2007 MINI Cooper S Technical Service Bulletins

114 technical service bulletins (TSBs) are on record for the 2007 MINI Cooper S. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10030164Mar 1, 2009Exterior lighting. Mini: while driving or at idle, the headlamps flicker or sporadically move up or down by themselves. The headlamp wiring harness is damaged due to chaffing at the engine ground point. R55 (cooper clubman, cooper s clubman); r56 (cooper, cooper s).
• 10026766Mar 1, 2009Body and structure, Latches, locks and linkages. Mini: rear split door opening problems. One or both of the rear split doors intermittently have functional problems. The door(s) may not unlatch when the lever on the handle is pulled or the latch may release unexpectedly without being pulled. *pe updated 7/10/09.
• 10028785Feb 1, 2009Fuel system. Mini: service engine soon or check gas cap warning is illuminated: tank leakage. Leakage is detected in the tank ventilation or evaporative system.
• 10026612Jul 1, 2008Engine cooling. Mini: fuel odor from the engine compartment. The high pressure pump (hdp) and/or the low pressure supply hose connection can allow fuel seepage, resulting in the fuel odor.
• 10026789Jun 1, 2008Equipment. Mini: check svs function. On certain vehicles, the voice input system (svs sa 620) does not function. The svs was not installed in the vehicles.
• 10025903Jun 1, 2008Transmission and drivetrain. Mini- r5 & r56 (cooper; cooper s) with getrag 6 speed manual transmission: complaint of an intermittent no-crank, no start situation. The clutch switch module has not been secured in the correct position on the clutch master cylinder.
• 10025846Jun 1, 2008Transmission and drivetrain. Mini: r55, r56 (cooper, cooper s) with f21 asin 6-speed automatic transmission - incorrect gear display.
• 10025844Jun 1, 2008Equipment. Mini: driver footwell area becomes hot. The hearter core pipes are poorly insulated. Model r56.
• 10025843Jun 1, 2008Exterior lighting, Steering. Mini: dsc indicator lamp active. R56 (cooper, cooper s) vehicles produced august 31, 2006 to july 22, 2007. The dsc indicator lamp (dynamic stability control) is active and the automatic turn signal reset is inoperative.
• 10025623Jan 1, 2008Tires. The tire warning illuminated due to low ambient temperature. Models r52 (cooper and cooper s) from 9/07 and r56 (cooper and cooper s) from 8/07.
• 10024513Jan 1, 2008Engine cooling. Rattle noise from engine. From start of production up to april 11, 2007. With n14 engine.
• 10032985Dec 1, 2007Engine cooling. Mini: electric cooling fan runs after engine is shut off. After the engine is shut off, the electric cooling fan continues to run. Due to the operating strategy of the dme, the electric cooling fan may continue to run after the engine is shut off in two different scenarios. Engine coolant temp reaches 108 degrees celsius (due to heat soak), cooling fan will activate til coolant temp drops below 105 degrees celsius.
• 10032984Dec 1, 2007Body and structure. Mini: water leak from the front doors. After heavy rain, the carpet may be wet in the area near the rear of the front doors or in the footwell area. Water which is allowed to enter the vehicle at the top rear edge of the door is not able to drain out through the bottom of the door seal. As a result, the water travels along the door seal and into the passenger compartment.
• 10024507Dec 1, 2007Electrical system. Service action: repair or retrofit ibs battery sensor.

← All problems reported for the 2007 MINI Cooper S