light.
• 10057570Dec 1, 2014Engine cooling. Mini: some vehicles have turbocharger noise and a lack or loss of performance, due to restriction of turbocharger oil supply, resulting in oil starvation and seizing of turbocharger assembly. Model all.
• 10148439Nov 1, 2014Steering, Equipment. Electro-Hydraulic Power-Assist Steering Pump (EHPS) and Cooling Fan: Limited Warranty Extension to 13 Years/150,000 Miles. On affected vehicles, the electro-hydraulic power steering (EHPS) pump can fail.
• 10148394Aug 1, 2014Equipment, Steering. Installation of Right-Hand Drive Steering Spindle in Left-Hand Drive Vehicle. Supply shortage of left-hand drive steering spindles
• 10056114Jun 1, 2014Visibility (wipers, defrost, mirrors). Mini: there is a disconnection or kink, in wnidshield washer hose, which is too short, causing windshield front washer jet to fail. Model f56 (cooper, cooper s).
• 10056111Jun 1, 2014Equipment. Mini: information on parts warranty extension applying to previous qualifying repairs and no immediate repair required unless currently experiencing problem with cvt assembly or component. Model 2005-2008 cooper, cooper s.
• 10044680Jan 1, 2014Engine. Mini: on certain model vehicles, an engine oil leak may occur, due to the compromised oil pump volume control solenoid valve, from the underside of engine. No model years listed. *pe updated 4/19/2013. *kb updated 3/11/14.
• 10150204Nov 1, 2013Engine cooling. State Inspection and Emission (I/M) Test Fails Due to an Invalid VIN Number. The affected vehicle may fail to pass a State Inspection and Emission (I/M) test due to a noncompliant 17-digit vehicle identification number (VIN) stored in the DME (Digital Motor Electronic). The VIN read-out displayed on the state test printout does not match the actual VIN of the vehicle.
• 10150304Oct 1, 2013Engine cooling. State Inspection and Emission (I/M) Test Fails to Read 17-Character VIN. An affected vehicle may fail to pass a state-mandated Inspection and/or Emission (I/M) test due to a noncompliant 17-character vehicle identification number (VIN) being read out and displayed on the state's required tester report printout. In accordance with the OBD regulation, all MY 2005 and newer vehicles are required to support the display…
• 10053604Aug 1, 2013Equipment. Mini: there is a procedural error in the removing and installing or replacing high pressure pump current version that has been replaced with the corrected repair instruction portion for the n14 and n18 engine. Models r55, 56, 57, 58, 59, 60, 61. No model years listed.
• 10150044Jul 1, 2013Equipment, Steering. Electro-Hydraulic Power-Assist Steering Pump (EHPS) and Cooling Fan: Warranty Extension to 13 years/150,000 miles. On affected vehicles, the electro-hydraulic power steering (EHPS) pump can fail.
• 10150086Jun 1, 2013Steering, Equipment. Electro-Hydraulic Power-Assist Steering Pump (EHPS) and Cooling Fan: Warranty Extension to 13 years/150,000 miles. On affected vehicles, the electro-hydraulic power steering (EHPS) pump can fail.
• 10044719Jun 1, 2012Engine, Electrical system. Mini: there is a software error causing the service engine soon light to be illuminated that is related to valvetronic diagnostics. Models r55, r56, r58, r57, r60, r59. No model years listed.
• 10044699Jun 1, 2012Engine. Mini: when resealing engine oil pan, engine oil pan gasket replacement should no longer be used due to causing sealing flange becoming deformed. Models r55, r56, r59, r60, r57, and r58. No model years listed.
• 10043927Mar 1, 2012Air bags. Bmw mini: airbag warning light is on: mrs fc 02, 03, 05, 06.
• 10043725Jan 1, 2012Other or unknown, Latches, locks and linkages. Mini: after drive-away locking activates, it is not possible to unlock the boot.
• 10040372May 1, 2011Engine cooling. Bmw: the crimping process of the oxygen sensor could lead to an electrical failure inside the sensor. There may be a malfunction light on with a fault code stored.
• 10039593May 1, 2011Air bags. Bmw: the airbag warning light is on with a fault stored. The wiring under the seat may be pinched or damaged.
• 10026767Mar 1, 2011Engine cooling. Mini: turbocharger failure; oil supply line blockage. Loss of performance and turbocharger noise. *pe updated 8/16/11.
• 10040741Feb 1, 2011Engine cooling. Bmw: engine too hot message is displayed with stored trouble codes. The water pump doesnt power up.
• 10037305Nov 1, 2010Engine cooling. Bmw: description and specifications of crankcase ventilation system.
• 10035884Oct 1, 2010Fuel system, Engine cooling. Mini: teileclearing for n14/n18 engine drivability and fuel system. Enhanced technical support (teileclearing) process has been developed to help identify the root causes ofcustomer complaints relating to the n14/n18 drivability and fuel system *e.g., long crank, loss of power, ses lamp on, etc.). This process can also help expedite the defect eradication process, once the root cause has been determined. No model…
• 10041389Aug 1, 2010Fuel system. Bmw: service engine soon light may be on with stored trouble codes and reduced engine power. The high pressure fuel pump malfunctions.
• 10030669Mar 1, 2009Engine cooling. Mini: when replacing the cylinder head cover on a vehicle equipped with the new n14 engine, the cover will look different in appearance. The replacement cover is now equipped with a crankcase ventilation system pressure relief valve. No model years listed.
• 10030667Mar 1, 2009Exterior lighting. Mini vehicles: while driving or at idle, the headlamps flicker or sporadically move up or down by themselves. The headlamp wiring harness is damaged due to chaffing at the engine ground point.
• 10030164Mar 1, 2009Exterior lighting. Mini: while driving or at idle, the headlamps flicker or sporadically move up or down by themselves. The headlamp wiring harness is damaged due to chaffing at the engine ground point. R55 (cooper clubman, cooper s clubman); r56 (cooper, cooper s).
• 10026766Mar 1, 2009Body and structure, Latches, locks and linkages. Mini: rear split door opening problems. One or both of the rear split doors intermittently have functional problems. The door(s) may not unlatch when the lever on the handle is pulled or the latch may release unexpectedly without being pulled. *pe updated 7/10/09.
• 10022023Mar 1, 2009Engine cooling. Crankcase ventilation system - cold climate conditions. *kb updated on 10/17/07. *nj updated 6/15/09.
• 10028785Feb 1, 2009Fuel system. Mini: service engine soon or check gas cap warning is illuminated: tank leakage. Leakage is detected in the tank ventilation or evaporative system.
• 10026612Jul 1, 2008Engine cooling. Mini: fuel odor from the engine compartment. The high pressure pump (hdp) and/or the low pressure supply hose connection can allow fuel seepage, resulting in the fuel odor.
• 10026789Jun 1, 2008Equipment. Mini: check svs function. On certain vehicles, the voice input system (svs sa 620) does not function. The svs was not installed in the vehicles.
• 10025903Jun 1, 2008Transmission and drivetrain. Mini- r5 & r56 (cooper; cooper s) with getrag 6 speed manual transmission: complaint of an intermittent no-crank, no start situation. The clutch switch module has not been secured in the correct position on the clutch master cylinder.
• 10025846Jun 1, 2008Transmission and drivetrain. Mini: r55, r56 (cooper, cooper s) with f21 asin 6-speed automatic transmission - incorrect gear display.
• 10025844Jun 1, 2008Equipment. Mini: driver footwell area becomes hot. The hearter core pipes are poorly insulated. Model r56.
• 10025843Jun 1, 2008Steering, Exterior lighting. Mini: dsc indicator lamp active. R56 (cooper, cooper s) vehicles produced august 31, 2006 to july 22, 2007. The dsc indicator lamp (dynamic stability control) is active and the automatic turn signal reset is inoperative.
• 10024513Jan 1, 2008Engine cooling. Rattle noise from engine. From start of production up to april 11, 2007. With n14 engine.
• 10032985Dec 1, 2007Engine cooling. Mini: electric cooling fan runs after engine is shut off. After the engine is shut off, the electric cooling fan continues to run. Due to the operating strategy of the dme, the electric cooling fan may continue to run after the engine is shut off in two different scenarios. Engine coolant temp reaches 108 degrees celsius (due to heat soak), cooling fan will activate til coolant temp drops below 105 degrees celsius.
• 10032984Dec 1, 2007Body and structure. Mini: water leak from the front doors. After heavy rain, the carpet may be wet in the area near the rear of the front doors or in the footwell area. Water which is allowed to enter the vehicle at the top rear edge of the door is not able to drain out through the bottom of the door seal. As a result, the water travels along the door seal and into the passenger compartment.
• 10019988Apr 1, 2006Tires. Nitrogen inflated tires.

← All problems reported for the 2006 MINI Cooper S